x series with advance micro - Sunbelt Transport Refrigeration

LIST OF ILLUSTRATIONS (Continued)FIGURE NUMBERPageFigure 9--15. Blower Wheel And Nozzle Cover Assembly .......................................... 9--23Figure 9--16. Thermostatic Expansion Valve Bulb and Thermocouple ................................ 9--25Figure 9--17. Vacuum Pump Connection ......................................................... 9--26Figure 9--18. Pressure Switch and Sensor ....................................................... 9--28Figure 9--19. Compressor Drive Assembly ....................................................... 9--29Figure 9--20. Oil Level in Sight Glass ............................................................ 9--30Figure 9--21. Compressor ..................................................................... 9--31Figure 9--22. Unloader Valve ................................................................... 9--32Figure 9--23. Discharge Check Valve (Serviceable) Prior to S/N JAW90756460 ....................... 9--32Figure 9--24. Discharge Check Valve (Non-Serviceable) Beginning With S/N JAW90756460 ............ 9--32Figure 9--25. Hot Gas Check Valve (Non-Serviceable) ............................................. 9--33Figure 9--26. Typical Setup for Testing High Pressure Switch ....................................... 9--34Figure 9--27 Discharge Pressure Transducer Values .............................................. 9--35Figure 9--28 Suction Pressure Transducer Values ................................................ 9--37Figure 9--29. SV2/SV4 Solenoid Valves .......................................................... 9--38Figure 9--30. SV-2/SV-4 MARKING ............................................................. 9--39Figure 9--31. SV1 Solenoid Valve ............................................................... 9--40Figure 9--32 Suction modulation valve (CSMV) ................................................... 9--41Figure 9--33 CSMV Coil ....................................................................... 9--42Figure 9--34. Defrost Air Switch Test Setup ...................................................... 9--44Figure 9--35. Unidrive Torque Requirements -- Non ESC Engine .................................... 9--48Figure 9--36. Unidrive Torque Requirements -- Electronic Speed Control Engine ....................... 9--49Figure 10--1. ESC Diagnostic Tree -- 1 Long, 1 Short LED Code .................................... 10--9Figure 10--2. ESC Diagnostic Tree -- 2 Long, 1 Short LED Code .................................... 10--10Figure 10--3. ESC Diagnostic Tree -- 2 Long, 3 Short LED Code .................................... 10--11Figure 10--4. ESC Diagnostic Tree -- 2 Long, 7 Short LED Code .................................... 10--12Figure 10--5. Micro Diagnostic Tree -- Cond. 1 -- Start/Run-Off Switch On -- Unit Does Not Operate ...... 10--14Figure 10--6. Micro Diagnostic Tree -- Cond. 2 -- Start/Run-Off Switch On -- Unit Operates But Not Properly 10--15Figure 10--7. Micro Diagnostic Tree -- Cond. 3 -- Start/Run-Off Switch Off -- Unit Fails To Stop .......... 10--16Figure 10--8. Micro Diagnostic Tree -- Cond. 4 -- Unit Will Not Run In High Speed ..................... 10--17Figure 10--9. Micro Diagnostic Tree -- Cond. 5 -- Unit Will Not Run In Low Speed ...................... 10--18Figure 10--10. Micro Diagnostic Tree -- Cond. 6 -- Data Recorder Data Download ProblemsWhen Using ReeferManager and a Download Cable. Data File AnalysisProblems Using Reports ........................................................... 10--19Figure 10--11. Microprocessor Diagnostic Tree -- PC Card Problems ................................. 10--20Figure 10--12. Micro Diagnostic Tree -- Cond. 8 -- Programming Problems With PC Cards .............. 10--21Figure 10--13. Micro Diagnostic Tree -- Cond. 9 -- Programming Problems With MicroProgrammer ....... 10--22Figure 10--14 Compressor Diagnostics .......................................................... 10--26xiii62--10683