INSTALLATION & OPERATING INSTRUCTIONS ... - Johnstone Supply

More documents

Recommendations

Info

HOUSEHOLD CO ALARMS. CURRENT LIMITATIONS TO THEIR EFFECTIVENESS REQUIRESTHAT YOU OTHERWISE CONTINUE TO FOLLOW APPROPRIATE INSTRUCTIONS LOCATED INTHE “INSTALLATION & OPERATING INSTRUCTIONS” AND “USERS INFORMATION” MANUALSRELATING TO PROTECTING PERSONS FROM THE RISKS OF CARBON MONOXIDE. REVIEWEACH CO MANUFACTURERS’ EXPLANATION OF THEIR UNIT’S CAPABILITIES AND FOLLOWTHOSE INSTALLATION AND OPERATING MANUAL WHEN INSTALLING AND OPERATINGTHESE UNITS.WARNINGTHE CIRCULATING AIR DUCTS MUST BE COMPLETELY AND POSITIVELY SEALED TOPREVENT COMBUSTION PRODUCTS, INCLUDING CARBON MONOXIDE, FROM ENTERINGTHE AIR STREAM.WARNINGTO ENSURE PROPER INSTALLATION AND OPERATION OF THIS PRODUCT, COMPLETELYREAD AND UNDERSTAND THESE INSTRUCTIONS PRIOR TO ATTEMPTING TO ASSEMBLE,INSTALL, MAINTAIN, OR REPAIR. IF THESE INSTRUCTIONS ARE NOT FOLLOWED PRECISELYTHERE IS A POTENTIAL OF CARBON MONOXIDE POISONING, WHICH CAN RESULT INSERIOUS ILLNESS OR DEATH.WARNINGTHIS FURNACE WAS EQUIPPED AT THE FACTORY FOR USE WITH NATURAL GAS ONLY. L.P.CONVERSION, IF REQUIRED, MUST BE PERFORMED BY A QUALIFIED TECHNICIAN FAMILIARWITH PERFORMING THIS TYPE OF CONVERSION. IF L.P. CONVERSION IS REQUIRED, ALLINSTRUCTIONS INCLUDED WITH THE FACTORY AUTHORIZED KIT MUST BE FOLLOWED. THEONLY KIT THAT MUST BE USED FOR THIS CONVERSION IS THE FACTORY AUTHORIZEDLPM-03 (GSM) OR LPM-04 (GSMS). FAILURE TO FOLLOW THOSE INSTRUCTIONS EXPLICITLYMAY CAUSE FIRE, EXPLOSION, OR PERSONAL INJURY AND PROPERTY DAMAGE.WARNINGIF PROHIBITED BY LOCAL CODE, DO NOT INSTALL A LIQUID PETROLEUM GAS BURNINGAPPLIANCE IN A PIT, BASEMENT, OR SIMILAR LOCATION WHERE, L.P., A HEAVIER THAN AIRGAS, CAN COLLECT IN LOW AREAS AND MAY NOT DISPERSE NATURALLY. APPLIANCESSO FUELED SHALL NOT BE INSTALLED IN AN ABOVE GRADE UNDER FLOOR SPACE ORBASEMENT UNLESS SUCH LOCATION IS PROVIDED WITH APPROVED MEANS FORREMOVAL OF UNBURNED GAS.GENERAL INFORMATIONThese Installation and Operating Instructions are intended for use by fully qualified installationtechnicians. Some localities require the installer/servicer to be licensed. If in doubt, check with localauthorities. The GSM furnace is a two stage heating appliance. For optimum use, the GSM furnaceshould use a two stage room thermostat. The GSMS furnace is a single stage furnace and uses asingle stage room thermostat.IO-176 4
INSTALLATION: In the USA this furnace MUST be installed in accordance with the latest edition ofthe ANSI Z223.1 booklet entitled “National Fuel Gas Code” (NFPA 54), and the requirements orcodes of the local utility or other authority having jurisdiction. In Canada this furnace must be installedin accordance with the current CAN/ CGA-B149.1 & 2 Gas Installation Codes, local plumbing orwaste water codes and other applicable codes.ANNUAL inspection of the furnace and it’s vent system are strongly recommended. It is the installer’sresponsibility to inform the user of this importance.Additional helpful publications are available from the NFPA are, NFPA 90A - Installation of AirConditioning and Ventilating System and NFPA90B - Warm Air Heating and Air ConditioningSystem. These publications are available from:National Fire Protection Association, Inc.Batterymarch ParkQuincy, MA 02269These furnaces meet the California NOX emission standards and the California efficiency standards.The GSM & GSMS furnace may be installed as either a Direct Vent or Non-Direct Vent Furnace.These furnaces are designed to be an UPFLOW or HORIZONTAL furnace. The following sketchshows a typical installation:TYPICAL UPFLOWINSTALLATIONDRAINHOSEIO-176 5
Page 1: INSTALLATION & OPERATINGINSTRUCTION
Page 6 and 7: LOCATIONDO NOT install this furnace
Page 9 and 10: When installed as a direct vent fur
Page 11 and 12: HORIZONTAL THROUGH THE WALL VENTING
Page 13 and 14: Note: Some local codes require this
Page 15 and 16: CAUTIONIf the local utility permits
Page 17 and 18: CONTROL VOLTAGE CONNECTIONSTHERMOST
Page 19 and 20: TIMING THE GAS METERUse the followi
Page 21 and 22: BLOWER DOOR INTERLOCK SWITCHThe pur
Page 23 and 24: SEQUENCE OF OPERATIONThis appliance
Page 25 and 26: INSPECTING & CLEANING THE HEAT EXCH
Page 27 and 28: GSMS ONLYIO-176 27
Page 29: These instructions are also on the

INSTALLATION & OPERATING INSTRUCTIONS ... - Johnstone Supply

Create successful ePaper yourself

Delete template?

Save as template?