Abstract SCHIRACK, ANDRIANA VAIS. The Effect of Microwave ...

More documents

Recommendations

Info

caused the increased intensity of burnt and stale/floral characteristics noted by the descriptive sensory panel. These compounds were only a small fraction of over 200 aroma-active compounds which were found to contribute to roasted peanut flavor using GC/O. Increased and unfavorable levels of these compounds may have been formed through Maillard reactions and thermal degradation during the high temperatures reached in microwave blanching. This research also confirmed the importance of Maillard reaction and lipid oxidation compounds in the peanut flavor profile. However, as the results show, even increased concentrations of compounds which are commonly found in good quality peanuts can lead to an imbalance in the flavor profile and cause the perception of an off-flavor. This research has helped improve the peanut lexicon, and has further characterized the extraction techniques best suited for the volatile analysis of peanuts. The analysis of an off-flavor that was difficult to define was made possible through the introduction of the total offnote term to the peanut lexicon, which was used successfully to differentiate the effects of microwave treatments. Further additions were made to the lexicon, such as the attribute “ashy”, which was referenced by the aroma of cigarette ash. In instrumental analysis, solvent extraction and SAFE were deemed more suitable than static headspace methods for analysis of aroma-active peanut compounds generated during the high temperatures in microwave blanching, indicating that compounds of higher molecular weight and moderate volatility had the highest impact on flavor. This research is important because it illustrates the importance of the relative concentrations of the many aroma-active compounds found in peanuts. Although 180
microwave technology may provide many advantages during blanching, its effects on the formation of flavor compounds must be considered. This research could aid in training sensory panels to evaluate processing-related off-flavors, because guaiacol and phenylacetaldehyde could be used as chemical standards to define the burnt/ashy and stale/floral off-flavors which can occur during high temperature processing. Through this project, it was determined that it is possible to achieve acceptable blanchability in peanuts using microwave blanching while minimizing the possibility of an off-flavor. 181
Page 1 and 2:
Abstract SCHIRACK, ANDRIANA VAIS. T
Page 3 and 4:
THE EFFEGT OF MICROWAVE BLANCHING O
Page 5 and 6:
BIOGRAPHY Andriana Schirack is orig
Page 7 and 8:
TABLE OF CONTENTS v Page List of Ta
Page 9 and 10:
Materials and Methods..............
Page 11 and 12:
Table 3 High Impact Aroma-Active Co
Page 13 and 14:
CHAPTER 1: INTRODUCTION 1
Page 15 and 16:
The processing parameters used duri
Page 17 and 18:
educed from 35-40% moisture to 8-10
Page 19 and 20:
REFERENCES Adelsberg GD, Sanders TH
Page 21 and 22:
Interdependency and underlying dime
Page 23 and 24:
Composition of Peanuts The structur
Page 25 and 26:
and Burma. The peanut prices in the
Page 27 and 28:
(w.b.) within 3 days, large quality
Page 29 and 30:
cdry = Specific heat of dry seeds (
Page 31 and 32:
there is no direct correlation publ
Page 33 and 34:
Peanuts are commonly stored in flat
Page 35 and 36:
lanching has been imitated using a
Page 37 and 38:
(1999), no detrimental effects of b
Page 39 and 40:
when the air is distributed from ab
Page 41 and 42:
y-product (Giese, 1992). Drying is
Page 43 and 44:
the material to absorb electromagne
Page 45 and 46:
ε' = Relative real permittivity (d
Page 47 and 48:
oils, both ε' and ε" are low and
Page 49 and 50:
1969). The flavor characteristics o
Page 51 and 52:
et al., 1980). Likewise, sugars pre
Page 53 and 54:
n-methylpyrrole. Walradt et al. (19
Page 55 and 56:
fact, Ory et al. (1992) suggested t
Page 57 and 58:
Flavor Research in Other Nuts Sever
Page 59 and 60:
changed with time of roasting and i
Page 61 and 62:
polyunsaturated acids that have a c
Page 63 and 64:
hexanal are intensified to the high
Page 65 and 66:
The results of temperature stress i
Page 67 and 68:
Brown et al. (1977) found that the
Page 69 and 70:
exhibited the fruity fermented off-
Page 71 and 72:
(Pawliszyn, 2000). Also, the elevat
Page 73 and 74:
compounds eluting from microwave-he
Page 75 and 76:
Table 1: Peanut Volatile Analysis b
Page 77 and 78:
the identification of volatile comp
Page 79 and 80:
the detector. The compounds can the
Page 81 and 82:
GC-O Applications High vacuum disti
Page 83 and 84:
each half was allocated into one of
Page 85 and 86:
Woody/Hulls/Skins Cardboard Table 2
Page 87 and 88:
Givaudan-Roure developed Quantitati
Page 89 and 90:
during high temperature microwave b
Page 91 and 92:
OVM Organic volatiles meter Pa Pasc
Page 93 and 94:
References Abegaz EG, Kerr WL, Koeh
Page 95 and 96:
odorants in high temperature cured
Page 97 and 98:
17(4): 728-732. Mason ME, Waller GR
Page 99 and 100:
partitioning constants and release
Page 101 and 102:
Vercellotti JR, Crippen KL, Lovegre
Page 103 and 104:
ABSTRACT Peanut blanching consists
Page 105 and 106:
peanut moisture content from 5.5 to
Page 107 and 108:
The computer monitored power output
Page 109 and 110:
RESULTS AND DISCUSSION Energy Absor
Page 111 and 112:
All treatments using the fan (F) ha
Page 113 and 114:
Treatments 11NF, 8NF, and 5NF also
Page 115 and 116:
lanchabilities as well as a longer
Page 117 and 118:
microwave attain much higher temper
Page 119 and 120:
REFERENCES ADELSBERG, G.D. and SAND
Page 121 and 122:
TABLES AND FIGURES Table 1: Process
Page 123 and 124:
Energy absorbed (kJ) 3000 2500 2000
Page 125 and 126:
Temperature of peanuts (°C) 160 14
Page 127 and 128:
Percent blanchability 100 90 80 70
Page 129 and 130:
Maximum internal temperature (°C)
Page 131 and 132:
ABSTRACT Microwave blanching of pea
Page 133 and 134:
Several methods are used for blanch
Page 135 and 136:
Peanuts MATERIALS AND METHODS Mediu
Page 137 and 138:
Canada) on a laptop computer (Dell
Page 139 and 140:
Sensory Analysis RESULTS AND DISCUS
Page 141 and 142: significantly lower final moisture
Page 143 and 144: ACKNOWLEDGMENTS Funded in part by t
Page 145 and 146: Foods and Beverages, Vol. 29, (G. C
Page 147 and 148: TABLE LEGENDS Table 1. Microwave ap
Page 149 and 150: TABLE 2. LEXICON OF PEANUT FLAVOR D
Page 151 and 152: Sweet Aromatic TABLE 4. CORRELATION
Page 153 and 154: CHAPTER 5: CHARACTERIZATION OF AROM
Page 155 and 156: Introduction The most common use of
Page 157 and 158: The objective of this study was to
Page 159 and 160: attributes which were different fro
Page 161 and 162: Volatile compounds from the solvent
Page 163 and 164: 0.25 μm df; J & W Scientific, Fols
Page 165 and 166: adjusted with the same concentratio
Page 167 and 168: characterized by the attributes of
Page 169 and 170: (E,E)-2,4-decadienal (fried/oxidize
Page 171 and 172: flavor dilution factors, nor did th
Page 173 and 174: that of the control, but only in th
Page 175 and 176: e high enough for pyrazine formatio
Page 177 and 178: sensory panelists analyzing process
Page 179 and 180: References (ASTM) American Society
Page 181 and 182: Megahed MG. 2001. Microwave roastin
Page 183 and 184: Vercellotti JR, Mills OE, Bett KL,
Page 185 and 186: Table 2- Model system concentration
Page 187 and 188: 28 4-acetoxy-2,5-dimethyl- 3(2H)-fu
Page 189 and 190: Table 5 - Quantification, sensory o
Page 191: Conclusions This research investiga
Page 195 and 196: protect against colon, prostate, an
Page 197 and 198: APPENDICES 185
Page 199 and 200: SAFE (3 SAFE's can be done in 1 day
Page 201 and 202: 2. Turn off waterbath. 3. Turn off
Page 203 and 204: 5. Filter through a third sodium su
Page 205 and 206: contamination, and run a blank on t
Page 207 and 208: AC nutty/burnt 975 1.5 NB cabbage/g
Page 209 and 210: AC oxidized 1289 1.5 NB dusty/nutty
Page 211 and 212: NB brothy 1612 3.5 NB honey/hay 161
Page 213 and 214: Table 2: Aroma-Active Compounds in
Page 215 and 216: AC cedar 1081 3.0 AC burnt sugar/nu
Page 217 and 218: AC brothy 1350 2.0 NB garlic 1352 5
Page 219 and 220: NB fruity/floral 1670 3.0 NB rosy 1
show all

Abstract SCHIRACK, ANDRIANA VAIS. The Effect of Microwave ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?