phb2013_complete_en.pdf [18.3 MB] - WÃ¶hner

More documents

Recommendations

Info

SECUR®LeanStreamer, NH in-line disconnectors for fuses IEC 60269-2 / VDE 0636-2 size 00 VDE 0660 part 107 / EN 60 947-3 / IEC 60 947-3 3-pole switching Outgoing connection top and bottom. Arc chamber. Shock-protected even with lid open and in park position. Mechanical fuse retention. Degree of protection IP30 (front side), degree of protection near terminal depends on installation. Connection contacts: – M8 screw; 2x M5 clamp, 12mm clear width – Prism clamp terminal Cu, Al* 16 - 70mm 2 s(r), s(s), f +AE (* Connections with aluminium conductors are not maintenance-free (see page 8/2) For 60mm distance between busbar centres: – screwless busbar contacting For 100mm distance between busbar centres: – screw-on connection to drilled busbars, screw M8 – mounting without drilling using a terminal clamp For 185mm distance between busbar centres: – with an adapter for screwing onto undrilled busbars, screw M12 mounting without drilling using a terminal clamp – with a double adapter for screwing onto drilled busbars, screw M12 Type 3-pole switching Type of current AC (50 - 60Hz) Rated operating voltage (Ue)** 690V AC Rated insulation voltage (Ui)** 1000V Rated surge withstand capacity (Uimp) without fuse monitoring** 8kV Rated operating current (Ie)* 160A Utilisation categories AC-22B (690V) without fuse monitoring** AC-23B (400V) AC-23B (500V 125A) Conditional rated short-circuit current*** 50kA For VDE 0636-2 NH fuses of all operating classes with power dissipation per phase * During continuous operation, the rated load factor specifi ed according to VDE 0660 part 500/EN 60 439-1, table 1, must be observed. 12W For AC-23B, the distance to earthed parts must be at least 50mm at the top and 25mm at the side. ** Fuse monitoring Ue, Ui 400V AC, Uimp 4kV, level of soiling: 2 (mains connections) *** Type tested with fuses of characteristic gL/gG. Pilot switch for lid position indication: 2 (changeover) switches can be used Rated operating voltage (rated operating current) 250V AC (5A), 30V DC (4A) Electronic fuse monitoring: 2 LEDs with latching properties or remote reset, programmable using 2 changeover switches 2 x Cu 2.5mm 2 solid conductors, DIN 46 288 or 2 x Cu 1.5mm 2 stranded conductors with sleeves, DIN 46 228-1/-2/-3 The internal resistance of the measuring needle lies above the MOhm level and thereby meets VDE requirements regarding contact voltage (>1000 Ohm/V.) To release turn off the upstream main switch. Circuit diagram on page 9/25 8 33
NH Bus-Mounting Fuse Block 690V ˜ /440Vfor fuses IEC 60269-2 / VDE 0636-2 size 00 100mm-System 3-pole Up to 160A Connection below and above. Bus contact: – for fi xing to drilled busbars, M8 screw – undrilled assembly clamp locks Connection contacts: – prism connection terminals Cu, Al* 16 - 70mm 2 s(r), s(s), f +AE * Connections with aluminium conductors are not maintenance-free (see page 8/2). SECUR®LeanStreamer, NH fuse block 690V ˜ /440V- for fuses IEC 60269-2 / VDE 0636-2 size 1–2–3 185mm-System power 3-pole Size 1 to 250A/size 2 to 400A/size 3 to 630A For screwing onto drilled busbars. Optional mounting on undrilled busbars. Cable connections at bottom. Shock protection. Connection space covers. Busbar contact with screws: Screw M12. drill – less contact with clamp bracket. busbars (10mm thick), profi le bars. Short-circuit capability up to 50kA with fuse links gL/gG. Technical specifications 8 34
Page 1 and 2:
Product manual 2013English
Page 3 and 4:
wöhnervision - the Wöhner magazin
Page 5 and 6:
DEAR READERS, All over the world, t
Page 7 and 8:
2963 METRES is the height of the Zu
Page 9 and 10:
BAD ESSEN OSNABRÜCK SIEGEN BIRKENH
Page 11 and 12:
2012 Wöhner presents its latest in
Page 13 and 14:
GEOTHERMAL MADE IN GERMANY THE SUST
Page 15 and 16:
THE CAR BEER The German purity law
Page 17 and 18:
ROBERT BOSCH The electrical enginee
Page 19 and 20:
Picture: The Bauhaus archive in Ber
Page 21 and 22:
GIESECKE & DEVRIENT NAUF BURDA FABE
Page 23 and 24:
MADE IN GERMANY THE LITERARY DUET W
Page 25 and 26:
MADE IN GERMANY FORMS IN MOTION It
Page 27 and 28:
43% is the alcohol content of the s
Page 29 and 30:
Editorial information EDITORIAL INF
Page 31 and 32:
New from Wöhner. Global control of
Page 33 and 34:
AMBUS®EasyLiner PV 1000V DC fuse h
Page 35 and 36:
1 2 3 4 5 6 7 8 9 10 60mm-System co
Page 38 and 39:
System advantages With an installed
Page 40 and 41:
1/1 60mm-System compact, 3-pole, sy
Page 42 and 43:
Page 44 and 45:
Page 46 and 47:
Know-how
Page 48 and 49:
System advantages The 60mm busbar s
Page 50 and 51:
2/1 01 485 01 131 01 484 01 356 01
Page 52 and 53:
2/3 01 232 01 422 01 231 01 132 01
Page 54 and 55:
2/5 60mm-System classic 630A (800A)
Page 56 and 57:
2/7 01 071 01 070 01 069 01 759 01
Page 58 and 59:
2/9 01 907 01 906 01 185 01 047 01
Page 60 and 61:
EQUES®MotorController 2/11 with re
Page 62 and 63:
2/13 32 477 32 486 32 464 32 485 32
Page 64 and 65:
EQUES®PowerConnector 2/15 32 157 3
Page 66 and 67:
2/17 36 209 36 108 36 105 36 102 36
Page 68 and 69:
2/19 31 158 01 981 01 424 01 980 01
Page 70 and 71:
2/21 31 963 31 955 31 958 31 960 31
Page 72 and 73:
2/23 CrossLink® Technology, module
Page 74 and 75:
2/25 CrossLink® Technology, module
Page 76 and 77:
2/27 33 156 33 914 33 908 33 911 Ac
Page 78 and 79:
2/29 33 063 33 602 33 601 QUADRON®
Page 80 and 81:
Accessories for QUADRON®CrossLinkB
Page 82 and 83:
2/33 SECUR®LeanStreamer size 00, N
Page 84 and 85:
System components 4-pole 2/35 31 96
Page 86:
Expertise 185mm-System power 2500A
Page 89 and 90:
The universal busbar support allows
Page 91 and 92:
3/2 33 341 01 906 01 907 01 185 01
Page 93 and 94:
3/4 33 097 33 099 33 093 33 095 33
Page 95 and 96:
3/6 33 126 33 292 33 300 33 373 Acc
Page 97 and 98:
3/8 185mm-System power 2500A 3 8
Page 99 and 100:
3/10 SECUR®LeanStreamer size 00, N
Page 101 and 102:
Safety 4
Page 103 and 104:
Centre feed unit up to 4000A Centre
Page 105 and 106:
4/2 CRITO®PowerClip, brace termina
Page 107:
4/4 Centre feed unit up to 4000A 4
Page 110 and 111:
For conventional wiring, Wöhner of
Page 112 and 113:
5/1 31 971 31 973 31 555 31 548 AMB
Page 114 and 115:
5/3 03 290 03 288 03 289 03 294 03
Page 116 and 117:
5/5 31 286 31 288 31 014 TRITON® 3
Page 118 and 119:
5/7 31 110 31 123 31 273 31 258 AMB
Page 120 and 121:
31 014 Accessories 5/9 31 012 01 19
Page 122 and 123:
5/11 31 295 31 296 31 297 31 298 AM
Page 124 and 125:
5/13 03 351 03 760 79 449 79 448 NH
Page 126 and 127:
Panel-mounting components Switchgea
Page 128 and 129:
QUADRON®CrossLinkBreaker Disconnec
Page 130 and 131:
MOTUS®ContactronControl 6/1 36 209
Page 132 and 133:
QUADRON®CrossLinkSwitch 6/3 33 552
Page 134 and 135:
QUADRON®CrossLinkBreaker NH fuse s
Page 136 and 137:
6/7 33 142 33 418 33 155 33 154 Acc
Page 138 and 139:
CAPUS®EasyUse 6/9 33 336 33 352 33
Page 140 and 141:
CAPUS®EasyUse 6/11 33 928 33 449 3
Page 142 and 143:
CAPUS®EasyUse 6/13 33 937 33 470 3
Page 144 and 145:
CAPUS®PowerFuse 6/15 33 340 33 352
Page 146 and 147:
Network
Page 148 and 149:
MOTUS®ContactronControl 7/1 36 111
Page 150 and 151:
7/3 01 138 33 075 01 890 01 888 01
Page 152 and 153: 01 127 7/5 01 114 01 928 08 824 08
Page 154 and 155: 7/7 01 196 01 612 01 613 01 298 01
Page 156 and 157: D0 fuses as per DIN VDE 0636-3 / IE
Page 158 and 159: NH fuses as per DIN VDE 0636-2 / IE
Page 160 and 161: 31 185 Cylindrical gG fuses Fuse li
Page 162 and 163: 31 209 Cylindrical gG fuses Fuse li
Page 164 and 165: 31 252 Cylindrical class CC fuses F
Page 166 and 167: 7/19 31 353 31 363 03 231 03 236 Cy
Page 169 and 170: Technical data Research 8
Page 171 and 172: Note on operating NH fuse switch di
Page 173 and 174: CE marking Wöhner products are sub
Page 175 and 176: Busbars, in compliance with EN 1360
Page 177 and 178: Universal conductor terminals Unive
Page 179 and 180: Clip-on screw connector The clip-on
Page 181 and 182: EQUES®EasyConnector EQUES®MotorCo
Page 183 and 184: MOTUS®ContactronControl Compact mo
Page 185 and 186: SECUR®PowerLiner, bus-mounting fus
Page 187 and 188: D02 bus-mounting fuse base, CUSTO®
Page 189 and 190: AMBUS®PowerSwitch, disconnectors w
Page 191 and 192: AMBUS®EasySwitch Class CC, Holder
Page 193 and 194: QUADRON®CrossLinkCarrier, NH fuse
Page 195 and 196: QUADRON®CrossLinkBreaker, QUADRON
Page 197 and 198: Conductor connections: Size Screw C
Page 199 and 200: QUADRON®CrossLinkSwitch NH busbar-
Page 201: QUADRON®CrossLinkSwitch Bus-mounti
Page 205 and 206: Technical specifications Size 1 2 3
Page 207 and 208: CAPUS®EasyUse Switch Disconnectors
Page 209 and 210: To IEC/EN 60947-3 800A 1250A 1600A
Page 211 and 212: Short-circuit withstand capacity di
Page 213 and 214: Short-circuit strength diagrams acc
Page 215 and 216: Part no. Rated operating Voltage U
Page 225 and 226: Part no. Type no. USA 01 240 240-L
Page 227 and 228: Part no. Type no. USA 03 228 03 229
Page 233: Approvals 8 64
Page 236 and 237: 01 272 01 068 01 203 01 284 01 285
Page 238 and 239: 01 364 01 367 01 370 01 426 01 427
Page 240 and 241: 01 495 01 485 01 484 01 500 01 357
Page 242 and 243: 01 116 01 231 01 236 01 237 01 238
Page 244 and 245: 01 539 01 540 01 596 a b c 180 146
Page 246 and 247: 01 068 01 203 01 284 01 285 01 287
Page 248 and 249: 32 429 32 430 32 431 32 432 32 433
Page 250 and 251: 32 137 32 138 32 140 32 156 32 157
Page 252 and 253:
03 520 03 518 33 402 33 421 33 422
Page 254 and 255:
03 654 03 656 33 216 a b c d e x 03
Page 256 and 257:
33 160 33 161 33 162 33 325 33 326
Page 258 and 259:
33 910 33 911 33 510 33 511 33 516
Page 260 and 261:
NH fuse switch disconnector with el
Page 262 and 263:
01 034 01 092 01 206 01 207 01 218
Page 264 and 265:
33 235 33 236 33 087 33 088 33 089
Page 266 and 267:
31 286 31 293 31 173 31 175 31 176
Page 268 and 269:
31 115 - 31 119 31 135 - 31 138 31
Page 270 and 271:
33 409 Centre line of connection a
Page 272 and 273:
03 350 03 351 03 354 03 355 03 749
Page 274 and 275:
33 149 33 150 33 151 33 201 33 202
Page 276 and 277:
33 502 33 542 33 505 33 545 33 910
Page 278 and 279:
33 333 33 334 33 335 33 336 33 424
Page 280 and 281:
33 430 33 431 33 432 33 433 33 434
Page 282 and 283:
33 437 33 438 33 439 33 452 33 453
Page 284 and 285:
33 458 33 459 33 460 33 461 33 462
Page 286 and 287:
05 779 05 780 05 781 05 782 05 783
Page 288:
Appendix Co-operation
Page 291 and 292:
Terms of Sale and Delivery 3. Tool
Page 293 and 294:
Terms of Sale and Delivery IX. Othe
Page 295 and 296:
Part no. Amount Amount of copper of
Page 297 and 298:
Page 299 and 300:
Page 301 and 302:
Page 303 and 304:
Page 305 and 306:
Page 307 and 308:
Wöhner-Group worldwide Worldwide b
Page 309 and 310:
Wöhner-Group worldwide Malaysia Pe
Page 311 and 312:
Wöhner-Group Europe Europe-wide br
Page 313 and 314:
Wöhner-Group Europe Republic of Be
Page 315 and 316:
Representatives in Germany 03 Ingen
Page 317:
Notes Notes 10 28
Page 320:
Woehner (UK) Limited · Electrotech
show all

phb2013_complete_en.pdf [18.3 MB] - WÃ¶hner

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?