Hazardous Materials Shipping Guide - Industrial Safety and Hazmat ...

Recommendations

Info

Sym- bols FedEx Ground Hazardous Materials Table D.O.T. Basic Description for Hazardous Material Shipments Packaging (§173.***) Hazardous materials descriptions and proper shipping names Hazard class or Division Identifi- cation Numbers PG Label codes Special provisions Exceptions NonBulk FedEx Ground Restrictions (1) (2) (3) (4) (5) (6) (7) (8A) (8B) (9) G Insecticide gases, toxic, flammable, n.o.s. Inhalation Hazard Zone B 2.3 (2.1) UN3355 POISON GAS, FLAMMABLE GAS 2 None 302305 Not Accepted by FedEx Ground G Insecticide gases, toxic, flammable, n.o.s. Inhalation Hazard Zone C 2.3 (2.1) UN3355 POISON GAS, FLAMMABLE GAS 3 None 302305 Not Accepted by FedEx Ground G Insecticide gases, toxic, flammable, n.o.s. Inhalation Hazard Zone D 2.3 (2.1) UN3355 POISON GAS, FLAMMABLE GAS 4 None 302305 Not Accepted by FedEx Ground G Insecticide gases, toxic, n.o.s. 2.3 UN1967 POISON GAS 3 None 193, 334 Not Accepted by FedEx Ground Inulin trinitrate (dry) Forbid- den Iodine azide (dry) Forbid- den Iodine monochloride 8 UN1792 II CORROSIVE N41 None 212 Iodine pentafluoride 5.1 (6.1, 8) UN2495 I OXIDIZER, POISON, CORROSIVE** None 205 Accepted only when packaged under applicable special permit or 49CFR 173.13 2-Iodobutane 3 UN2390 II FLAMMABLE LIQUID 150 202 Iodomethylpropanes 3 UN2391 II FLAMMABLE LIQUID 150 202 Iodopropanes 3 UN2392 III FLAMMABLE LIQUID 150 203 Iodoxy compounds (dry) Forbid- den Iridium nitratopentamine iridium nitrate Iron chloride, see Ferric chloride Forbid- den Iron oxide, spent, or Iron sponge, spent obtained from coal gas purification 4.2 UN1376 III SPONTANEOUSLY COMBUSTIBLE None 213 Not Accepted by FedEx Ground Iron pentacarbonyl Iron sesquichloride, see Ferric chloride Irritating material, see Tear gas substances, etc. 6.1 (3) UN1994 I POISON, FLAMMABLE LIQUID 1 None 226 Not Accepted by FedEx Ground Isobutane see also Petroleum gases, liquefied 2.1 UN1969 FLAMMABLE GAS 19 306 304 Isobutanol or Isobutyl alcohol 3 UN1212 III FLAMMABLE LIQUID 150 203 Isobutyl acetate 3 UN1213 II FLAMMABLE LIQUID 150 202 Isobutyl acrylate, stabilized Isobutyl alcohol, see Isobutanol Isobutyl aldehyde, see Isobutyraldehyde 3 UN2527 III FLAMMABLE LIQUID 150 203 Isobutylamine 3 (8) UN1214 II FLAMMABLE LIQUID, CORROSIVE 150 202 D Isobutyl chloroformate 6.1 (3, 8) NA2742 I POISON, FLAMMABLE LIQUID, CORROSIVE 2 None 227 Not Accepted by FedEx Ground Isobutylene see also Petroleum gases, liquefied 2.1 UN1055 FLAMMABLE GAS 19 306 304 Isobutyl formate 3 UN2393 II FLAMMABLE LIQUID 150 202 Isobutyl isobutyrate 3 UN2528 III FLAMMABLE LIQUID 150 203 + Isobutyl isocyanate 3 (6.1) UN2486 I FLAMMABLE LIQUID, POISON 1 None 226 Not Accepted by FedEx Ground Isobutyl methacrylate, stabilized 3 UN2283 III FLAMMABLE LIQUID 150 203 Isobutyl propionate 3 UN2394 III FLAMMABLE LIQUID 150 203 Isobutyraldehyde or Isobutyl aldehyde 3 UN2045 II FLAMMABLE LIQUID 150 202 Isobutyric acid 3 (8) UN2529 III FLAMMABLE LIQUID, CORROSIVE 150 203 Isobutyronitrile 3 (6.1) UN2284 II FLAMMABLE LIQUID, POISON** 150 202 Accepted only when packaged under applicable special permit or 49CFR 173.13 Isobutyryl chloride 3 (8) UN2395 II FLAMMABLE LIQUID, CORROSIVE 150 202 G G G Isocyanates, flammable, toxic, n.o.s. or Isocyanate solutions, flammable, toxic, n.o.s. flashpoint less than 23 degrees C Isocyanates, flammable, toxic, n.o.s. or Isocyanate solutions, flammable, toxic, n.o.s. flashpoint less than 23 degrees C Isocyanates, toxic, flammable, n.o.s. or Isocyanate solutions, toxic, flammable, n.o.s., flashpoint not less than 23 degrees C but not more than 61 degrees C and boiling point less than 300 degrees C 3 (6.1) UN2478 II FLAMMABLE LIQUID, POISON** 5 150 202 3 (6.1) UN2478 III FLAMMABLE LIQUID, POISON** 5 150 203 6.1 (3) UN3080 II POISON, FLAMMABLE LIQUID** 153 202 Note: Proper shipping names that must include a technical name in parentheses are indicated by the letter G in column 1 ** Column 6: See column 9 for FedEx Ground restrictions 203 Accepted only when packaged under applicable special permit or 49CFR 173.13 Accepted only when packaged under applicable special permit or 49CFR 173.13 Accepted only when packaged under applicable special permit or 49CFR 173.13
Sym- bols FedEx Ground Hazardous Materials Table D.O.T. Basic Description for Hazardous Material Shipments Packaging (§173.***) Hazardous materials descriptions and proper shipping names Hazard class or Division Identifi- cation Numbers PG Label codes Special provisions Exceptions NonBulk FedEx Ground Restrictions (1) (2) (3) (4) (5) (6) (7) (8A) (8B) (9) Isocyanates, toxic, n.o.s. or Isocyanate, solutions, toxic, n.o.s., G flashpoint more than 61 degrees C and boiling point less than 300 degrees C 6.1 UN2206 II POISON** 153 202 Accepted only when packaged under applicable special permit or 49CFR 173.13 Isocyanates, toxic, n.o.s. or Isocyanate, solutions, toxic, n.o.s., G flashpoint more than 61 degrees C and boiling point less than 300 degrees C 6.1 UN2206 III POISON** 153 203 Accepted only when packaged under applicable special permit or 49CFR 173.13 Isocyanatobenzotrifluorides 6.1 (3) UN2285 II POISON, FLAMMABLE LIQUID** 5 153 202 Accepted only when packaged under applicable special permit or 49CFR 173.13 Isoheptenes 3 UN2287 II FLAMMABLE LIQUID 150 202 Isohexenes Isooctane, see Octanes 3 UN2288 II FLAMMABLE LIQUID 150 202 Isooctenes Isopentane, see Pentane Isopentanoic acid, see Corrosive liquids, n.o.s. 3 UN1216 II FLAMMABLE LIQUID 150 202 Isopentenes 3 UN2371 I FLAMMABLE LIQUID 150 201 Isophoronediamine 8 UN2289 III CORROSIVE 154 203 Isophorone diisocyanate 6.1 UN2290 III POISON** 153 203 Accepted only when packaged under applicable special permit or 49CFR 173.13 Isoprene, stabilized 3 UN1218 I FLAMMABLE LIQUID 150 201 Isopropanol or Isopropyl alcohol 3 UN1219 II FLAMMABLE LIQUID 150 202 Isopropenyl acetate 3 UN2403 II FLAMMABLE LIQUID 150 202 Isopropenylbenzene 3 UN2303 III FLAMMABLE LIQUID 150 203 Isopropyl 2-chloropropionate 3 UN2934 III FLAMMABLE LIQUID 150 203 Isopropyl acetate 3 UN1220 II FLAMMABLE LIQUID 150 202 Isopropyl acid phosphate Isopropyl alcohol, see Isopropanol 8 UN1793 III CORROSIVE 154 213 Isopropylamine 3 (8) UN1221 I FLAMMABLE LIQUID, CORROSIVE None 201 Isopropylbenzene 3 UN1918 III FLAMMABLE LIQUID 150 203 Isopropyl butyrate 3 UN2405 III FLAMMABLE LIQUID 150 203 Isopropyl chloroacetate 3 UN2947 III FLAMMABLE LIQUID 150 203 Isopropyl chloroformate 6.1 (3, 8) UN2407 I POISON, FLAMMABLE LIQUID, CORROSIVE 2 None 227 Not Accepted by FedEx Ground Isopropylcumyl hydroperoxide, with more than 72 percent in solution Forbid- den Isopropyl isobutyrate 3 UN2406 II FLAMMABLE LIQUID 150 202 + Isopropyl isocyanate Isopropyl mercaptan, see Propanethiols 3 (6.1) UN2483 I FLAMMABLE LIQUID, POISON 1 None 226 Not Accepted by FedEx Ground Isopropyl nitrate Isopropyl phosphoric acid, see Isopropyl acid phosphate 3 UN1222 II FLAMMABLE LIQUID 150 202 Isopropyl propionate 3 UN2409 II FLAMMABLE LIQUID 150 202 Isosorbide-5-mononitrate 4.1 UN3251 III FLAMMABLE SOLID 66 151 213 Isosorbide dinitrate mixture with not less than 60 percent lactose, mannose, starch or calcium hydrogen phosphate 4.1 UN2907 II FLAMMABLE SOLID N85 None 212 Isothiocyanic acid Jet fuel, see Fuel aviation, turbine engine Forbid- den D Jet perforating guns, charged oil well, with detonator 1.1D NA0124 II EXPLOSIVE 1.1D 55,56 None 62 Not Accepted by FedEx Ground Note: Proper shipping names that must include a technical name in parentheses are indicated by the letter G in column 1 ** Column 6: See column 9 for FedEx Ground restrictions 204
Page 1 and 2:
Hazardous Materials Shipping Guide
Page 3 and 4:
-TABLE OF CONTENTS- TOPIC Page # Fe
Page 5 and 6:
FedEx Ground Conditions and Require
Page 7 and 8:
may be marked with a statement indi
Page 9 and 10:
o For packages weighing up to 20 lb
Page 11 and 12:
Small Quantity Exceptions Hazardous
Page 13 and 14:
Qualification Process In order to s
Page 15 and 16:
• Hazardous Materials Label, OP-9
Page 17 and 18:
DOT Basic Description for Hazardous
Page 19 and 20:
the telephone number applies to all
Page 21 and 22:
A B C D E F HAZARDOUS MATERIAL SHIP
Page 23 and 24:
SAMPLE HAZARDOUS MATERIAL SHIPPING
Page 25 and 26:
OP-900 Example #5: Radioactive Radi
Page 27 and 28:
Each package containing a material
Page 29 and 30:
Example #3: Flammable Gas (Class 2.
Page 31 and 32:
Definitions and other terms For the
Page 33 and 34:
individually, palletized, or unitiz
Page 35 and 36:
Class 8. See § 173.136 of this sub
Page 37 and 38:
(2) Is currently registered as a pr
Page 39 and 40:
Flammable gas. See § 173.115 of th
Page 41 and 42:
transportation safety. This term in
Page 43 and 44:
(2) Is designated for mechanical ha
Page 45 and 46:
Metered delivery service means a ca
Page 47 and 48:
components necessary to contain and
Page 49 and 50:
Placarded car means a rail car whic
Page 51 and 52:
ail, and includes a box car, flat c
Page 53 and 54:
compounds or elements that will not
Page 55 and 56:
Train means one or more engines cou
Page 57 and 58:
Vessel includes every description o
Page 59 and 60:
equirements of this subchapter and
Page 61 and 62:
(3) A description, copy, or the loc
Page 63 and 64:
demonstrated need to know. The secu
Page 65 and 66:
(3) Each salvage cylinder must be p
Page 67 and 68:
(ii) Thirty (30) g (1 ounce) for au
Page 69 and 70:
(1) Cargo-only aircraft. Only hazar
Page 71 and 72:
and pressure, and shocks, loadings
Page 73 and 74:
(5) Packagings used for solids, whi
Page 75 and 76:
gravity marked on the packaging, pr
Page 77 and 78:
(b) Examination, classing and appro
Page 79 and 80:
new explosive that has not been exa
Page 81 and 82:
(2) Off-shore down-hole tool pallet
Page 83 and 84:
(3) For flammable liquids in Packin
Page 85 and 86:
(1) For flammable solids in Packing
Page 87 and 88:
(b) of this section, shipments of O
Page 89 and 90:
(d) Materials corrosive to aluminum
Page 91 and 92:
fitted that shock of impact damage,
Page 93 and 94:
as required for use in the United S
Page 95 and 96:
package must be of the same type wh
Page 97 and 98:
(e) Cells and batteries may be tran
Page 99 and 100:
(4) Wax “Vesta” matches are mat
Page 101 and 102:
the metal container must be capable
Page 103 and 104:
efillable inside container must be
Page 105 and 106:
of this section. A copy of the qual
Page 107 and 108:
The warning must be on a contrastin
Page 109 and 110:
(2) Packaged to conform with the re
Page 111 and 112:
FedEx Ground Guide for Shipping Haz
Page 113 and 114:
Identification Number-Cross Referen
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
alternate proper shipping name and
Page 145 and 146:
may, due to differing physical stat
Page 147 and 148:
group or hazard zone shown in assoc
Page 149 and 150:
standards, or not appropriately add
Page 151 and 152:
Column 8A Exceptions Column 8B NonB
Page 153 and 154:
Sym- bols FedEx Ground Hazardous Ma
Page 155 and 156: Sym- bols FedEx Ground Hazardous Ma
Page 205: Sym- bols FedEx Ground Hazardous Ma
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
carbon), which does not meet the de
Page 265 and 266:
29 Lithium cells and batteries and
Page 267 and 268:
49 Mixtures of solids which are not
Page 269 and 270:
general packaging requirements of s
Page 271 and 272:
transport. Mixtures containing at l
Page 273 and 274:
141. A toxin obtained from a plant,
Page 275 and 276:
162 This material may be transporte
Page 277 and 278:
N33 Aluminum drums are not authoriz
Page 279 and 280:
Appendix A to 172.101 List of Hazar
Page 281 and 282:
Code Hazardous Substance 277 Report
Page 283 and 284:
Page 285 and 286:
Code Hazardous Substance Reportable
Page 287 and 288:
Page 289 and 290:
Code Hazardous Substance 2,4-(1H,3H
Page 291:
1000 FedEx Drive Moon Township, PA
show all

Hazardous Materials Shipping Guide - Industrial Safety and Hazmat ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?