Hazardous Materials Shipping Guide - Industrial Safety and Hazmat ...

Recommendations

Info

Example #5: ORM-D Shipments Note: ORM-D shipments do NOT require the hazardous material shipping paper (OP-900) and hazardous material certification form (OP-950). Note: All outer non-specification packaging (i.e. overpacks, ORM-D’s packaging) must display a minimum 200 lb. Burst Strength Test Seal or 32 Edge Crush Test (ECT) Seal. Hazardous Material Support The Dangerous Goods/Hazardous Materials hotline is available to answer questions about shipping hazardous materials via FedEx Ground. Please call 1- 800-GO-FEDEX and press “81.” 27
Definitions and other terms For the purpose of this guide, the following commonly used terms have been provided for your information. A complete list of definitions can be found in 49 CFR §171.8. Administrator means the Administrator, Pipeline and Hazardous Materials Safety Administration. Aerosol means any non-refillable receptacle containing a gas compressed, liquefied or dissolved under pressure, the sole purpose of which is to expel a nonpoisonous (other than a Division 6.1 Packing Group III material) liquid, paste, or powder and fitted with a self-closing release device allowing the contents to be ejected by the gas. Agricultural product means a hazardous material, other than a hazardous waste, whose end use directly supports the production of an agricultural commodity including, but not limited to a fertilizer, pesticide, soil amendment or fuel. An agricultural product is limited to a material in Class 3, 8 or 9, Division 2.1, 2.2, 5.1, or 6.1, or an ORM-D material. Approval means a written authorization, including a competent authority approval, from the Associate Administrator or other designated Department official, to perform a function for which prior authorization by the Associate Administrator is required under subchapter C of this chapter (49 CFR parts 171 through 180.) Approved means approval issued or recognized by the Department unless otherwise specifically indicated in this subchapter. Asphyxiant gas means a gas which dilutes or replaces oxygen normally in the atmosphere. Associate Administrator means the Associate Administrator for Hazardous Materials Safety, Research and Special Programs Administration. Atmospheric gases means air, nitrogen, oxygen, argon, krypton, neon and xenon. Authorized Inspection Agency means: 28
Page 1 and 2: Hazardous Materials Shipping Guide
Page 3 and 4: -TABLE OF CONTENTS- TOPIC Page # Fe
Page 5 and 6: FedEx Ground Conditions and Require
Page 7 and 8: may be marked with a statement indi
Page 9 and 10: o For packages weighing up to 20 lb
Page 11 and 12: Small Quantity Exceptions Hazardous
Page 13 and 14: Qualification Process In order to s
Page 15 and 16: • Hazardous Materials Label, OP-9
Page 17 and 18: DOT Basic Description for Hazardous
Page 19 and 20: the telephone number applies to all
Page 21 and 22: A B C D E F HAZARDOUS MATERIAL SHIP
Page 23 and 24: SAMPLE HAZARDOUS MATERIAL SHIPPING
Page 25 and 26: OP-900 Example #5: Radioactive Radi
Page 27 and 28: Each package containing a material
Page 29: Example #3: Flammable Gas (Class 2.
Page 33 and 34: individually, palletized, or unitiz
Page 35 and 36: Class 8. See § 173.136 of this sub
Page 37 and 38: (2) Is currently registered as a pr
Page 39 and 40: Flammable gas. See § 173.115 of th
Page 41 and 42: transportation safety. This term in
Page 43 and 44: (2) Is designated for mechanical ha
Page 45 and 46: Metered delivery service means a ca
Page 47 and 48: components necessary to contain and
Page 49 and 50: Placarded car means a rail car whic
Page 51 and 52: ail, and includes a box car, flat c
Page 53 and 54: compounds or elements that will not
Page 55 and 56: Train means one or more engines cou
Page 57 and 58: Vessel includes every description o
Page 59 and 60: equirements of this subchapter and
Page 61 and 62: (3) A description, copy, or the loc
Page 63 and 64: demonstrated need to know. The secu
Page 65 and 66: (3) Each salvage cylinder must be p
Page 67 and 68: (ii) Thirty (30) g (1 ounce) for au
Page 69 and 70: (1) Cargo-only aircraft. Only hazar
Page 71 and 72: and pressure, and shocks, loadings
Page 73 and 74: (5) Packagings used for solids, whi
Page 75 and 76: gravity marked on the packaging, pr
Page 77 and 78: (b) Examination, classing and appro
Page 79 and 80: new explosive that has not been exa
Page 81 and 82:
(2) Off-shore down-hole tool pallet
Page 83 and 84:
(3) For flammable liquids in Packin
Page 85 and 86:
(1) For flammable solids in Packing
Page 87 and 88:
(b) of this section, shipments of O
Page 89 and 90:
(d) Materials corrosive to aluminum
Page 91 and 92:
fitted that shock of impact damage,
Page 93 and 94:
as required for use in the United S
Page 95 and 96:
package must be of the same type wh
Page 97 and 98:
(e) Cells and batteries may be tran
Page 99 and 100:
(4) Wax “Vesta” matches are mat
Page 101 and 102:
the metal container must be capable
Page 103 and 104:
efillable inside container must be
Page 105 and 106:
of this section. A copy of the qual
Page 107 and 108:
The warning must be on a contrastin
Page 109 and 110:
(2) Packaged to conform with the re
Page 111 and 112:
FedEx Ground Guide for Shipping Haz
Page 113 and 114:
Identification Number-Cross Referen
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
alternate proper shipping name and
Page 145 and 146:
may, due to differing physical stat
Page 147 and 148:
group or hazard zone shown in assoc
Page 149 and 150:
standards, or not appropriately add
Page 151 and 152:
Column 8A Exceptions Column 8B NonB
Page 153 and 154:
Sym- bols FedEx Ground Hazardous Ma
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Page 217 and 218:
Page 219 and 220:
Page 221 and 222:
Page 223 and 224:
Page 225 and 226:
Page 227 and 228:
Page 229 and 230:
Page 231 and 232:
Page 233 and 234:
Page 235 and 236:
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
carbon), which does not meet the de
Page 265 and 266:
29 Lithium cells and batteries and
Page 267 and 268:
49 Mixtures of solids which are not
Page 269 and 270:
general packaging requirements of s
Page 271 and 272:
transport. Mixtures containing at l
Page 273 and 274:
141. A toxin obtained from a plant,
Page 275 and 276:
162 This material may be transporte
Page 277 and 278:
N33 Aluminum drums are not authoriz
Page 279 and 280:
Appendix A to 172.101 List of Hazar
Page 281 and 282:
Code Hazardous Substance 277 Report
Page 283 and 284:
Page 285 and 286:
Code Hazardous Substance Reportable
Page 287 and 288:
Page 289 and 290:
Code Hazardous Substance 2,4-(1H,3H
Page 291:
1000 FedEx Drive Moon Township, PA
show all

Hazardous Materials Shipping Guide - Industrial Safety and Hazmat ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?