Download Manual - Silvan Australia

More documents

Recommendations

Info

Safety Information Wording of Safety Warnings The wording of the safety decals shown on the previous page is given below. Before operating the sprayer read all safety warning decals. Failure to comply with these warnings could result in serious injury or death Part Number DEC 48 Part Number DEC 13 Part Number DEC 10 Part Number DEC 12 Part Number DEC 51 Part Number DEC 52 Part Number DEC 121 Part Number DEC 119 6 Part Number 399 14 1000
Features and Specifications Tank Polytuff impact resistant polyethylene. Capacity 2500 litres. 455 mm screw down lid with basket strainer. Calibrated liquid level sight gauge. Dual rotating chemical rinse nozzles inside tank. 50 mm bottom drain with ball valve. Bottom Fill 50 mm cam-lever hose coupling. High capacity filter. Agitation Continuous agitation from by-pass flow line plus high volume venturi agitator. Pump and Drive PTO Drive Model Three cylinder, constant displacement, oil backed diaphragm pump. Direct coupled to 540 rpm shielded PTO shaft. Standard Pump Model No. BP151/20 Max flow (l/min) 142 Max pressure (Bar) 20 (290 psi) Hydraulic Drive Model Centrifugal pump with cast iron body, glass nylon impellor, viton seals and self-priming chamber. Direct coupled to hydraulic motor suitable for closed or open centre systems. Pump Model No. Hypro 9303C-HM4C-SP Max flow (l/min) 360 Max pressure (Bar) 5.5 (80 psi) Tractor hydraulic flow required 19 - 26 l/min (4.2 - 5.7 Imp GPM) Cabin Controls Standard Silvamatic Spray Controller Master On/Off switch. Boom section On/Off for up to 5 sections Spraying pressure regulating switch. Pressure gauge 0 - 20 Bar. Circuit protection fuse 10 amp. Optional Farmscan Primo 400 Spray Controller Programmable spray computer with single function digital display panel. Power switch. Boom switches - Master and 4 sections. Valve Block Assembly Flow Sensor and Flow Control valve. Electric On/Off valves for 3, 4 or 5 boom sections. Glycerine filled pressure gauge (at front of sprayer) Maximum Pressure 20 Bar Operating Voltage 12 volt DC Spray Boom – Front or Rear Mounted Front mounted Silvan RowMASTER folding boom of 12 or 15 metre width. Requires three sets of remote hydraulic outlets. Optional electric over hydraulic 3 bank controls for lift, inner fold and outer fold. Optional individual wing tilt and 5 bank controls. or Rear mounted Silvan RowMASTER folding boom of 12 or 15 metre width. Requires two sets of remote hydraulic outlets. Optional electric over hydraulic 3 bank controls for lift, inner and outer fold. Optional individual wing tilt and 5 bank controls. or Rear mounted Silvan PaddockKING folding boom of 18 or 21 metre width. See relevant boom manual for specifications. Filtration Four stage with removable elements. Standard mesh shown. Alternatives available. 1) Tank lid strainer 18 mesh. Bottom fill filter 50 mesh (blue) 2) Suction line filter 80 mesh (grey) 3) High pressure filter 100 mesh (red) 4) Nozzle strainers 50 mesh (Silvan booms) Chassis, Wheels and Suspension Heavy duty galvanised steel chassis. Three point linkage swivelling hitch. Folding support stand. Single axle with adjustable track. Track widths 1524mm min. to 1828mm max. (60 inches to 72 inches) Tyre size & pressure – 11.2 x 44 radial - 45 psi. Standard Equipment Flushing Tanks two 100 litre Fresh Water Tank 14 litre Silmix - with 60 litre hopper on drop down frame for induction of powdered chemicals. Optional Equipment Foam Marker Arag digital flow meter. Boom fence line kit. 100 litre Dimensions and Weights With standard equipment, single axle and 15m front boom. Mass with tanks empty. To calculate Gross Mass add 1 kg per litre of water fill. Length Width Height Mass Max.Gross Mass (dimensions in mm) (kg) (kg) 5750 2550 3100 2500 5200 Tractor Requirement Minimum recommended PTO power rating. 75 Kw (100 HP) 7
Page 1 and 2: Operator’s Manual MANBA07 - Rev A
Page 3 and 4: Contents Page Introduction 2 Warran
Page 5 and 6: New Product Warranty WARRANTY POLIC
Page 7: Safety Information Locations of Saf
Page 11 and 12: Features and Specifications 2500 li
Page 13 and 14: Description of Fluid Flow The schem
Page 15 and 16: Installation Left Tilt Main Fold Ri
Page 17 and 18: Connecting to the Tractor Adjustabl
Page 19 and 20: Operation Bottom Fill Filter Option
Page 21 and 22: Operation To increase pressure turn
Page 23 and 24: Operation Empty Valve open Knife Va
Page 25 and 26: Operation Spray Boom Operation The
Page 27 and 28: General Spraying Information When t
Page 29 and 30: Calibrating the Sprayer Testing the
Page 31 and 32: Optional Equipment Hand Valve DIGIT
Page 33 and 34: Lubrication and Maintenance Annual
Page 35: SILVAN AUSTRALIA PTY. LTD. ABN 48 0

Download Manual - Silvan Australia

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?