English - Yamaha-Racingparts

More documents

Recommendations

Info

3 Tightening Torque List ............................................................................... 70 4 Headlight Cord Wiring Diagram................................................................. 83 5 YZF-R1 Wiring Diagram.............................................................................. 84
1 Engine Specifications Spec SBK STK STD Displacement 998 cm³ 998 cm³ 998 cm³ Bore/Stroke 78.0 x 52.2 mm 78.0 x 52.5 mm 78.0 x 52.2 mm Maximum engine speed (limiter controlled speed) 13800 rpm 13800 rpm 13800 rpm Compression ratio 13.7:1 12.9:1 12.7:1 (recommended value) (Depend of (Depending on head-gasket the thickness of and head the head cylinder thickness and cylinder head surface grinding) gasket) Valve timing (event angle) INT. 110° 103° 105° EXT. 105° 103° 105° Squish height (minimum) 0.65 mm 0.65 mm 0.75 mm Clearance between valve INT. 1.0 mm 1.0 mm 1.3 mm and piston (minimum) (ATDC10°) (ATDC10°) (ATDC10°) EXT. 2.0 mm 2.5 mm 2.8 mm (BTDC10°) (BTDC10°) (BTDC10°) Valve (tappet) clearance INT. 0.17 – 0.23 mm 0.11 – 0.20 mm 0.11 – 0.20 mm EXT. 0.27 – 0.33 mm 0.21 – 0.25 mm 0.21 – 0.25 mm – 1 –
Page 2 and 3: Introduction • This manual is int
Page 6 and 7: 2 Kit Parts 2-1 Installing Engine P
Page 8 and 9: 3. Head-gasket, Cylinder Gasket Par
Page 10 and 11: 4. Piston Set (14B-116A0-70) Parts
Page 12 and 13: 8. Valve Spring Set (14B-A2110-71)
Page 14 and 15: 3. Installing the Lever Assembly Se
Page 16 and 17: Ycci System Control You can use the
Page 18 and 19: 12. AIS-plug Set (5VY-A4890-70) Thi
Page 20 and 21: 13. Clutch Spring Set (4B1-A6330-70
Page 22 and 23: (Setting of back torque limiter of
Page 24 and 25: 15. Transmission Gear Parts List No
Page 26 and 27: NOTICE This set contains modified g
Page 28 and 29: - 24 - YZF-R1 Speed List Engine spe
Page 30 and 31: 38 36 29 28 33 27 25 26 29 28 37 35
Page 32 and 33: 17. Drive Sprockets Parts List This
Page 34 and 35: 2-2 Installing Chassis Parts 19. Oi
Page 36 and 37: 20. Shock Absorber Rear (14B-22210-
Page 38 and 39: - 34 - Performance and purpose of k
Page 40 and 41: 22. Front Fork ASSY Parts List No.
Page 42 and 43: - 38 - Performance and purpose of k
Page 44 and 45: 23. Spring Front Fork Parts List No
Page 46 and 47: 5. Remove the push rod and fit the
Page 48 and 49: References Front and rear load chan
Page 50 and 51: 25. Front Spare Wheel ASS’Y (4C8-
Page 52 and 53: 27. Throttle Set (14B-C6300-70) Par
Page 54 and 55:
28. Throttle Set (14B-C6300-80) Par
Page 56 and 57:
29. Tube Guide (5VY-26243-80) Parts
Page 58 and 59:
31. Cable Interface (13S-8533A-70)
Page 60 and 61:
Self-Diagnosis Functions • The EC
Page 62 and 63:
Installing Wire Harness: 1. Remove
Page 64 and 65:
NOTICE The wire from the ACM is des
Page 66 and 67:
Installing Rectifier/Regulator: 1.
Page 68 and 69:
• The switch installed to the STD
Page 70 and 71:
• This harness comes with a coupl
Page 72 and 73:
- 68 -
Page 74 and 75:
3 Tightening Torque List Engine To
Page 76 and 77:
Engine To be tightened Part No. Par
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Chassis To be tightened Part No. Pa
Page 84 and 85:
Chassis To be tightened Part No. Pa
Page 86 and 87:
Installing the Crankcase Tightening
Page 88 and 89:
5 YZF-R1 Wiring Diagram - 84 -
show all

English - Yamaha-Racingparts

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?