ORION Commercial 'LULA' Elevator - Advanced Lift Solutions

Recommendations

Info

o r i o n co m m e r c i a l ‘l u l a’ e l e vat o r 1.4 ELEVATOR TERMINOLOGY 10 of 145 TERMINOLOGY DESCRIPTION Cab This is the compartment of the elevator in which people ride. Also, called the car. Cable Hydraulic This is the type of drive system used on the Orion. It involves a hydraulic jack, wire cable and pulley system to raise and lower the cab compartment. Car See cab. Cab Gate/Door This is a door or gate connected to the cab. Interior gate. Control System This is the entire electrical control system, usually identified as the “controller” (mounted at the pump unit). Cylinder This is the outside tubular casing of the jack. D.B.G. This is the Distance Between Guides (Rails) or the critical measurement between the face of the left rail and the face of the right rail. Electro-Mechanical Interlock This is the electrically and mechanically controlled door or gate lock that prevents the door/gate from opening when the elevator is not present at the landing and prevents the elevator from running, unless all doors/gates are closed and locked. Guide Yoke/Sheave This is a cable guide arrangement consisting of a sheave, guide shoes, roller bearings and adjustable cable guards. The sheave is furnished with rounded grooves to fit the cables and is mechanically attached to the end of the hydraulic plunger to provide the 1:2 mechanical advantage. Hoistway/Runway This is the elevator shaft totally enclosing the elevator. Hoistway Door This is a door connected to the hoistway at a landing. Jack Unit This is the hydraulic piston/plunger and cylinder used to drive the elevator cab up and down. L.E.D. This is a Light Emitting Diode. Landing This is any floor level or access level where passengers will enter and/or exit the elevator cab. <strong>Lift</strong> This is another word for elevator. Load (Rated) This is the maximum amount of allowable weight that the elevator is rated to carry (in persons or lb/kg). Orion Installation Guide PN 000581 (18-m06-2010)
TERMINOLOGY DESCRIPTION Machine Room This is a separate room usually next to the hoistway to hold the hydraulic power unit and motor control system. Overhead Clearance This is the vertical clearance required to fit the elevator and its drive components at the top floor. It is measured from the upper floor level to top of the hoistway. Pit This is the bottom area of the hoistway that is below the lowest floor level. Plunger/Piston This is the rod portion of the hydraulic cylinder that extends from the cylinder as hydraulic pressure is applied and is attached to the sling. Power Unit/Pump Unit This is a hydraulic power producing unit consisting of an electric motor, hydraulic pump, valves, and control panel. Wire Rope This is lifting wire cable. Roped Hydraulic See Cable Installation. Safeties This is a mechanical device used to stop and support the elevator cab, sling, and rated load if a failure in the normal suspension means occurs. Sling This is structural steel members that support the elevator cab. The sling carries the cab up and down the hoistway. Stiles These are vertical support members of the sling assembly. Travel This is the distance from the bottom finished floor level to the top finished floor level. Travelling Cable This is the black flat multi-wire electrical cable connecting the elevator control panel in the car to the pump unit, push buttons, and safety devices. Upstand Post The upstand post is a rigid steel post of varying lengths used to support the jack unit. Orion Installation Guide PN 000581 (18-m06-2010) 11 of 145 o r i o n co m m e r c i a l ‘l u l a’ e l e vato r
Page 1: ORION Commercial ‘LULA’ Elevato
Page 4 and 5: 1 8 15 22 31 Install Rails and Rail
Page 6 and 7: o r i o n co m m e r c i a l ‘l u
Page 64 and 65:
o r i o n co m m e r c i a l ‘l u
Page 66 and 67:
Page 68 and 69:
Page 70 and 71:
Page 72 and 73:
Page 74 and 75:
Page 76 and 77:
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
Page 132 and 133:
Page 134 and 135:
Page 136 and 137:
Page 138 and 139:
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 151:
APPENDIx A ELECTRICAL SCHEMATICS PN
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212 and 213:
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Page 240:
show all

ORION Commercial 'LULA' Elevator - Advanced Lift Solutions

Create successful ePaper yourself

Delete template?

Save as template?