ORION Commercial 'LULA' Elevator - Advanced Lift Solutions

Recommendations

Info

o r i o n co m m e r c i a l ‘l u l a’ e l e vat o r 4) Mount the two (2) torsion bars to the sling (Figure 34). 5) Mount the car top prop to the uprights. 6) Install the “X” braces on the uprights using ⅜” x 1” bolts, lock washers and nuts (Figure 34). Spreader Channel 36 of 145 NOTE The “X” braces are 1” x ¼” flat bar with slots in each end. ENSURE SLING IS “SQUARE” BEFORE TIGHTENING “X” BRACES! X braces are installed only when a telephone box is not used. Safety Block figure 34 Sling Assembly figure 35 Sling Assembled Orion Installation Guide PN 000581 (18-m06-2010)
7) The cables are normally shipped coiled and tied with baling wire. One end of the cable has a permanent “swaged” fitting attached and the other end is taped to prevent unravelling. The swaged end attaches to the sling lifting bracket and the free end attaches to the dead end available on the pit channel. Orion Installation Guide PN 000581 (18-m06-2010) CAUTION When uncoiling the cable, never pull it out by its center. Undo the wire and carefully “unroll” the cable. NEVER LET THE CABLE BECOME “KINKED” as this can greatly reduce the safety and life of the cable. NOTE The cable has been installed in the sling lifting bracket with two clamps holding the tension of the SAFETY ACTUATING SPRINGS. Do not remove the holding clamps until ready to start the pump unit and place tension on the cables. Refer to Figure 36. figure 36 Cables on <strong>Lift</strong>ing Bracket figure 37 <strong>Lift</strong>ing Bracket 37 of 145 o r i o n co m m e r c i a l ‘l u l a’ e l e vato r
Page 1: ORION Commercial ‘LULA’ Elevato
Page 4 and 5: 1 8 15 22 31 Install Rails and Rail
Page 6 and 7: o r i o n co m m e r c i a l ‘l u
Page 90 and 91:
o r i o n co m m e r c i a l ‘l u
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
Page 132 and 133:
Page 134 and 135:
Page 136 and 137:
Page 138 and 139:
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 151:
APPENDIx A ELECTRICAL SCHEMATICS PN
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212 and 213:
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Page 240:
show all

ORION Commercial 'LULA' Elevator - Advanced Lift Solutions

Create successful ePaper yourself

Delete template?

Save as template?