ORION Commercial 'LULA' Elevator - Advanced Lift Solutions

Recommendations

Info

o r i o n co m m e r c i a l ‘l u l a’ e l e vat o r 3.1 RAIL INSTALLATION wITH SPEEDY JIG The Speedy Jig (PN 200743) has been designed to speed up the rail installation process and improve the accuracy of the installation. The jig is adjustable to allow use for the Orion DBG of 30”. See the photos below showing the two different set ups. Tools required Set of mechanical sockets and wrenches (¼” – 1 ¼”), 4 foot Carpenter’s level, Carpenter’s square, ⅜” reversible hand drill, ½” Hammer drill, ⅜” and ½” carbide drill bits, scratch point awl, chalk line, two plumb lines, tape measure, four vice-grip pliers, rags and cleaning solvent, temporary lighting for hoistway. Schedule 2 men for 3 to 5 hours The Leaf Brackets are now left and right handed. The round pre-drilled opening is to be installed on the rail wall side as shown in Figure 13. 18 of 145 figure 5 figure 4 figure 6 Orion Installation Guide PN 000581 (18-m06-2010)
Installation Procedure To install the rails and rail brackets proceed as follows: 1) Start by plumbing the hoistway to determine the tightest spot in order to establish running clearances and the overall condition of the rail support wall. 2) Locate the centerline of the rails as referenced from the “sill line” on the Installation Drawings supplied with each elevator (Figure 7). Orion Installation Guide PN 000581 (18-m06-2010) NOTE The importance of accurately installing the rails is critical. The rails must be supported and aligned properly and they must be true and plumb. The overall performance and “ride” of the elevator depend primarily on how well the rails are installed. INSTALL THE LADDERS AND/OR SCAffOLDING TO THE MANUfACTURER’S RECOMMENDATIONS. USE ExTREME CARE wHEN wORKING AT HEIGHTS AND ALwAYS wEAR A SAfETY BELT. NOTE While 1 mechanic is working on steps 6, 12, 13, 14, 15, 16; the other mechanic can work on steps 7, 8, 9, 10, 11. figure 7 Installation Drawing (Sample) 19 of 145 o r i o n co m m e r c i a l ‘l u l a’ e l e vato r
Page 1: ORION Commercial ‘LULA’ Elevato
Page 4 and 5: 1 8 15 22 31 Install Rails and Rail
Page 6 and 7: o r i o n co m m e r c i a l ‘l u
Page 72 and 73:
o r i o n co m m e r c i a l ‘l u
Page 74 and 75:
Page 76 and 77:
Page 78 and 79:
Page 80 and 81:
Page 82 and 83:
Page 84 and 85:
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
Page 132 and 133:
Page 134 and 135:
Page 136 and 137:
Page 138 and 139:
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 151:
APPENDIx A ELECTRICAL SCHEMATICS PN
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212 and 213:
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Page 240:
show all

ORION Commercial 'LULA' Elevator - Advanced Lift Solutions

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?