ORION Commercial 'LULA' Elevator - Advanced Lift Solutions

Recommendations

Info

o r i o n co m m e r c i a l ‘l u l a’ e l e vat o r 3.3 JACK UNIT AND UPSTAND INSTALLATION The cable hydraulic system features cables, a sheave/guide yoke and a slack/broken cable SAFETY DEVICE. Care must be taken to ensure that all adjustments of the safety device are properly followed and that the lifting cables are handled according to the recommended procedures. To install the jack unit and upstand post proceed as follows: 1) Place the bottom of the upstand post into the pit channel and secure the top using the jack bracket shown in Figure 27, and 28. Do not tighten at this time. See Installation Drawings for exact bracket locations. 2) To adjust the upstand post to the required height (Figure 28): 30 of 145 a) Loosen the lock nut at the top b) See Installation Drawings for “Adjustable Upstand Setting” dimension c) Turn the screw until the correct height is achieved d) Finger tighten the lock nut. DO NOT PUT ANY wEIGHT ON THE JACK ASSEMBLY UNTIL BOTH THE JACK AND THE UPSTAND ARE SECURELY fASTENED TO THE wALL. Install the rubber gasket between the muffler clamp and cylinder 3) Mount the jack unit on top of the upstand post ensuring the male end of the jack’s base fits the female socket figure 25 Jack Bracket on the top of the upstand. Secure the top of the jack unit to the rail using the jack bracket supplied (Figure 26 and 27). Do not tighten at this time. NOTE On elevators equipped with a 2” (51 mm) cylinder, the rubber gasket supplied must be installed on the jack bracket between the muffler clamp and the cylinder in order to provide a tight fit. Refer to Figure 25. Orion Installation Guide PN 000581 (18-m06-2010)
IMPORTANT The Jack Bracket must be installed as shown below. Note that the square cutout in the bracket must be positioned towards the top of the hoistway. 4) Using a plumb line and carpenter’s level, ensure the jack and upstand are “in line” with each other and vertically plumb. Slight misalignment can cause undue wear on the seals and an unsatisfactory ride in the cab. NOTE: The jack centerline is 4 ⅜” (111 mm) in the right of the rail/cab centerline. 5) Tighten all jack and upstand brackets. Orion Installation Guide PN 000581 (18-m06-2010) figure 27 Jack Bracket Installed figure 26 Jack Bracket Upstand The square cutout in the bracket must be positioned towards the top of the hoistway. The above Jack Bracket is supplied with 42 in. wide cabs 31 of 145 o r i o n co m m e r c i a l ‘l u l a’ e l e vato r
Page 1: ORION Commercial ‘LULA’ Elevato
Page 4 and 5: 1 8 15 22 31 Install Rails and Rail
Page 6 and 7: o r i o n co m m e r c i a l ‘l u
Page 84 and 85:
o r i o n co m m e r c i a l ‘l u
Page 86 and 87:
Page 88 and 89:
Page 90 and 91:
Page 92 and 93:
Page 94 and 95:
Page 96 and 97:
Page 98 and 99:
Page 100 and 101:
Page 102 and 103:
Page 104 and 105:
Page 106 and 107:
Page 108 and 109:
Page 110 and 111:
Page 112 and 113:
Page 114 and 115:
Page 116 and 117:
Page 118 and 119:
Page 120 and 121:
Page 122 and 123:
Page 124 and 125:
Page 126 and 127:
Page 128 and 129:
Page 130 and 131:
Page 132 and 133:
Page 134 and 135:
Page 136 and 137:
Page 138 and 139:
Page 140 and 141:
Page 142 and 143:
Page 144 and 145:
Page 146 and 147:
Page 148 and 149:
Page 151:
APPENDIx A ELECTRICAL SCHEMATICS PN
Page 154 and 155:
Page 156 and 157:
Page 158 and 159:
Page 160 and 161:
Page 162 and 163:
Page 164 and 165:
Page 166 and 167:
Page 168 and 169:
Page 170 and 171:
Page 172 and 173:
Page 174 and 175:
Page 176 and 177:
Page 178 and 179:
Page 180 and 181:
Page 182 and 183:
Page 184 and 185:
Page 186 and 187:
Page 188 and 189:
Page 190 and 191:
Page 192 and 193:
Page 194 and 195:
Page 196 and 197:
Page 198 and 199:
Page 200 and 201:
Page 202 and 203:
Page 204 and 205:
Page 206 and 207:
Page 208 and 209:
Page 210 and 211:
Page 212 and 213:
Page 214 and 215:
Page 216 and 217:
Page 218 and 219:
Page 220 and 221:
Page 222 and 223:
Page 224 and 225:
Page 226 and 227:
Page 228 and 229:
Page 230 and 231:
Page 232 and 233:
Page 234 and 235:
Page 236 and 237:
Page 238 and 239:
Page 240:
show all

ORION Commercial 'LULA' Elevator - Advanced Lift Solutions

Create successful ePaper yourself

Delete template?

Save as template?