Piaggio Fly 4T servicemanual - Scootergrisen

More documents

Recommendations

Info

Pre-delivery MSS Fly 50 4T CAUTION TO ENSURE MAXIMUM PERFORMANCE, THE BATTERY MUST BE CHARGED BEFORE USE. INADEQUATE CHARGING OF THE BATTERY WITH A LOW LEVEL OF ELECTROLYTE BEFORE IT IS FIRST USED SHORTENS THE LIFE OF THE BATTERY. WARNING BEFORE RECHARGING THE BATTERY, REMOVE THE CAPS OF EACH CELL. KEEP THE BATTERY AWAY FROM NAKED FLAMES OR SPARKS WHILE IT IS CHARGED. REMOVE THE BATTERY FROM THE SCOOTER, DISCONNECTING THE NEGATIVE TERMINAL FIRST. CAUTION WHEN INSTALLING THE BATTERY, ATTACH THE POSITIVE LEAD FIRST AND THEN THE NEG- ATIVE ONE. WARNING BATTERY ELECTROLYTE IS TOXIC AND IT MAY CAUSE SERIOUS BURNS. IT CONTAINS SUL- PHURIC ACID. AVOID CONTACT WITH EYES, SKIN AND CLOTHING. IN CASE OF CONTACT WITH EYES OR SKIN, RINSE WITH ABUNDANT WATER FOR ABOUT 15 MINUTES AND SEEK MEDICAL ATTENTION AT ONCE. IF IT IS SWALLOWED, IMMEDIATELY DRINK LARGE QUANTITIES OF WATER OR VEGETABLE OIL. SEEK IMMEDIATE MEDICAL ATTENTION. BATTERIES PRODUCE EXPLOSIVE GAS; KEEP THEM AWAY FROM NAKED FLAMES, SPARKS AND CIGARETTES. IF THE BATTERY IS CHARGED IN A CLOSED PLACE, TAKE CARE TO EN- SURE ADEQUATE VENTILATION. ALWAYS PROTECT YOUR EYES WHEN WORKING CLOSE TO BATTERIES. KEEP OUT OF THE REACH OF CHILDREN CAUTION NEVER USE FUSES WITH A CAPACITY HIGHER THAN THE RECOMMENDED CAPACITY. USING A FUSE OF UNSUITABLE RATING MAY SERIOUSLY DAMAGE THE VEHICLE OR EVEN CAUSE A FIRE. Levels check Level check: - Hydraulic brake system fluid level. - Rear hub oil level - Engine oil level Road test Test ride - Cold start - Instrument operations - Response to the throttle control - Stability on acceleration and braking - Rear and front brake efficiency - Rear and front suspension efficiency - Abnormal noise PRE DE - 148
MSS Fly 50 4T Pre-delivery Static test Static control after the test ride: - Starting when warm - Starter operation - Minimum hold (turning the handlebar) - Uniform turning of the steering - Possible leaks CAUTION CHECK AND ADJUST TYRE PRESSURE WITH TYRES AT AMBIENT TEMPERATURE. CAUTION NEVER EXCEED THE RECOMMENDED INFLATION PRESSURES OR TYRES MAY BURST. Functional inspection Functional check up: Braking system (hydraulic) - Lever travel Braking system (mechanical) - Lever travel Clutch - Proper functioning check Engine - Throttle travel check Others - Check documentation - Check the frame and engine numbers - Tool kit - License plate fitting - Check locks - Check tyre pressures - Installation of mirrors and any accessories PRE DE - 149
Page 1 and 2:
WORKSHOP MANUAL MSS Fly 50 4T 63321
Page 3:
WORKSHOP MANUAL MSS Fly 50 4T This
Page 6 and 7:
INDEX OF TOPICS CHARACTERISTICS CHA
Page 8 and 9:
Characteristics MSS Fly 50 4T Vehic
Page 10 and 11:
Characteristics MSS Fly 50 4T Trans
Page 12 and 13:
Characteristics MSS Fly 50 4T Kehin
Page 14 and 15:
Characteristics MSS Fly 50 4T Pisto
Page 16 and 17:
Characteristics MSS Fly 50 4T Produ
Page 18 and 19:
Tooling MSS Fly 50 4T TOOL - 18 TOO
Page 20 and 21:
Tooling MSS Fly 50 4T TOOL - 20 Sto
Page 22 and 23:
Page 24 and 25:
Page 26 and 27:
INDEX OF TOPICS MAINTENANCE MAIN
Page 28 and 29:
Maintenance MSS Fly 50 4T Engine oi
Page 30 and 31:
Maintenance MSS Fly 50 4T 1. Needle
Page 32 and 33:
Maintenance MSS Fly 50 4T Direct th
Page 34 and 35:
Maintenance MSS Fly 50 4T - Start t
Page 36 and 37:
Maintenance MSS Fly 50 4T Checking
Page 38 and 39:
Maintenance MSS Fly 50 4T 9) Adjust
Page 40 and 41:
INDEX OF TOPICS TROUBLESHOOTING TRO
Page 42 and 43:
Troubleshooting MSS Fly 50 4T Possi
Page 44 and 45:
Troubleshooting MSS Fly 50 4T Insuf
Page 46 and 47:
INDEX OF TOPICS ELECTRICAL SYSTEM E
Page 48 and 49:
Electrical system MSS Fly 50 4T Spe
Page 50 and 51:
Electrical system MSS Fly 50 4T Bat
Page 52 and 53:
Electrical system MSS Fly 50 4T Tur
Page 54 and 55:
Electrical system MSS Fly 50 4T Sta
Page 56 and 57:
Electrical system MSS Fly 50 4T a)
Page 58 and 59:
Electrical system MSS Fly 50 4T 3 T
Page 60 and 61:
INDEX OF TOPICS ENGINE FROM VEHICLE
Page 62 and 63:
INDEX OF TOPICS ENGINE ENG
Page 64 and 65:
Engine MSS Fly 50 4T Removing the d
Page 66 and 67:
Engine MSS Fly 50 4T Inspecting the
Page 68 and 69:
Page 70 and 71:
Engine MSS Fly 50 4T - Reassemble t
Page 72 and 73:
Engine MSS Fly 50 4T 20.12 mm Drivi
Page 74 and 75:
Engine MSS Fly 50 4T Removing the h
Page 76 and 77:
Page 78 and 79:
Engine MSS Fly 50 4T Gasket Locking
Page 80 and 81:
Engine MSS Fly 50 4T Removing the s
Page 82 and 83:
Engine MSS Fly 50 4T Refitting the
Page 84 and 85:
Engine MSS Fly 50 4T - Remove the d
Page 86 and 87:
Engine MSS Fly 50 4T Removing the v
Page 88 and 89:
Engine MSS Fly 50 4T - Measure the
Page 90 and 91:
Engine MSS Fly 50 4T Removing the p
Page 92 and 93:
Engine MSS Fly 50 4T CYLINDER BASE
Page 94 and 95:
Engine MSS Fly 50 4T NATION WITH A
Page 96 and 97:
Engine MSS Fly 50 4T 1.6 mm - Inser
Page 98 and 99: Engine MSS Fly 50 4T Inspecting the
Page 100 and 101: Engine MSS Fly 50 4T Refitting the
Page 102 and 103: Engine MSS Fly 50 4T - Bring the sc
Page 104 and 105: Engine MSS Fly 50 4T Splitting the
Page 106 and 107: Engine MSS Fly 50 4T - Support the
Page 108 and 109: Engine MSS Fly 50 4T Crankshaft oil
Page 110 and 111: Engine MSS Fly 50 4T - Remove the c
Page 112 and 113: Engine MSS Fly 50 4T Removing the o
Page 114 and 115: Engine MSS Fly 50 4T - Remove the p
Page 116 and 117: Engine MSS Fly 50 4T - Remove the s
Page 118 and 119: Engine MSS Fly 50 4T - Wash and blo
Page 120 and 121: Engine MSS Fly 50 4T - Insert the d
Page 122 and 123: Engine MSS Fly 50 4T - Insert rubbe
Page 124 and 125: Engine MSS Fly 50 4T loss of engine
Page 126 and 127: Suspensions MSS Fly 50 4T Sospensio
Page 128 and 129: Suspensions MSS Fly 50 4T Handlebar
Page 130 and 131: Suspensions MSS Fly 50 4T Steering
Page 132 and 133: Suspensions MSS Fly 50 4T - To repl
Page 134 and 135: Braking system MSS Fly 50 4T Front
Page 136 and 137: Braking system MSS Fly 50 4T Refitt
Page 138 and 139: Braking system MSS Fly 50 4T Loctit
Page 140 and 141: Braking system MSS Fly 50 4T 8 - Sp
Page 142 and 143: INDEX OF TOPICS CHASSIS CHAS
Page 144 and 145: Chassis MSS Fly 50 4T Air filter
Page 146 and 147: INDEX OF TOPICS PRE-DELIVERY PRE DE
Page 150 and 151: INDEX OF TOPICS TIME TIME
Page 152 and 153: Time MSS Fly 50 4T Crankcase CRANKC
Page 154 and 155: Time MSS Fly 50 4T Cylinder head as
Page 156 and 157: Time MSS Fly 50 4T Cylinder head co
Page 158 and 159: Time MSS Fly 50 4T Oil pump OIL PUM
Page 160 and 161: Time MSS Fly 50 4T Transmission cov
Page 162 and 163: Time MSS Fly 50 4T Flywheel magneto
Page 164 and 165: Time MSS Fly 50 4T Air cleaner AIR
Page 166 and 167: Time MSS Fly 50 4T Legshield spoile
Page 168 and 169: Time MSS Fly 50 4T Central cover CE
Page 170 and 171: Time MSS Fly 50 4T Fuel tank FUEL T
Page 172 and 173: Time MSS Fly 50 4T Steering column
Page 174 and 175: Time MSS Fly 50 4T Handlebar compon
Page 176 and 177: Time MSS Fly 50 4T Seat SADDLE Code
Page 178 and 179: Time MSS Fly 50 4T Front wheel FRON
Page 180 and 181: Time MSS Fly 50 4T Electric devices
Page 182 and 183: Time MSS Fly 50 4T Electronic contr
Page 184 and 185: Time MSS Fly 50 4T Brake callipers
Page 186 and 187: Time MSS Fly 50 4T Helmet bay HELME
Page 188 and 189: Time MSS Fly 50 4T Secondary air bo
show all

Piaggio Fly 4T servicemanual - Scootergrisen

Create successful ePaper yourself

Delete template?

Save as template?