capriz 25 capriz 28 - Heatline

More documents

Recommendations

Info

HALL EFFECT SENSOR r r FAN GAS CONTROL VALVE AIR PRESSURE SWITCH rr g g PUMP g/y r LIMIT SAFETY THERMOSTAT w g DOMESTIC HOT WATER SENSOR r r w w CENTRAL HEATING SENSOR r w WATER PRESSURE SENSOR FLAME (IONISATION) w ELECTRODE THREE WAY VALVE IGNITION ELECTRODES 14 r w g WATER FLOW SENSOR 230V ROOM THERMOSTAT CONNECTION (high voltage) br r r w w OVERHEAT THERMOSTAT FUSES (2A) br g/y CHASSIS EARTH g/y r r PRINTED CIRCUIT BOARD r r w w w r bk br b F1 F2 b br m b b g/y g/y g/y g/y w r r ww 5 4 3 2 1 24V TIME CLOCK (low voltage) 24V ROOM THERMOSTAT CONNECTION (low voltage) USER INTERFACE ww br b g/y g gn bk m r w KEY BROWN BLUE GREEN/YELLOW GREY GREEN BLACK MAUVE RED WHITE L E N 230V~50Hz PERMANENT MAINS SUPPLY FUSED AT 3A FUSE RATINGS: F1: 2 A F2: 2 A Figure 9 Page 14
10. Boiler Installation 10.1 Prior to installing the boiler check the contents of the carton: Appliance, Valves (Fixing Jig Optional), Wall Hanging Bracket, Mounting Template Service, Installation and User Manual, Guarantee Card and Benchmark Log Book. The boiler dimensions are given in Figure 10. Dimension A Capriz 25 405 Capriz 28 430 B 169 169 C 60/100 60/100 10.2 Ensure that the boiler is suitable for the gas supply by checking the data plate, which is situated on the inside of the control panel door, and that the system and chosen boiler position is in accordance to Sections 5, 6 and 7 of these instructions. 15 10.3 Position the supplied template on the wall, ensuring it is level both vertically and horizontally (figure 11). Mark the boiler fixing jig (if required), wall bracket fixing positions and flue outlet position (rear flue only). For flue side exit from the boiler - Mark the horizontal flue centre line on the rear wall. Extend the horizontal line to the side wall allowing a 3 0 decline back towards the boiler, to enable condensate to drain back through the boiler. Mark the flue centre vertical line. ( figure 12) A = = B 03 Distance to centre line 169 mm Figure 12 10.4 When cutting the flue hole it is recommended that a 105mm diameter core drill is used where both internal and external access for the flue installation is available. Where only internal access is available a 125mm diameter core drill should be used. (Note: Please take adequate precautions to prevent debris entering the boiler via the flue outlet). 10.5 Using a 8·5mm drill bit, drill the holes for fixing jig (optional) and hanging bracket. Locate and secure the supplied wall mounting bracket in position (figure 13 ). C Bracket Fixing Slots Figure 11. 30 130 130 Figure 13 027 BOILER Boiler Mounting Tabs CONDENSATE CONNECTION 50 98 SDV outlet (NON-CONDENSING) (CONDENSING) 10.6 Mount the boiler onto the fixing bracket via the boiler mounting slots, (figure 13). 10.7 Connect isolation valves assembled to the boiler ensuring the washers are fitted correctly. 151 86 Figure 10. A 86 151 CENTRAL HEATING DOMESTIC WATER 10.8 On installing the flue, determine the required length of the outer air duct by measuring the distance 'L' ( figure 15 ) from the face of the external wall to the back of boiler's elbow connecting collar. The measurement for the inner flue duct will be 'L' + 20mm Page 15
Page 1 and 2: capriz 25 & capriz 28 Condensing Wa
Page 3 and 4: Contents noitceS egaP ecaferP xoBno
Page 5 and 6: The Signs on Box The Signs on Boile
Page 7 and 8: 2. Technical Data Capriz 25 (25 kW)
Page 9 and 10: 07 3. Boiler Characteristics 3.1 Th
Page 11 and 12: 09 will cause the heater to lock ou
Page 13 and 14: Figure 4 11 Internal Corner Externa
Page 15: 13 FOR CONDENSING BOILERS IT IS REC
Page 19 and 20: 3 4 5 17 12. Filling the System 13.
Page 21 and 22: 15.3 Setting the boiler's integral
Page 23 and 24: FAULT FINDING CHART 3 S T A R T Doe
Page 25 and 26: 18.7 Disconnect the electrical lead
Page 27 and 28: 19.6 Fan Unit Disconnect the electr
Page 29 and 30: Remove the fixing screws from the p
Page 31 and 32: Following replacement the maximum a
Page 33 and 34: Disconnect the DHW sensor as descri
Page 35 and 36: APPENDICES SPARE PARTS LIST 33 PART
Page 37 and 38: Natural Gas / LPG Heatline TM Capri
Page 39 and 40: 37 3. D.H.W. temperature control Th
Page 41 and 42: 39 3003202303-01 Page 39

capriz 25 capriz 28 - Heatline

Create successful ePaper yourself

Delete template?

Save as template?