Compatible Control - HUBER

More documents

Recommendations

Info

1. Safety 1.1 Intended Use General Safety Instructions Duties of the Plant Operator � The operating instructions must be kept readily available in the immediate vicinity of the thermostat. � Only sufficiently qualified operating personnel are permitted to use the thermostat. � The operating personnel must be trained in handling and using the thermostat. � Verify that operating personnel have read and understood the operating instructions. � Precisely define the fields of responsibility of the operating personnel. � Provide protective clothing for the operating personnel. Requirements to be Met by the Operating Personnel � Only personnel assigned and trained by the plant operator may handle and operate the thermostat. � The minimum age for operating personnel is 16 years. Within the workspace, the device operator is responsible for third parties. � The device operator must be sufficiently qualified. Duties of the Operatorating Personnel � The operating personnel must read the operating instructions thoroughly before handling or using the thermostat. � The operating personnel must heed all the safety instructions. � The operating personnel must wear protective clothing when handling or using the thermostat. Workspace The workspace is defined to be at the control panel in front of the thermostat. The workspace is further defined by the peripheral equipment connected by the customer. The customer is responsible for taking suitable safety measures. Safety Devices � Over-temperature protection device � Low liquid level protection Protection Devices � Mains failure automatic � Alarm functions Emergency Plan – Switch off the Power Supply! Hazardous emission of fluid/vapor from the thermostat or connected pipes/hoses (very hot, very cold, hazardous chemical compositions) and or fire/explosion/implosion: Strictly heed the safety instructions of the plant operator relating to the risk of injury and danger to life as well as to the limitation of damage. Observe the instructions included in the safety data sheet of the respective thermal fluid! 4
2. Device Description Due to technical developments the location of components may change.
Page 1: Version 2.0 /08 Compatible Control
Page 4 and 5: Preface Dear Customer, Congratulati
Page 6 and 7: Unichiller with Compatible Control
Page 9: Contents Preface 1. Safety 1.1 Inte
Page 15 and 16: 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15
Page 17 and 18: 1 2 3 4 5 6 7 8 Removable, exchange
Page 19 and 20: 1 2 3 4 5 6 7 8 9 Removable, exchan
Page 21: 3. Commissioning
Page 24 and 25: DIN 12876 3. Commissioning 3.1 Safe
Page 26 and 27: Hazards through emission of fluids
Page 28 and 29: Preparing the thermostat for use Th
Page 30 and 31: Overtemperature protection Requirem
Page 32 and 33: Fill the bath 3. Commissioning 3.4
Page 34 and 35: Fill the thermostat 3. Commissionin
Page 36 and 37: Language Deutsch Setpoint Minimum S
Page 39 and 40: Checks to be performed: Test Arrang
Page 41 and 42: Selection 4. Thermoregulation via C
Page 43 and 44: Display Time Scale Mains Failure Au
Page 45 and 46: Compressor Auto Heating Capacity So
Page 47 and 48: Analog Interface Caution! Electroni
Page 49 and 50: Digital Interface 4. Thermoregulati
Page 51 and 52: Acoustic Alarm Select Usermenu Conf
Page 53 and 54: Calibra- tion Prog. 4. Thermoregula
Page 55 and 56: Circulation Venting 2. Setpoint 4.
Page 57 and 58: Start Ramp 4. Thermoregulation via
Page 59 and 60: Edit Program 4. Thermoregulation vi
Page 61 and 62: Edit Program 4. Thermoregulation vi
Page 63:
Abort Schematic diagram See 2.3. 4.
Page 67 and 68:
Draining Thermofluid Draining cooli
Page 69 and 70:
Requirements Replacing fuses Cleani
Page 71:
6. Appendix
Page 74 and 75:
Interface Specification Float Switc
Page 76 and 77:
Hardware error ALARM !!! HARDWARE E
Page 78 and 79:
6. Appendix 6.3. Device Messages 2.
Page 80 and 81:
Bath Volume (also referred to as fi
Page 82 and 83:
Flow Temperature Denotes the temper
Page 84 and 85:
Process Temperature (core temperatu
Page 86:
Viscosity Also referred to as „in
show all

Compatible Control - HUBER

Create successful ePaper yourself

Delete template?

Save as template?