Pool & Spa Heaters

More documents

Recommendations

Info

PART ONE - USER'S OPERATING INSTRUCTIONSFOR YOUR SAFETY - READ BEFORE OPERATINGWARNING:EXACTLY, AIFFIREYOUORDOEXPLOSIONNOT FOLLOWMAYTHESERESULT,INSTRUCTIONSPROPERTY DAMAGE, PERSONAL INJURY OR LOSSCAUSINGOF LIFE.SECTION 1 / START-UP PROCEDURESBEFORE START-UPBURNERSClean air louvres of dust, lint and debris. Keepheater area clear and free from combustibles, flammableliquids and chemicals. Do not obstruct theflow of combustion and ventilating air.WATERWater must be flowing through the heater duringoperation. Ensure that system is filled with water andthe pump is operating.055 105155 185 - 265 - 405227-01-04
FOR YOUR SAFETY READ BEFORE OPERATINGWARNING: IFRESULTYOU DOCAUSINGNOT FOLLOWPROPERTYTHESEDAMAGE,INSTRUCTIONSPERSONALEXACTLY,INJURYA FIREOR LOSSOR EXPLOSIONOF LIFE.MAYThiswhichapplianceautomaticallyis equippedlights thewithpilot.an ignitionDo not trydevicethe pilot by hand. to lightBEFOREaround theOPERATINGappliance areaafterfora prolongedgas. Be sureoff,tosmellsmellallnextand willto thesettleflooronbecausethe floor.some gas is heavier than airWHATDo notTOtryDOto lightIF YOUanySMELLapplianceGASDoDo notnottouchuse anyanyphoneelectricin yourswitch* Immediately call your gas supplierbuilding.fromgas supplier'sa neighbour'sinstructions.phone. Follow the* Ifcallyouthecannotfire service.reach your gas supplier,Isolate this is not the accessible, appliance with isolate the at Service the gas Cock meter. inside. IfDoundernotwater.use thisImmediatelyappliancecallif anya qualifiedpart has beenserviceto replaceengineerany parttoofinspectthe controlthe appliancesystem andandany gas control which has been under water.CAUTION: Propane gas is heavier than airand will settle on the ground. Since propanecan accumulate in confined areas, extra careshould be exercised when lighting propaneheaters.OPERATING MODELS 055,105 and 155Quick StartCheck that the Electricity and Gas Supplies areon. Turn on the Pool Pump. Turn on the Heaterwith the switch on the Front Panel and set thedesired temperature with the Pool TemperatureKnob. In a few seconds the Heater will fire.Summary of Controls (Left to Right)SpaTemperatureRangekstop.tifKnobstop RingPool TemperatureRangeStandbyTemperaturePool Temperature Control Knob16°C to 41°C (60°F to 106°F)The Pool or Spa water temperature is controlledby the Pool Temperature Knob, rotate anticlockwiseto increase the Pool Temperature.The Knob is fitted with a means of limiting theupper temperature limit below the maximum level.The knob stop adjustment ring illustrated is adjustableby loosening the set screw, rotating theknobstop ring to the desired location andretightening the set screw.High LimitIf the Heater temperature rises too high theHigh Limit Thermostat will operate. Wait untilthe Heater is cool then press 'Reset'. It will clickif it has had to reset. The Heater should nowrun.If this problem persists this should beinvestigated by a Service Engineer.ON/OFF Switch - Turns the Heater On and Offand resets the Ignition Control if locked out. Forlonger periods of isolation the Heater should beswitched off at its Mains supply.318-02-04
Page 1 and 2: Natural Gas L.P.G. Serial No:MODEL:
Page 3: ContentsINSIDE COVER - GENERAL & PE
Page 7 and 8: Software Version 11 and aboveOPERAT
Page 9 and 10: Software Version 11 and aboveAFTER
Page 11 and 12: PART TWO - INSTALLATION/SERVICE INS
Page 13 and 14: CLEARANCESALL HEATERSFor clearances
Page 15 and 16: INDOOR HEATERThe design is also cer
Page 17 and 18: DIMENSIONS - 155 Model Only220mm(8
Page 19 and 20: GAS SUPPLY CONNECTIONSGas piping mu
Page 21 and 22: This page is intentionally left bla
Page 23 and 24: DAN MAINES055 Models OnlyINOUT185,
Page 25 and 26: WIRING DIAGRAM 055-105-155 MODELS O
Page 27 and 28: WIRING DIAGRAM 185-265-405 MODELS O
Page 29 and 30: SECTION 3 / SERVICING INSTRUCTIONSG
Page 31 and 32: 185 265 and 405 ModelsOn/OffSwitchT
Page 33 and 34: 3. To remove the manual reset high
Page 35 and 36: All ModelsDESOOTING PROCEDURECAUTIO
Page 37 and 38: PROBLEM CAUSE SOLUTIONPilot outage.
Page 39 and 40: ELECTRICAL TROUBLESHOOTING055, 105
Page 41 and 42: Software Version 11 and above185, 2
Page 43 and 44: For software version 011 and above4
Page 45 and 46: BBURNER TRAYKey Description - 055 M
Page 51 and 52: Key Description - 185, 265 & 405 Mo
Page 53: 17-05-04Station LaneIndustrial Esta

Pool & Spa Heaters

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?