Pool & Spa Heaters

More documents

Recommendations

Info

AFTER START-UPFeel the inlet and outlet pipes. Outlet pipe should beonly slightly warmer than the inlet. It should not behot.WARNING: Should overheating occur or the gassupply fail to shut off, turn off the manual gas controlto the appliance.VISUAL INSPECTIONWith the heater on, remove the door and make avisual check of the pilot and burner.The flame should be blue with a well-defined pattern.4" MAX100MMMAIN BURNER FLAMEPILOT BURNER FLAMEflame.tifeuropilot2.tifA yellow or "floating" flame indicates restricted airopenings or incorrect injector size. Should thisoccur, shut the heater off and contact your installeror gas supplier.WATER PRESSURE SWITCHA water pressure switch is provided in the heaterto shut off the burners in the event that watersupply to the heater is interrupted. It is veryimportant to verify that the switch electricallyopens and shuts off the gas valve when water flowto the heater is interrupted. Otherwise, rapid andsevere damage is likely to occur to the heater.(The water pressure switch should be checkedand adjusted for proper operation by a qualifiedservice person at the time of installation checkedthereafter.WARNING: Operation of the heater without watercirculation will cause rapid and severe damage tothe heater.5SECTION 2 / CAUTIONElevated water temperature can be hazardous, andthe U. S. Consumer Product Safety Commissionrecommends the following guidelines:1. <strong>Spa</strong> or hot tub water temperatures shouldnever exceed 40°C (104°F). A temperature of 38°C(100°F) is considered safe for a healthy adult.Special caution is suggested for young children.2. Drinking of alcoholic beverages before or duringspa or hot tub use can cause drowsiness whichcould lead to unconsciousness and subsequentlyresult in drowning.3. Pregnant Women Beware! Soaking in waterover 39°C (102°F) can cause fetal damage duringthe first three months of pregnancy resulting in thebirth of a brain-damaged or deformed child.Pregnant women should stick to the 38°C (100°F)maximum rule.4. Before entering the spa or hot tub, users shouldcheck the water temperature with an accuratethermometer; spa or hot tub ther mostats mayerr in regulating watertemperatures by as muchas 2°C (4°F).5. Persons with a medical history of heart disease, circulatory problems, diabetes, or bloodpressure problems should obtain a physician'sadvice before using pools or hot tubs.6. Persons taking medications which inducedrowsiness, such as tranquilizers, antihistamines,or anticoagulant, should not use spas or hot tubs.SECTION 3 / MAINTENANCE ANDCARE PROCEDURESThis heater casing is Polyester powder on top ofzinc coated steel to assist in resisting corrosion. It isrecommended that periodically the casing iscleaned and sprayed with WD40 or similar liquidespecially when installed outdoors. Exposedthreads on manifolds will benefit from a light coatingof grease. Outdoor tops are finished with a specialblack high temperature coating and as this is part ofthe flueing system, subject to high temperaturesand the elements, can discolour and corrode over aperiod of time.A full service by a competent person (i.e. CORGIregistered) should be conducted at least once ayear.1. Inspect top of heater and drafthood for soot, (asticky black substance around finned tubes and "V"baffles), and open flue gas passage ways. Ifsoot is present, contact installer or service agent.2. Inspect and operate all controls, gas valve andpressure relief valve.27-01-04
Software Version 11 and aboveAFTER START-UPWARNING: Should overheating occur or the gassupply fail to shut off, turn off the manual gas controlto the appliance.4" MAX100MMflame.tifeuropilot2.tifWATER PRESSURE SWITCHWARNING: Operation of the heater without watercirculation will cause rapid and severe damage tothe heater.SECTION 2 / CAUTION Pregnant Women Beware! SECTION 3 / MAINTENANCE ANDCARE PROCEDURES
Page 1 and 2: Natural Gas L.P.G. Serial No:MODEL:
Page 3 and 4: ContentsINSIDE COVER - GENERAL & PE
Page 5 and 6: FOR YOUR SAFETY READ BEFORE OPERATI
Page 7: Software Version 11 and aboveOPERAT
Page 11 and 12: PART TWO - INSTALLATION/SERVICE INS
Page 13 and 14: CLEARANCESALL HEATERSFor clearances
Page 15 and 16: INDOOR HEATERThe design is also cer
Page 17 and 18: DIMENSIONS - 155 Model Only220mm(8
Page 19 and 20: GAS SUPPLY CONNECTIONSGas piping mu
Page 21 and 22: This page is intentionally left bla
Page 23 and 24: DAN MAINES055 Models OnlyINOUT185,
Page 25 and 26: WIRING DIAGRAM 055-105-155 MODELS O
Page 27 and 28: WIRING DIAGRAM 185-265-405 MODELS O
Page 29 and 30: SECTION 3 / SERVICING INSTRUCTIONSG
Page 31 and 32: 185 265 and 405 ModelsOn/OffSwitchT
Page 33 and 34: 3. To remove the manual reset high
Page 35 and 36: All ModelsDESOOTING PROCEDURECAUTIO
Page 37 and 38: PROBLEM CAUSE SOLUTIONPilot outage.
Page 39 and 40: ELECTRICAL TROUBLESHOOTING055, 105
Page 41 and 42: Software Version 11 and above185, 2
Page 43 and 44: For software version 011 and above4
Page 45 and 46: BBURNER TRAYKey Description - 055 M
Page 51 and 52: Key Description - 185, 265 & 405 Mo
Page 53: 17-05-04Station LaneIndustrial Esta

Pool & Spa Heaters

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?