Page 50<strong>LXi</strong> Pool/Spa Heater Installation <strong>and</strong> Operation ManualFV+ FV-BL BK RF1 F2 24VACIGNITION CONTROLIGN240JKIGN120 L1 L2 IGN 12 11 13 14FS PWS W VAL GNDGY BK W BK O Y/BK BR YOBRGAS VALVEYWGYIHOT SURFACEIGNITERHWY/BKCAIR FLOWSWITCHNONCBKFLAME SENSETO COMBUSTIONAIR LOUVER STARTER(IF USED)TO PUMP STARTERCONTACTS (IF USED)Factory Wired 24VFactory Wired 120V/240VWATERPRESSSWITCHBK - BLACKBK/Y - BLACK WITH YELLOW TRACEBL - BLUEBR - BROWNG - GREENGY - GRAYO - ORANGER - REDV - VIOLETW - WHITEY - YELLOWY/BK - YELLOW WITH BLACK TRACEFigure 37. Test Point Identification Diagram (2 of 2)
<strong>LXi</strong> Pool/Spa Heater Installation <strong>and</strong> Operation Manual Page 51Section 11. Replacement Parts11.1 Ordering InformationTo order or purchase parts for the <strong>LXi</strong> pool <strong>and</strong>spa heater, contact your nearest <strong>J<strong>and</strong>y</strong> dealer or distributor.Access the <strong>J<strong>and</strong>y</strong> web site at www.j<strong>and</strong>y.comfor the nearest service center. If it cannot supply youwith what you need, contact <strong>J<strong>and</strong>y</strong>'s Customer ServiceDepartment at 1.707.776.8200, extension 245.NOTE To order the correct part, it is important thatyou state the model number, serial number<strong>and</strong> type of gas when applicable. Thisinformation is on the rating plate insid<strong>et</strong>he heater.11.2 Parts ListKeyModel No. OrderNo. DescriptionPart No.Heat Exchanger Components1 Compl<strong>et</strong>e Heat Exchanger (Copper) 250,300,400 R0453303,04,052 Tube Assy.(Cu), w/ Hdwr & Gskts 250,400,300 R0453403,05,063 Heat Exchanger End Baffl es 250,400,300 R0453503,05,064 Front Header, w/ Hdwr & Gskts All R04536005 By-Pass Assy, Compl<strong>et</strong>e All R04537006 Hardware <strong>and</strong> O-rings, Bypass All R04538007 Spring, Bypass All R04539008 Coupling Nut Kit, w/ O-ring,(S<strong>et</strong> of two)AllR04540009* O-ring, Coupling, (S<strong>et</strong> of two) All R045410010 Rear Header, w/ Hdwr & Gskts All R045420011 Gask<strong>et</strong>, Header, Front or Rear,(S<strong>et</strong> of 16)AllR045430012 Header Drain Plug w/ O-ring (S<strong>et</strong> of 3) All R045440013* Heat Exch. Hardware Kit & Gask<strong>et</strong>s All R045450014 Cap Sensor/Press Switch O-ring All R045540015 R<strong>et</strong>urn Header Cap & O-ring All R0454600Gas Components16 Burner w/ Gask<strong>et</strong> All R045470016 Burner w/ Tap <strong>and</strong> Gask<strong>et</strong> All R045470117 Manifold, Gas, Nat 250,300,400 R0454803,04,0517** Manifold, Gas, LP 250,300,400 R0455003,04,0518 Gas Valve Nat w/ Stre<strong>et</strong> Elbow All R045520018 Gas Valve LP w/ Stre<strong>et</strong> Elbow All R0455300Exhaust System19 Flue Collector w/ Gask<strong>et</strong>s 250,300,400 R0455503,04,0520 Blower Assy w/ Gask<strong>et</strong> All R045560021 Air Orifi ce Adjust Brack<strong>et</strong> All R045570022 Flue Vent Assy w/ Gask<strong>et</strong> 250,300,400 R0455803,04,0523 Outdoor Grill 250/300,400 R0456001,0224* Vent Hardware Kit All R045610025 Flue Box Assy w/ Gask<strong>et</strong> All R045620026* Side Wall Vent Kit 250/300,400 R0467301,02Electrical27 Transformer All R045630028 Air Pressure Switch All R045640029 Temperature Sensor (Regular) All R045650029 Temperature Sensor (Salt) All R047730030 Gask<strong>et</strong>, Temperature Sensor All R045660031 Plastic Sleeve, Temperature Sensor All R045670032 Plug Sensor All R0456800NOTES:1. All hardware s<strong>et</strong>s contain all pieces necessary for assembly, includinggask<strong>et</strong>s.2. Gask<strong>et</strong>s <strong>and</strong> hardware are included in all kits that involve the removal of agask<strong>et</strong> as part of the procedure to replace a part.* PARTS NOT SHOWN ON KEY VIEW** MANIFOLD KIT INCLUDES INSTALLED ORIFICES BUT DOES NOTINCLUDE GAS VALVE