ServiceManual

More documents

Recommendations

Info

03 FUEL SYSTEM SERVICE MANUAL MARINE ENGINES 03.09 Change fuel filter Water or other fuel contaminations may form deposits which clog the fuel filter and may lead to a disturbance. Therefore, change the fuel filter every 300 operating hours and/or every 2 years at least. 1 1 Ventilate fuel system. For this purpose, open fuel pipe between fuel filter and fuel supply (from fuel tank or water separator) on filter head (ill.1/pos.1), and operate the pump approx 6 times each 10 sec. = 6 times 10 sec. ignition ON. Make sure that air is sucked. 09.00 ill.1 ATTENION: Close fuel cock on tank, if tank is higher than fuel filer. 2 Unscrew filter (ill.2) by means of filter wrench No. 2300713/1. Remove filter and dispose. Take care that original seal does not adhere to filter housing. If so, remove seal and dispose. 3 Clean sealing surface on filter head (ill.3). 09.00 ill.2 4 Slightly oil seal of new fuel filter with clean motor oil (ill.4). 5 Screw on new fuel filter until seal slightly rests on sealing surface of filter head. Then tighten filter by hand with 3/4 turn. 6 Connect fuel pipe between fuel filter and fuel supply or water separator on filter head (ill.1/pos.1) again. 7 Ventilate fuel system. NOTE: Fuel system is ventilated via E-fuel pump. Turn ignition ON 6 times each 10 sec. 09.00 ill.3 8 Remove possibly spilled fuel residues. Start engine and check fuel system for leakage. 09.00 ill.4 Page FUEL SYSTEM - 30 Z001019/0_7_July 2012
SERVICE MANUAL MARINE ENGINES 03 FUEL SYSTEM 03.11 Replace GlOW Plug Preparation: 03.08.01 For 4 cyl. engines only for glow plug of second to fourth cylinder, remove intercooler - refer to 01.08.01 for glow plug of first cylinder, additionaly remove control solenoid - refer to For 6 cyl. engines only for glow plug of first cylinder, remove control solenoid - refer to 03.08.01 for glow plug of second to sixth cylinder, remove intercooler - refer to 01.08.01 1 Remove glow plug. 2 Unscrew glow plug(s) with special tool No.VR00146/0. 3 Screw in new glow plug(s) by means of special tool No. VR00146/0 and tighten by means of special tool No. 2300703/0 with a torque of 15 Nm +/-1. 11.00 ill.1 NOTE: Exactly keep torque of 15 Nm +/-1 when fixing glow plugs! 11.00 ill.2 Z001019/0_7_July 2012 Page FUEL SYSTEM - 31
Page 1 and 2:
STEYR MARINE ENGINES 4 CYLINDERS +
Page 3 and 4:
PREFACE STEYR MOTORS GmbH has devel
Page 5 and 6:
TABLE OF CONTENTS (MAIN ASSEMBLY GR
Page 7 and 8:
05 Cooling system 05.01 Cooler, hea
Page 9 and 10:
ToC SERVICE MANUAL MARINE ENGINES G
Page 11 and 12:
Page 13 and 14:
ToC SERVICE MANUAL MARINE ENGINES A
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
ToC SERVICE MANUAL MARINE ENGINES O
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
ToC SERVICE MANUAL MARINE ENGINES 0
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136: ToC SERVICE MANUAL MARINE ENGINES 0
Page 155 and 156: ToC SERVICE MANUAL MARINE ENGINES R
Page 157 and 158: SERVICE MANUAL MARINE ENGINES 03 FU
Page 185: SERVICE MANUAL MARINE ENGINES 03 FU
Page 193 and 194: SERVICE MANUAL MARINE ENGINES 03.14
Page 201 and 202: SERVICE MANUAL MARINE ENGINES 05 CO
Page 237 and 238:
Page 239 and 240:
Page 241 and 242:
Page 243 and 244:
Page 245 and 246:
Page 247 and 248:
Page 249 and 250:
Page 251 and 252:
Page 253 and 254:
Page 255 and 256:
Page 257 and 258:
Page 259 and 260:
Page 261 and 262:
Page 263 and 264:
Page 265 and 266:
Page 267 and 268:
Page 269 and 270:
L J 6 5 4 2 3 1 23 ToC SERVICE MANU
Page 271 and 272:
Page 273 and 274:
Page 275 and 276:
Page 277 and 278:
Page 279 and 280:
Page 281 and 282:
Page 283 and 284:
Page 285 and 286:
ToC SERVICE MANUAL MARINE ENGINES I
Page 287 and 288:
ToC SERVICE MANUAL MARINE ENGINES E
Page 289 and 290:
Page 291 and 292:
ToC SERVICE MANUAL MARINE ENGINES I
Page 293 and 294:
Page 295 and 296:
Page 297 and 298:
Page 299 and 300:
°C °F 250 80 40 100 120 0 L MAIN
Page 301 and 302:
°C °F 250 80 40 100 120 0 MAIN RP
Page 303 and 304:
Page 305 and 306:
Page 307 and 308:
Page 309 and 310:
Page 311 and 312:
Page 313 and 314:
Page 315 and 316:
Page 317 and 318:
Page 319 and 320:
Page 321 and 322:
Page 323 and 324:
Page 325 and 326:
Page 327 and 328:
Page 329 and 330:
Page 331:
show all

ServiceManual

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?