H-1100 - Smiths Medical
H-1100 - Smiths Medical
H-1100 - Smiths Medical
Create successful ePaper yourself
Turn your PDF publications into a flip-book with our unique Google optimized e-Paper software.
SECTION 10<br />
Troubleshooting<br />
Only qualified personnel authorized by the institution should perform any<br />
routine maintenance and repairs to the Level 1 ® NORMOFLO ® H-<strong>1100</strong><br />
Irrigation Fluid Warmer.<br />
The following two tables feature general troubleshooting information<br />
along with slow flow rate troubleshooting.<br />
General Troubleshooting Guide<br />
Problem Check the following<br />
No Power Check to see if unit is plugged in and power is turned ON.<br />
Be sure the unit is plugged into a working MAINS receptacle.<br />
Disposables<br />
Alarm activates<br />
Add<br />
Recirculating<br />
Solution Alarm<br />
activates<br />
Over<br />
Temperature<br />
Alarm activates<br />
Check to see that the Heat Exchanger and Disposable Set<br />
are properly installed.<br />
Fill reservoir to the maximum reservoir level with recirculating<br />
solution.<br />
Press OFF button to clear alarm. Then, press ON button to<br />
power on. If the Fluid Warmer continues to alarm,<br />
discontinue use of the medical device and remove from<br />
service. Contact <strong>Smiths</strong> <strong>Medical</strong> or an authorized<br />
representative for service.<br />
Hot Cabinet Check the air inlet on the bottom of the unit. Remove any<br />
blockage or dust to insure adequate air flow.<br />
Heat Exchanger<br />
hard to install<br />
Green Automatic<br />
Operating LED<br />
doesn't light up<br />
during setup<br />
Lubricate O-Rings in #1 and #2 block heat exchanger<br />
sockets with silicone lubricant. Silicone lubricant part<br />
# 80-04-002.<br />
Verify unit is plugged into MAINS.<br />
If still no LED illumination, discontinue use of the medical<br />
device and remove from service.<br />
30 Level 1 ® NORMOFLO ® H-<strong>1100</strong> Irrigation Fluid Warmer | Operator’s Manual<br />
S E C T I O N 1 0 • T r o u b l e s h o o t i n g