899883192 - Valiant

More documents

Recommendations

Info

Section 6 - Storage 7. Immediately remove the blue drain plug from the side of the thermostat housing or the heat exchanger. This must be removed within 30 seconds to properly vent the cooling system. b c a d a c d Closed Cooled Models 33144 a - Blue drain plug location b - Blue air pump Seawater Cooled Models c - Air manifold d - Green indicators 33150 8. Verify that water is draining from each opening. If not, use the Three Point Manual Drain System instructions. a a - Port side drain location b 6133 b - Starboard side drain location 9. Allow the system to drain for a minimum of five minutes. Pump air as necessary to keep the green indicators extended. 10. Crank the engine over slightly with the starter motor to purge any water trapped in the seawater pump. Do not allow engine to start. 11. Reinstall the blue drain plug in the thermostat housing or heat exchanger. 12. Remove the blue air pump from the air manifold and return it to the mounting bracket. 13. Mercury MerCruiser recommends leaving the drain system open while transporting the boat or while performing other maintenance. This helps ensure that all water is drained. Page 96 90-<strong>899883192</strong> NOVEMBER 2008
Section 6 - Storage 14. Before launching the boat, pull up on the manual release valve. Verify that the green indicators are no longer extended. BOAT OUT OF THE WATER a - Green indicators 6135 15. Open the seacock, if equipped, or unplug and reconnect the water inlet hose prior to operating the engine. NOTE: This procedure is written for the blue air pump that is attached to the engine. However, any air source can be used. 1. Place the boat on a lever surface to ensure complete draining of system. 2. Remove the blue air pump from the engine. 3. Ensure that the lever on top of the pump is flush with the handle (horizontal). 4. Install the air pump on the actuator fitting. 5. Pull lever on air pump (vertical) to lock pump on the fitting. a c e a d b a - Actuator fitting b - Green indicators c - Manual release valve 8293 d - Air pump e - Lever (locking) 90-<strong>899883192</strong> NOVEMBER 2008 Page 97
Page 1 and 2:
NOTE: The following applies to CE m
Page 3 and 4:
Welcome You have selected one of th
Page 5 and 6:
TABLE OF CONTENTS Section 1 - Warra
Page 7 and 8:
Checking...........................
Page 9 and 10:
Table of Contents Section 1 - Warra
Page 11 and 12:
Transfer of Warranty Section 1 - Wa
Page 13 and 14:
Section 1 - Warranty Conditions Tha
Page 15 and 16:
Global Warranty Charts Section 1 -
Page 17 and 18:
Warranty for Government Application
Page 19 and 20:
Warranty for Government Application
Page 21 and 22:
Commercial Application Warranty Cha
Page 23 and 24:
Section 1 - Warranty Mercury MerCru
Page 25 and 26:
How To Obtain Warranty Coverage Wha
Page 27 and 28:
Section 1 - Warranty Disclaimers An
Page 29 and 30:
Owner Responsibility "STD."—Emiss
Page 31 and 32:
Section 2 - Getting to Know Your Po
Page 33 and 34:
Page 35 and 36:
Instrumentation • consuming alcoh
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
SYNCHRONIZING DUAL HELMS PRIOR TO S
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Table of Contents Section 3 - On th
Page 53 and 54: Section 3 - On the Water • Do not
Page 55 and 56: Section 3 - On the Water Operation
Page 57 and 58: Section 3 - On the Water Operation
Page 59 and 60: 1. Refer to Remote Controls section
Page 61 and 62: Section 3 - On the Water Wave and W
Page 63 and 64: Ventilation Section 3 - On the Wate
Page 65 and 66: Section 4 - Specifications Section
Page 67 and 68: Section 4 - Specifications • Corr
Page 69 and 70: Propshaft power Displacement Altern
Page 71 and 72: Propshaft power Displacement Altern
Page 73 and 74: Table of Contents Section 5 - Maint
Page 75 and 76: Section 5 - Maintenance Maintenance
Page 77 and 78: Section 5 - Maintenance Task Interv
Page 79 and 80: Section 5 - Maintenance 1. Remove o
Page 81 and 82: Section 5 - Maintenance 3. Walter V
Page 83 and 84: Section 5 - Maintenance Changing Co
Page 85 and 86: Section 5 - Maintenance 11. Install
Page 87 and 88: Section 5 - Maintenance GEN III Mod
Page 89 and 90: Transmission Linkage Section 5 - Ma
Page 91 and 92: NEWTONE Section 5 - Maintenance 5.
Page 93 and 94: The Boat Out of the Water Section 5
Page 95 and 96: Section 5 - Maintenance IMPORTANT:
Page 97 and 98: Section 5 - Maintenance 14. Tag the
Page 99 and 100: Table of Contents Section 6 - Stora
Page 101 and 102: Section 6 - Storage 10. For additio
Page 103: Section 6 - Storage THREE POINT MAN
Page 107 and 108: Section 6 - Storage 12. Before laun
Page 109 and 110: Section 6 - Storage Battery Storage
Page 111 and 112: Table of Contents Section 7 - Troub
Page 113 and 114: Engine Will Not Start or Is Hard to
Page 115 and 116: Steering Wheel Jerks or Is Difficul
Page 117 and 118: Section 8 - Customer Assistance Inf
Page 119 and 120: PARTS AND ACCESSORIES INQUIRIES Res
show all

899883192 - Valiant

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?