899883192 - Valiant

More documents

Recommendations

Info

Section 7 - Troubleshooting Possible Cause Seawater pickups or sea strainer obstructed. Faulty thermostat. Coolant level (if equipped) low in closed cooling section. Heat Exchanger or Fluid Cooler plugged with foreign material Loss of pressure in closed cooling section. Faulty seawater pickup pump. Seawater discharge restricted or plugged. Insufficient Engine Temperature Remove obstruction. Replace. Remedy Check for cause of low coolant level and repair. Fill system with proper coolant solution. Clean Heat Exchanger, Engine Oil Cooler, and Transmission Oil Cooler (if equipped). Check for leaks. Clean, inspect and test pressure cap. Repair. Clean exhaust elbows. Faulty thermostat. Low Engine Oil Pressure Possible Cause Replace. Remedy Possible Cause Insufficient oil in crankcase. Excessive oil in crankcase (causing it to become aerated). Diluted or improper viscosity oil. Check and add oil. Remedy Check and remove required amount of oil. Check for cause of excessive oil (improper filling). Change oil and oil filter, using correct grade and viscosity oil. Determine cause for dilution (excessive idling). Battery Will Not Recharge Possible Cause Excessive current draw from battery. Alternator drive belt loose or in poor condition. Unacceptable battery condition. Loose or dirty electrical connections or damaged wiring. Faulty alternator Remedy Turn off non‐essential accessories. Replace and/or adjust. Test battery, replace if necessary. Check all associated electrical connections and wires (especially battery cables). Clean and tighten faulty connections. Repair or replace damaged wiring. Test alternator output, replace if necessary. Remote Control Is Difficult to Move, Has Excessive Play, or Makes Unusual Sounds Possible Cause Insufficient lubrication on shift and throttle linkage fasteners. Obstruction in shift or throttle linkages. Loose or missing shift and throttle linkages. Shift or throttle cable kinked. Lubricate. Remove obstruction. Remedy Check all throttle linkages. If any are loose or missing, see authorized Mercury MerCruiser dealer immediately. Straighten cable or have authorized Mercury MerCruiser dealer replace cable if damaged beyond repair. Page 106 90-<strong>899883192</strong> NOVEMBER 2008
Steering Wheel Jerks or Is Difficult to Turn Section 7 - Troubleshooting Possible Cause Low power steering pump fluid level. Drive belt loose or in poor condition. Insufficient lubrication on steering components. Lubricate. Loose or missing steering fasteners or parts. Contaminated power steering fluid. Remedy Check for leak. Refill system with fluid. Replace and/or adjust. Check all parts and fasteners if any are loose or missing, see authorized Mercury MerCruiser dealer immediately. See authorized Mercury MerCruiser dealer. 90-<strong>899883192</strong> NOVEMBER 2008 Page 107
Page 1 and 2:
NOTE: The following applies to CE m
Page 3 and 4:
Welcome You have selected one of th
Page 5 and 6:
TABLE OF CONTENTS Section 1 - Warra
Page 7 and 8:
Checking...........................
Page 9 and 10:
Table of Contents Section 1 - Warra
Page 11 and 12:
Transfer of Warranty Section 1 - Wa
Page 13 and 14:
Section 1 - Warranty Conditions Tha
Page 15 and 16:
Global Warranty Charts Section 1 -
Page 17 and 18:
Warranty for Government Application
Page 19 and 20:
Warranty for Government Application
Page 21 and 22:
Commercial Application Warranty Cha
Page 23 and 24:
Section 1 - Warranty Mercury MerCru
Page 25 and 26:
How To Obtain Warranty Coverage Wha
Page 27 and 28:
Section 1 - Warranty Disclaimers An
Page 29 and 30:
Owner Responsibility "STD."—Emiss
Page 31 and 32:
Section 2 - Getting to Know Your Po
Page 33 and 34:
Page 35 and 36:
Instrumentation • consuming alcoh
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
SYNCHRONIZING DUAL HELMS PRIOR TO S
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Table of Contents Section 3 - On th
Page 53 and 54:
Section 3 - On the Water • Do not
Page 55 and 56:
Section 3 - On the Water Operation
Page 57 and 58:
Section 3 - On the Water Operation
Page 59 and 60:
1. Refer to Remote Controls section
Page 61 and 62:
Section 3 - On the Water Wave and W
Page 63 and 64: Ventilation Section 3 - On the Wate
Page 65 and 66: Section 4 - Specifications Section
Page 67 and 68: Section 4 - Specifications • Corr
Page 69 and 70: Propshaft power Displacement Altern
Page 71 and 72: Propshaft power Displacement Altern
Page 73 and 74: Table of Contents Section 5 - Maint
Page 75 and 76: Section 5 - Maintenance Maintenance
Page 77 and 78: Section 5 - Maintenance Task Interv
Page 79 and 80: Section 5 - Maintenance 1. Remove o
Page 81 and 82: Section 5 - Maintenance 3. Walter V
Page 83 and 84: Section 5 - Maintenance Changing Co
Page 85 and 86: Section 5 - Maintenance 11. Install
Page 87 and 88: Section 5 - Maintenance GEN III Mod
Page 89 and 90: Transmission Linkage Section 5 - Ma
Page 91 and 92: NEWTONE Section 5 - Maintenance 5.
Page 93 and 94: The Boat Out of the Water Section 5
Page 95 and 96: Section 5 - Maintenance IMPORTANT:
Page 97 and 98: Section 5 - Maintenance 14. Tag the
Page 99 and 100: Table of Contents Section 6 - Stora
Page 101 and 102: Section 6 - Storage 10. For additio
Page 103 and 104: Section 6 - Storage THREE POINT MAN
Page 105 and 106: Section 6 - Storage 14. Before laun
Page 107 and 108: Section 6 - Storage 12. Before laun
Page 109 and 110: Section 6 - Storage Battery Storage
Page 111 and 112: Table of Contents Section 7 - Troub
Page 113: Engine Will Not Start or Is Hard to
Page 117 and 118: Section 8 - Customer Assistance Inf
Page 119 and 120: PARTS AND ACCESSORIES INQUIRIES Res
show all

899883192 - Valiant

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?