899883192 - Valiant

More documents

Recommendations

Info

Section 1 - Warranty Duration Of Coverage NOTE: Your dealer will register your engine for warranty coverage for you. The warranty registration process is not related in any way to the process of obtaining a license, title or registration from state boating authorities. You should ask your dealer to update your warranty registration information to reflect a change of address or a transfer of ownership. (This change may be made at any time.) See the Warranty Registration section of your manual or your dealer for more information. Mercury Marine warrants the components of the emissions control systems (see the components of the emission control system listed following) of its new, 2003 model year and later California certified inboard and sterndrive engines, registered to a California resident, to be free from defects in material or workmanship that cause the failure of a warranted part to be identical in all material respects to that part as described in the application of Mercury Marine for certification from the California Air Resources Board, for the period of time, and under the conditions identified below. The cost to diagnose a warranty failure is covered under the warranty (if the warranty claim is approved). Damage to other engine components caused by the failure of a warranted part will also be repaired under warranty. NOTE: Mercury Marine does not establish model years for the Mercury MerCruiser product line. In order to comply with CARB warranty regulations, and for that limited purpose only, model year shall have the same meaning as calendar year. As an example, 2003 model year products refers to products manufactured during calendar year 2003 This limited warranty provides coverage for the components of the emissions control systems. Select emission control parts from model year 2003‐2005 (inboard or sterndrive) engines are warranted for 2 years from either the date the product is first sold, or first put into service, whichever occurs first. Select emission control parts from 2006‐2007 (inboard or sterndrive) engines are warranted for 2 years from either the date the product is first sold, or first put into service, whichever occurs first. Select emission control parts from 2008 (inboard or sterndrive) engines are warranted for 3 years or 480 hours, whichever first occurs, from either the date the product is first sold, or first put into service, whichever occurs first. Select emission control parts from 2009 and later (inboard or sterndrive) engines are warranted for 3 years or 480 hours, whichever first occurs, from either the date the product is first sold, or first put into service, whichever occurs first. Emission related normal maintenance items such as spark plugs and filters, that are on the warranted parts list (see following) are warranted up to their first required replacement interval only. (See Maintenance Schedule). The repair or replacement of parts, or the performance of service under this warranty, does not extend the life of this warranty beyond its original expiration date. Unexpired warranty coverage can be transferred to a subsequent purchaser. (See instructions on transfer of warranty). Warranty coverage is terminated for used product repossessed from a retail customer, purchased at auction, from a salvage yard, or from an insurance company that obtained the product as a result of an insurance claim. Page 16 90-<strong>899883192</strong> NOVEMBER 2008
How To Obtain Warranty Coverage What Mercury Will Do What Is Not Covered Section 1 - Warranty The customer must provide Mercury with a reasonable opportunity to repair and reasonable access to the product for warranty service. Warranty claims shall be made by delivering the product for inspection to a Mercury dealer authorized to service the product. If purchaser cannot deliver the product to such a dealer, please notify Mercury Marine and Mercury will then arrange for the inspection and any covered repair. Purchaser in that case shall pay for all related transportation charges and/or travel time. If the service provided is not covered by this warranty, purchaser shall pay for all related labor and material, and any other expenses associated with that service. Purchaser shall not, unless requested by Mercury, ship the product or parts of the product directly to Mercury. Proof of registered ownership must be presented to the dealer at the time warranty service is requested in order to obtain coverage. Mercury Marine's sole and exclusive obligation under this warranty is limited to, at our expense and at our option, repairing or replacing defective parts with new or Mercury Marine certified re‐manufactured parts, or refunding the purchase price of the Mercury product. Mercury reserves the right to improve or modify products from time to time without assuming an obligation to modify products previously manufactured. This limited warranty does not cover routine maintenance items, tune ups, adjustments, normal wear and tear, damage caused by abuse, abnormal use, use of a propeller or gear ratio that does not allow the engine to run in its recommended wide‐open‐throttle RPM range (see Specifications), operation of the product in a manner inconsistent with the recommended operation procedures, neglect, accident, submersion, improper installation (proper installation specifications and techniques are set forth in the installation instructions for the product), improper service, use of an accessory or part not manufactured or sold by us, jet pump impellers and liners, operation with fuels, oils or lubricants which are not suitable for use with the product (see Specifications), alteration or removal of parts, or water entering the engine through the fuel intake, air intake or exhaust system. Use of the product for racing or other competitive activity, or operating with a racing type lower unit, at any point, even by a prior owner of the product, voids the warranty. Expenses related to haul‐out, launch, towing, storage, telephone, rental, inconvenience, slip fees, insurance coverage, loan payments, loss of time, loss of income, or any other type of incidental or consequential damages are not covered by this warranty. Also, expenses associated with the removal and/or replacement of boat partitions or material caused by boat design for access to the product are not covered by this warranty. Non‐warranty maintenance, replacement, or repair of emission control devices and systems may be performed by any marine engine repair establishment or individual. The use of non‐Mercury parts for non‐warranty maintenance or repairs will not be grounds for disallowing other warranty work. The use of add‐on (as defined at section 1900 (b)(1) and (b)(10) of Title 13 of the California Code of Regulations) or modified parts not exempted by the California Air Resources Board may be grounds for disallowing a warranty claim, at the discretion of Mercury Marine. Failures of warranted parts caused by the use of a non‐exempted add‐on or modified part will not be covered. Components Of The Emission Control System 1. Fuel Metering System a. Carburetor and internal parts (and/or pressure regulator or fuel injection system) b. Air/fuel ratio feedback and control system 90-<strong>899883192</strong> NOVEMBER 2008 Page 17
Page 1 and 2: NOTE: The following applies to CE m
Page 3 and 4: Welcome You have selected one of th
Page 5 and 6: TABLE OF CONTENTS Section 1 - Warra
Page 7 and 8: Checking...........................
Page 9 and 10: Table of Contents Section 1 - Warra
Page 11 and 12: Transfer of Warranty Section 1 - Wa
Page 13 and 14: Section 1 - Warranty Conditions Tha
Page 15 and 16: Global Warranty Charts Section 1 -
Page 17 and 18: Warranty for Government Application
Page 19 and 20: Warranty for Government Application
Page 21 and 22: Commercial Application Warranty Cha
Page 23: Section 1 - Warranty Mercury MerCru
Page 27 and 28: Section 1 - Warranty Disclaimers An
Page 29 and 30: Owner Responsibility "STD."—Emiss
Page 31 and 32: Section 2 - Getting to Know Your Po
Page 35 and 36: Instrumentation • consuming alcoh
Page 45 and 46: SYNCHRONIZING DUAL HELMS PRIOR TO S
Page 51 and 52: Table of Contents Section 3 - On th
Page 53 and 54: Section 3 - On the Water • Do not
Page 55 and 56: Section 3 - On the Water Operation
Page 57 and 58: Section 3 - On the Water Operation
Page 59 and 60: 1. Refer to Remote Controls section
Page 61 and 62: Section 3 - On the Water Wave and W
Page 63 and 64: Ventilation Section 3 - On the Wate
Page 65 and 66: Section 4 - Specifications Section
Page 67 and 68: Section 4 - Specifications • Corr
Page 69 and 70: Propshaft power Displacement Altern
Page 71 and 72: Propshaft power Displacement Altern
Page 73 and 74: Table of Contents Section 5 - Maint
Page 75 and 76:
Section 5 - Maintenance Maintenance
Page 77 and 78:
Section 5 - Maintenance Task Interv
Page 79 and 80:
Section 5 - Maintenance 1. Remove o
Page 81 and 82:
Section 5 - Maintenance 3. Walter V
Page 83 and 84:
Section 5 - Maintenance Changing Co
Page 85 and 86:
Section 5 - Maintenance 11. Install
Page 87 and 88:
Section 5 - Maintenance GEN III Mod
Page 89 and 90:
Transmission Linkage Section 5 - Ma
Page 91 and 92:
NEWTONE Section 5 - Maintenance 5.
Page 93 and 94:
The Boat Out of the Water Section 5
Page 95 and 96:
Section 5 - Maintenance IMPORTANT:
Page 97 and 98:
Section 5 - Maintenance 14. Tag the
Page 99 and 100:
Table of Contents Section 6 - Stora
Page 101 and 102:
Section 6 - Storage 10. For additio
Page 103 and 104:
Section 6 - Storage THREE POINT MAN
Page 105 and 106:
Section 6 - Storage 14. Before laun
Page 107 and 108:
Section 6 - Storage 12. Before laun
Page 109 and 110:
Section 6 - Storage Battery Storage
Page 111 and 112:
Table of Contents Section 7 - Troub
Page 113 and 114:
Engine Will Not Start or Is Hard to
Page 115 and 116:
Steering Wheel Jerks or Is Difficul
Page 117 and 118:
Section 8 - Customer Assistance Inf
Page 119 and 120:
PARTS AND ACCESSORIES INQUIRIES Res
show all

899883192 - Valiant

Create successful ePaper yourself

Delete template?

Save as template?