899883192 - Valiant

More documents

Recommendations

Info

Section 4 - Specifications NOTE: We do not recommend non‐detergent oils, multi‐viscosity oils (other than as specified), non FC‐W–rated synthetic oils, low‐quality oils, or oils that contain solid additives. Mercury Full-Synthetic MerCruiser Engine Oil, 20W-40, NMMA FC-W rated ORDER OF PREFERENCE MerCruiser/Quicksilver 25W-40 Synthetic Blend, NMMA FC-W rated 4-cycle MerCruiser oil Mercury/Quicksilver 25W-40, NMMA FC-W rated 4-cycle MerCruiser oil Other recognized brands of NMMA FC-W rated oils SAE40W SAE30W SAE 20W 0° C (32° F) AIR TEMPERATURE 10° C (50° F) 32878 Engine Specifications Inboard 5.7 MPI with Emissions Control NOTE: Performance specifications are obtained and corrected in accordance with SAE J1228/ISO 8665 Crankshaft Power. All measurements are taken with the engine at normal operating temperature. RPM range is measured using an accurate service tachometer with the engine at normal operating temperatures. Oil pressure must be checked with the engine at normal operating temperature. NOTE: Oil pressure specifications are for reference and may vary. Page 60 90-<strong>899883192</strong> NOVEMBER 2008
Propshaft power Displacement Alternator amperage RPM Minimum oil pressure Thermostat Timing at idle Hot Cold Section 4 - Specifications 224 kW (300 hp) 5.7 L (350 cid) 72 A 65 A WOT 4600–5000 Rev limiter 5150 Idle in neutral 600 At 2000 RPM At idle 124 kPa (18 psi) 41 kPa (6 psi) Seawater‐cooled models 71° C (160° F) MPI models with closed cooling 77° C (170° F) Not Adjustable Firing order 1‐8‐4‐3‐6‐5‐7‐2 Minimum battery rating Non‐DTS models DTS models 750 CCA, 950 MCA, 180 Ah 800 CCA, 1000 MCA, 190 Ah Spark plug type AC Platinum (AC 41‐993) Spark plug gap Inboard 6.2 MPI with Emissions Control 1.5 mm (0.060 in.) NOTE: Performance specifications are obtained and corrected in accordance with SAE J1228/ISO 8665 Crankshaft Power. All measurements are taken with the engine at normal operating temperature. RPM range is measured using an accurate service tachometer with the engine at normal operating temperatures. Oil pressure must be checked with the engine at normal operating temperature. Propshaft power Displacement Alternator amperage RPM Minimum oil pressure Thermostat Timing at idle Hot Cold 239 kW (320 hp) 6.2 L (377 cid) 72 A 65 A WOT 4600–5000 Rev limiter 5150 Idle in neutral 600 At 2000 RPM At idle 124 kPa (18 psi) 41 kPa (6 psi) Seawater‐cooled models 71° C (160° F) MPI models with closed cooling 77° C (170° F) Not Adjustable Firing order 1‐8‐4‐3‐6‐5‐7‐2 Minimum battery rating Non‐DTS models DTS models 750 CCA, 950 MCA, 180 Ah 800 CCA, 1000 MCA, 190 Ah Spark plug type AC Platinum (AC 41‐993) Spark plug gap 1.5 mm (0.060 in.) 90-<strong>899883192</strong> NOVEMBER 2008 Page 61
Page 1 and 2:
NOTE: The following applies to CE m
Page 3 and 4:
Welcome You have selected one of th
Page 5 and 6:
TABLE OF CONTENTS Section 1 - Warra
Page 7 and 8:
Checking...........................
Page 9 and 10:
Table of Contents Section 1 - Warra
Page 11 and 12:
Transfer of Warranty Section 1 - Wa
Page 13 and 14:
Section 1 - Warranty Conditions Tha
Page 15 and 16:
Global Warranty Charts Section 1 -
Page 17 and 18: Warranty for Government Application
Page 19 and 20: Warranty for Government Application
Page 21 and 22: Commercial Application Warranty Cha
Page 23 and 24: Section 1 - Warranty Mercury MerCru
Page 25 and 26: How To Obtain Warranty Coverage Wha
Page 27 and 28: Section 1 - Warranty Disclaimers An
Page 29 and 30: Owner Responsibility "STD."—Emiss
Page 31 and 32: Section 2 - Getting to Know Your Po
Page 35 and 36: Instrumentation • consuming alcoh
Page 45 and 46: SYNCHRONIZING DUAL HELMS PRIOR TO S
Page 51 and 52: Table of Contents Section 3 - On th
Page 53 and 54: Section 3 - On the Water • Do not
Page 55 and 56: Section 3 - On the Water Operation
Page 57 and 58: Section 3 - On the Water Operation
Page 59 and 60: 1. Refer to Remote Controls section
Page 61 and 62: Section 3 - On the Water Wave and W
Page 63 and 64: Ventilation Section 3 - On the Wate
Page 65 and 66: Section 4 - Specifications Section
Page 67: Section 4 - Specifications • Corr
Page 71 and 72: Propshaft power Displacement Altern
Page 73 and 74: Table of Contents Section 5 - Maint
Page 75 and 76: Section 5 - Maintenance Maintenance
Page 77 and 78: Section 5 - Maintenance Task Interv
Page 79 and 80: Section 5 - Maintenance 1. Remove o
Page 81 and 82: Section 5 - Maintenance 3. Walter V
Page 83 and 84: Section 5 - Maintenance Changing Co
Page 85 and 86: Section 5 - Maintenance 11. Install
Page 87 and 88: Section 5 - Maintenance GEN III Mod
Page 89 and 90: Transmission Linkage Section 5 - Ma
Page 91 and 92: NEWTONE Section 5 - Maintenance 5.
Page 93 and 94: The Boat Out of the Water Section 5
Page 95 and 96: Section 5 - Maintenance IMPORTANT:
Page 97 and 98: Section 5 - Maintenance 14. Tag the
Page 99 and 100: Table of Contents Section 6 - Stora
Page 101 and 102: Section 6 - Storage 10. For additio
Page 103 and 104: Section 6 - Storage THREE POINT MAN
Page 105 and 106: Section 6 - Storage 14. Before laun
Page 107 and 108: Section 6 - Storage 12. Before laun
Page 109 and 110: Section 6 - Storage Battery Storage
Page 111 and 112: Table of Contents Section 7 - Troub
Page 113 and 114: Engine Will Not Start or Is Hard to
Page 115 and 116: Steering Wheel Jerks or Is Difficul
Page 117 and 118: Section 8 - Customer Assistance Inf
Page 119 and 120:
PARTS AND ACCESSORIES INQUIRIES Res
show all

899883192 - Valiant

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?