SERVICE MANUAL - Appliance Blog

More documents

Recommendations

Info

SECTION B OWNER GUIDEFor your safety, the information in this manual must be followed to minimize the risk of fire orexplosion or to prevent property damage, personal injury or loss of life.- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.- WHAT TO DO IF YOU SMELL GAS:• Do not try to light any appliance.• Do not touch any electrical switch; do not use any phone in your building.• Clear the room, building or area of all occupants.• Immediately call your gas supplier from a neighbor's phone. Follow the gas supplier's instructions.• If you cannot reach your gas supplier, call the fire department.Installation and service must be performed by a qualified installer, service agency or the gas supplier.Versión en españolSi desea obtener una copia en español de esteManual del Usuario, sírvase escribir a la direcciónque se incluye a continuación. Solicite la P/N 131878600.Spanish Owner's GuidesFrigidaire Home ProductsP.O. Box 212378Augusta, GA 30917Product RegistrationThank you for choosing this dryer. This owner'sguide will explain proper operation and care.Record Your Model and Serial NumbersRecord below the model and serial numbers found onthe dryer serial plate located on the left side of thedoor opening. Keep these numbers for futurereference.Model Number ________________Serial Number _________________Date of Purchase ______________Register Your ProductThe self-addressed PRODUCT REGISTRATIONCARD should be filled in completely, signed andreturned.Important Safety InstructionsRead all instructions before using this dryer.To reduce the risk of fire, electricalshock, or injury to persons when using this dryer,comply with the basic warnings listed below.Failure to comply with these warnings could resultin serious personal injuries.Prevent FireDo not wash or dry items that have beenpreviously cleaned in, soaked in, or spotted with gasoline,cleaning solvents, kerosene, waxes, etc. Do not storethese items on or near the dryer. These substancesgive off vapors that could ignite or explode.Do not put oily or greasy rags or clothingon top of the laundry center. These substances give offvapors that could ignite the materials.Do not add gasoline, cleaning solvents,or other flammable or explosive substances to thewash water. These substances give off vapors thatcould ignite or explode.Under certain conditions, hydrogengas may be produced in a hot water system that has notbeen used for 2 weeks or more. HYDROGEN GAS ISEXPLOSIVE. If the hot water system has not beenused for such a period, before using the washer, turn onall hot water faucets and let the water flow from eachfor several minutes. This will release any accumulated20
hydrogen gas. Hydrogen gas is flammable; do notsmoke or use an open flame during this time.To prevent fire, do not use heat to dryitems containing plastic, foam rubber or similarly texturedrubber-like materials, or items containing feathers ordown. Use Air Fluff (No Heat) only.Clean the lint screen before or aftereach load. The interior of the dryer, lint screen housingand exhaust duct should be cleaned approximatelyevery 18 months by qualified service personnel. Anexcessive amount of lint build-up in these areas couldresult in inefficient drying and possible fire.Do not operate the dryer if the lint screenis blocked, damaged or missing. Fire hazard,overheating and damage to fabrics can occur. If yourdryer has a drying rack, always replace the lint screenwhen finished using the drying rack.Keep area around the exhaust openingand surrounding areas free from the accumulation oflint, dust and dirt.Do not operate the dryer if the lintscreen is blocked, damaged or missing. Fire hazard,overheating and damage to fabrics can occur. If yourdryer has a drying rack, always replace the lint screenwhen finished using the drying rack.Keep area around the exhaust openingand surrounding areas free from the accumulation oflint, dust and dirt.Do not obstruct the flow of ventilatingair. Do not stack or place laundry or throw rugs againstthe front or back of the laundry center.Do not spray any type of aerosol into,on or near laundry center at any time.Do not use fabric softeners or productsto eliminate static unless recommended by themanufacturer of the fabric softener or product.Failure to comply with these warnings could resultin fire, explosion, serious bodily injury and/or damageto the rubber or plastic parts of the laundry center.This Owner's Guide provides general operatinginstructions for your laundry center. It also containsinformation about features for several other models.Your laundry center may not have every feature included.Use the laundry center only as instructed in this Owner'sGuide.Avoid fire hazard or electrical shock. Donot use an adaptor plug or extension cord or removegrounding prong from electrical power cord. Failure tofollow this warning can cause serious injury, fire ordeath.ELECTRIC LAUNDRY CENTER:14-30RFUSED 30 AMP120/240 V OR120/208 VWALLRECEPTACLENote: The instructions appearing in this Owner's Guideare not meant to cover every possible condition andsituation that may occur. Common sense and cautionmust be practiced when installing, operating andmaintaining any appliance.Protect ChildrenCORRECTUse this way ONLYDRYERDRYER<strong>SERVICE</strong> CORDGAS LAUNDRY CENTER:Grounding typewall receptacleDo not underany circumstancescut, remove,or bypassthe grounding prongfrom this plug.Power supplycord with 3-pronggrounding plugCORRECTUse this way ONLYDo not allow children to play on or in thelaundry center. Close supervision of children isnecessary when the laundry center is used near children.As children grow, teach them the proper, safe use of allappliances.21
Page 1 and 2: (/(&752/8;Ã+20(Ã352'8&76Ã1257+Ã
Page 3 and 4: SAFE SERVICING PRACTICES 2QUICK REF
Page 5 and 6: Short unrestricted vents 51Electric
Page 7 and 8: Removing the control thermostat 101
Page 9 and 10: SpecificationsLAUNDRY CENTER WASHER
Page 11 and 12: Connecting Drive Motor for Bench Ch
Page 13 and 14: SAMPLE GAS DRYER SECTION WIRING DIA
Page 15 and 16: SAMPLE WASHER TIMER CYCLE CHARTCAM0
Page 17 and 18: The cycle signal will sound briefly
Page 19: • Prewash - When soaking is not n
Page 24 and 25: 5. If desired, add liquid bleach to
Page 26 and 27: • Do not combine stain removal pr
Page 28 and 29: Common Washing ProblemsMany washing
Page 31 and 32: 4. Close the dryer door and set dry
Page 33 and 34: To reduce risk of fire or serious i
Page 35 and 36: Avoid Service ChecklistBefore calli
Page 37 and 38: OCCURRENCEDRYERDryer does not start
Page 39 and 40: SECTION C INSTALLATION INSTRUCTIONS
Page 41 and 42: :$51,1* Do not allow combustible ma
Page 43 and 44: 0 IN.(0 CM )0 IN.(0 CM )1 IN.(2.54
Page 45 and 46: ELECTRICAL INSTALLATIONALL ELECTRIC
Page 47 and 48: &$87,21DO NOT CROSS THREAD OROVERTI
Page 49 and 50: SECTION D - DRYER SECTION OPERA-TIO
Page 51 and 52: ing times, hotter dryer surfaces an
Page 53 and 54: the control thermostat are cycled b
Page 55 and 56: switch, so the switch can be releas
Page 57 and 58: SECTION E - WASHER SECTION OPERA-TI
Page 59 and 60: Softener Dispenser:The softener dis
Page 61 and 62: magnetic field pulls the armature u
Page 63 and 64: flushing the lint out the drain. Be
Page 65 and 66: ELECTRICAL OPERATIONIn the washer s
Page 67 and 68: Timer Motor CircuitPower is not sup
Page 69 and 70: Terminal M7 supplies power to the s
Page 71 and 72:
Terminal M7 supplies power to the s
Page 73 and 74:
SECTION F - TROUBLESHOOTING FLOW CH
Page 75 and 76:
Gas Dryer Completely Inoperative.No
Page 77 and 78:
Electric Dryers Timer Advances in A
Page 79 and 80:
Gas Dryers Blower Motor Runs but Dr
Page 81 and 82:
Washer SectionNOTE: Always check th
Page 83 and 84:
Washer Does Not Drain.Note: Always
Page 85 and 86:
Drive Motor Does Not Turn.Note: Alw
Page 87 and 88:
Slow Water Fill.Note: Always check
Page 89 and 90:
Washer will Not Fill in AnySetting
Page 91 and 92:
Water Temperature is too Hot or too
Page 93 and 94:
Removing the access panel:1. The ac
Page 95 and 96:
Removing the fabric selector switch
Page 97 and 98:
Removing the dryer door heat shield
Page 99 and 100:
Replacing the front duct:1. Disconn
Page 101 and 102:
Removing the control thermostat and
Page 103 and 104:
2. Disconnect the manual shut off,
Page 105 and 106:
Removing the high limit thermostat:
Page 107 and 108:
2. The blower wheel can be removed
Page 109 and 110:
3. Remove the three screw in the fr
Page 111 and 112:
2. Place a screwdriver between tran
Page 113 and 114:
Removing the water inlet nozzle:2.
Page 115 and 116:
3. Disconnect the wires from the ca
Page 117 and 118:
3. Remove the bolt from the front l
Page 119 and 120:
3. Using a 1/2” socket remove the
Page 121 and 122:
Removing the washer cabinet:1. Disc
Page 123 and 124:
NOTES123
show all

SERVICE MANUAL - Appliance Blog

Create successful ePaper yourself

Delete template?

Save as template?