SERVICE MANUAL - Appliance Blog

More documents

Recommendations

Info

• Do not combine stain removal products,especially ammonia and chlorine bleach.Dangerous fumes may result.• Determine the kind of stain, then followrecommended treatment in the stain removalchart on the next page.• To pretreat stains, use a prewash product, liquiddetergent, or a paste made from granulardetergent and water.• Use cold water on unknown stains because hotwater can set stains.• Check care label instructions for treatments toavoid on specific fabrics.Do not combine stain removal products.• Never wash items which have been previouslycleaned in, washed in, soaked in or spotted withgasoline, dry cleaning solvents or otherflammable or explosive substances because theygive off vapors that could ignite or explode.• Never use highly flammable solvents, such asgasoline, inside the home. Vapors can explodeon contact with flames or sparks.For successful stain removal:• Remove stains promptly.Follow fabric care label instructions.• Check for colorfastness by testing stain removeron an inside seam.• Rinse and wash items after stain removal.Stain RemovalSTAINAdhesive tape, chewinggum, rubber cement.Baby formula, dairyproducts, egg.Beverages (coffee, tea,soda,juice, alcoholicbeverages).Blood.Candle wax, crayon.Chocolate.Collar or cuff soil,cosmetics.TREATMENTApply ice. Scrape off excess. Place stain face down on paper towels. Saturatewith prewash stain remover or nonflammable dry cleaning fluid.Use product containing enzymes to pretreat or soak stains. Soak for 30minutes or more. Wash.Pretreat stain. Wash using cold water and bleach safe for fabric.Rinse with cold water. Rub with bar soap. Or, pretreat or soak with productcontaining enzymes. Wash using bleach safe for fabric.Scrape off surface wax. Place stain face down between paper towels. Presswith warm iron until wax is absorbed. Replace paper towels frequently. Treatremaining stain with prewash stain remover or nonflammable dry cleaningfluid. Hand wash to remove solvent. Wash using bleach safe for fabric.Pretreat or soak in warm water using product containing enzymes. Wash usingbleach safe for fabric.Pretreat with prewash stain remover or rub with bar soap.26
STAINDye transfer on whitefabric.Grass.Grease, oil, tar (butter,fats,salad dressing,cooking oils, cargrease, motor oils).Ink.Mildew, scorch.Mud.Mustard, tomato.Nail polish.Paint, varnish.Perspiration.Rust, brown or yellowdiscoloration.Shoe polish.Urine, vomit, mucus,feces.TREATMENTUse packaged color remover. Wash using bleach safe for fabric.Pretreat or soak in warm water using product containing enzymes. Wash usingbleach safe for fabric.Scrape residue from fabric. Pretreat. Wash using hottest water safe for fabric. Forheavy stains and tar, apply nonflammable dry cleaning fluid to back of stain.Replace towels under stain frequently. Rinse thoroughly. Wash using hottestwater safe for fabric.Some inks may be impossible to remove. Washing may set some inks. Useprewash stain remover, denatured alcohol or nonflammable dry cleaning fluid.Wash with chlorine bleach if safe for fabric. Or, soak in oxygen bleach and hotwater before washing. Badly mildewed fabrics may be permanently damaged.Brush off dry mud. Pretreat or soak with product containing enzymes.Pretreat with prewash stain remover. Wash using bleach safe for fabric.May be impossible to remove. Place stain face down on paper towels. Apply nailpolish remover to back of stain. Repeat, replacing paper towels frequently. Do notuse on acetate fabrics.WATER BASED: Rinse fabric in cool water while stain is wet. Wash. Once paintis dry, it cannot be removed. OIL BASED AND VARNISH: Use solventrecommended on can label. Rinse thoroughly before washing.Use prewash stain remover or rub with bar soap. Rinse. Wash using nonchlorinebleach in hottest water safe for fabric.For spots, use rust remover safe for fabric. For discoloration of an entire load, usenonchlorine bleach. Do not use chlorine bleach because it may intensifydiscoloration.LIQUID: Pretreat with a paste of granular detergent and water. PASTE: Scraperesidue from fabric. Pretreat with prewash stain remover or nonflammable drycleaning fluid. Rinse. Rub detergent into dampened area. Wash using bleach safefor fabric.Pretreat or soak in product containing enzymes. Wash using bleach safe forfabric.27
Page 1 and 2: (/(&752/8;Ã+20(Ã352'8&76Ã1257+Ã
Page 3 and 4: SAFE SERVICING PRACTICES 2QUICK REF
Page 5 and 6: Short unrestricted vents 51Electric
Page 7 and 8: Removing the control thermostat 101
Page 9 and 10: SpecificationsLAUNDRY CENTER WASHER
Page 11 and 12: Connecting Drive Motor for Bench Ch
Page 13 and 14: SAMPLE GAS DRYER SECTION WIRING DIA
Page 15 and 16: SAMPLE WASHER TIMER CYCLE CHARTCAM0
Page 17 and 18: The cycle signal will sound briefly
Page 19 and 20: • Prewash - When soaking is not n
Page 21: hydrogen gas. Hydrogen gas is flamm
Page 24 and 25: 5. If desired, add liquid bleach to
Page 28 and 29: Common Washing ProblemsMany washing
Page 31 and 32: 4. Close the dryer door and set dry
Page 33 and 34: To reduce risk of fire or serious i
Page 35 and 36: Avoid Service ChecklistBefore calli
Page 37 and 38: OCCURRENCEDRYERDryer does not start
Page 39 and 40: SECTION C INSTALLATION INSTRUCTIONS
Page 41 and 42: :$51,1* Do not allow combustible ma
Page 43 and 44: 0 IN.(0 CM )0 IN.(0 CM )1 IN.(2.54
Page 45 and 46: ELECTRICAL INSTALLATIONALL ELECTRIC
Page 47 and 48: &$87,21DO NOT CROSS THREAD OROVERTI
Page 49 and 50: SECTION D - DRYER SECTION OPERA-TIO
Page 51 and 52: ing times, hotter dryer surfaces an
Page 53 and 54: the control thermostat are cycled b
Page 55 and 56: switch, so the switch can be releas
Page 57 and 58: SECTION E - WASHER SECTION OPERA-TI
Page 59 and 60: Softener Dispenser:The softener dis
Page 61 and 62: magnetic field pulls the armature u
Page 63 and 64: flushing the lint out the drain. Be
Page 65 and 66: ELECTRICAL OPERATIONIn the washer s
Page 67 and 68: Timer Motor CircuitPower is not sup
Page 69 and 70: Terminal M7 supplies power to the s
Page 71 and 72: Terminal M7 supplies power to the s
Page 73 and 74: SECTION F - TROUBLESHOOTING FLOW CH
Page 75 and 76: Gas Dryer Completely Inoperative.No
Page 77 and 78:
Electric Dryers Timer Advances in A
Page 79 and 80:
Gas Dryers Blower Motor Runs but Dr
Page 81 and 82:
Washer SectionNOTE: Always check th
Page 83 and 84:
Washer Does Not Drain.Note: Always
Page 85 and 86:
Drive Motor Does Not Turn.Note: Alw
Page 87 and 88:
Slow Water Fill.Note: Always check
Page 89 and 90:
Washer will Not Fill in AnySetting
Page 91 and 92:
Water Temperature is too Hot or too
Page 93 and 94:
Removing the access panel:1. The ac
Page 95 and 96:
Removing the fabric selector switch
Page 97 and 98:
Removing the dryer door heat shield
Page 99 and 100:
Replacing the front duct:1. Disconn
Page 101 and 102:
Removing the control thermostat and
Page 103 and 104:
2. Disconnect the manual shut off,
Page 105 and 106:
Removing the high limit thermostat:
Page 107 and 108:
2. The blower wheel can be removed
Page 109 and 110:
3. Remove the three screw in the fr
Page 111 and 112:
2. Place a screwdriver between tran
Page 113 and 114:
Removing the water inlet nozzle:2.
Page 115 and 116:
3. Disconnect the wires from the ca
Page 117 and 118:
3. Remove the bolt from the front l
Page 119 and 120:
3. Using a 1/2” socket remove the
Page 121 and 122:
Removing the washer cabinet:1. Disc
Page 123 and 124:
NOTES123
show all

SERVICE MANUAL - Appliance Blog

Create successful ePaper yourself

Delete template?

Save as template?