SERVICE MANUAL - Appliance Blog

More documents

Recommendations

Info

Prepare items for drying 30Check that lint screen is clean and in place 30Load the dryer 30Close the dryer door and set dryer controls 31Turn cycle selector clockwise to the desired setting 31Start the dryer 31When the cycle ends, remove items immediately and hang or fold 31Features 31Cycle signal control 31Drum light 31Drying rack 31Common drying problems 32Inside the washer 33Inside the Dryer 33Outside 33Before moving the laundry center 34Winterizing instructions 34Avoid service checklist 35 - 37Sample warranty 38SECTION C INSTALLATION INSTRUCTIONS 39 - 48What to do if you smell gas 39Pre-installation requirements 39Tools and materials required for installation 39Electrical requirements 39Electric laundry center 39Circuit 39Power supply 39Power supply cord kit 39Gas laundry center 40Circuit 40Power supply 40Power supply cord 40Water supply requirements 40Drain requirements 40Exhaust system requirements 40Exhaust lengths 41Gas supply requirements 42Location of your laundry center 42Do not install your laundry center 42Installation in recess or closet 42Mobile home installation 43Rough-in dimensions 44Unpacking 44Electrical installation 45 - 46All electric laundry centers 45Grounding requirements 45Canadian electric laundry center 45All gas laundry centers 45Electrical connections for a 3-wire system 46Electrical connections for a 4-wire system 46Installation 46 - 47Gas connection 47Replacement parts 48SECTION D - DRYER SECTION OPERATION 49 - 56Airflow electric dryers 49Airflow gas dryers 50Airflow problems 50Restrictions 51Air leaks 514
Short unrestricted vents 51Electrical operation electric dryer 51 - 53Automatic regular cycle 51Drive motor circuit 52The timer motor circuit 52The heat circuit 52The air fluff circuit 53The cycle signal circuit 53Automatic perm press 53Timed dry cycle 53Electrical operation gas dryer 54 - 56Auto dry cycle 54Drive motor circuit 54The timer motor circuit 55The heat circuit 55The air fluff circuit 56Automatic perm press 56The cycle signal circuit 56Timed dry cycle 56SECTION E - WASHER SECTION OPERATION 57 - 71Timer 57Pressure switch assembly 57Wash/rinse temperature switch 58Lid lock assembly 58Softener dispenser 59Agitator 59Bleach dispenser 59Water inlet valve 59Valve operation 60Drain pump 61The motor 61Transmission 62Spin basket or inner tub 62Splash tub cover 63Outer tub 63Leg and dome assembly 63Snubber 64Base 64Electrical operation 65 - 71Fill circuit 65Spray rinse during the first pump cycle with the temp switch set to 65All settings 65During the rinse cycle with temp switch set to 66All settings other than warm 66Warm 66Timer motor circuit 67Drain pump 68Drive motor 68 - 71High speed agitation 68Low speed agitation 69High speed spin 70Low speed spin 71SECTION F - TROUBLESHOOTING FLOW CHARTS 73 - 91Dryer section 73 - 80Electric dryer completely inoperative 74Gas dryer completely inoperative 75Electric dryers, blower motor runs but timer does notadvance in auto or timed dry 76Electric dryers, timer advances in timed dry but not in auto dry 765
Page 1 and 2: (/(&752/8;Ã+20(Ã352'8&76Ã1257+Ã
Page 3: SAFE SERVICING PRACTICES 2QUICK REF
Page 7 and 8: Removing the control thermostat 101
Page 9 and 10: SpecificationsLAUNDRY CENTER WASHER
Page 11 and 12: Connecting Drive Motor for Bench Ch
Page 13 and 14: SAMPLE GAS DRYER SECTION WIRING DIA
Page 15 and 16: SAMPLE WASHER TIMER CYCLE CHARTCAM0
Page 17 and 18: The cycle signal will sound briefly
Page 19 and 20: • Prewash - When soaking is not n
Page 21: hydrogen gas. Hydrogen gas is flamm
Page 24 and 25: 5. If desired, add liquid bleach to
Page 26 and 27: • Do not combine stain removal pr
Page 28 and 29: Common Washing ProblemsMany washing
Page 31 and 32: 4. Close the dryer door and set dry
Page 33 and 34: To reduce risk of fire or serious i
Page 35 and 36: Avoid Service ChecklistBefore calli
Page 37 and 38: OCCURRENCEDRYERDryer does not start
Page 39 and 40: SECTION C INSTALLATION INSTRUCTIONS
Page 41 and 42: :$51,1* Do not allow combustible ma
Page 43 and 44: 0 IN.(0 CM )0 IN.(0 CM )1 IN.(2.54
Page 45 and 46: ELECTRICAL INSTALLATIONALL ELECTRIC
Page 47 and 48: &$87,21DO NOT CROSS THREAD OROVERTI
Page 49 and 50: SECTION D - DRYER SECTION OPERA-TIO
Page 51 and 52: ing times, hotter dryer surfaces an
Page 53 and 54: the control thermostat are cycled b
Page 55 and 56:
switch, so the switch can be releas
Page 57 and 58:
SECTION E - WASHER SECTION OPERA-TI
Page 59 and 60:
Softener Dispenser:The softener dis
Page 61 and 62:
magnetic field pulls the armature u
Page 63 and 64:
flushing the lint out the drain. Be
Page 65 and 66:
ELECTRICAL OPERATIONIn the washer s
Page 67 and 68:
Timer Motor CircuitPower is not sup
Page 69 and 70:
Terminal M7 supplies power to the s
Page 71 and 72:
Terminal M7 supplies power to the s
Page 73 and 74:
SECTION F - TROUBLESHOOTING FLOW CH
Page 75 and 76:
Gas Dryer Completely Inoperative.No
Page 77 and 78:
Electric Dryers Timer Advances in A
Page 79 and 80:
Gas Dryers Blower Motor Runs but Dr
Page 81 and 82:
Washer SectionNOTE: Always check th
Page 83 and 84:
Washer Does Not Drain.Note: Always
Page 85 and 86:
Drive Motor Does Not Turn.Note: Alw
Page 87 and 88:
Slow Water Fill.Note: Always check
Page 89 and 90:
Washer will Not Fill in AnySetting
Page 91 and 92:
Water Temperature is too Hot or too
Page 93 and 94:
Removing the access panel:1. The ac
Page 95 and 96:
Removing the fabric selector switch
Page 97 and 98:
Removing the dryer door heat shield
Page 99 and 100:
Replacing the front duct:1. Disconn
Page 101 and 102:
Removing the control thermostat and
Page 103 and 104:
2. Disconnect the manual shut off,
Page 105 and 106:
Removing the high limit thermostat:
Page 107 and 108:
2. The blower wheel can be removed
Page 109 and 110:
3. Remove the three screw in the fr
Page 111 and 112:
2. Place a screwdriver between tran
Page 113 and 114:
Removing the water inlet nozzle:2.
Page 115 and 116:
3. Disconnect the wires from the ca
Page 117 and 118:
3. Remove the bolt from the front l
Page 119 and 120:
3. Using a 1/2” socket remove the
Page 121 and 122:
Removing the washer cabinet:1. Disc
Page 123 and 124:
NOTES123
show all

SERVICE MANUAL - Appliance Blog

Create successful ePaper yourself

Delete template?

Save as template?