SERVICE MANUAL - Appliance Blog

More documents

Recommendations

Info

QUICK REFERENCE SHEET1. Serial nameplate location:Dryer door edge2. Serial number breakdown.X E 2 3 0 0 1 3 6 7Incremented unit numberProduction weekLast digit of production yearProduct identificationManufacturing facility3. Tech sheet locationBack of access panel8
SpecificationsLAUNDRY CENTER WASHER SECTION ELECTRIC GASTransmissionAgitate Speed Oscillations Per Minute (High) 71 - 77 71 - 77Agitate Speed Oscillations Per Minute (Low) 47 - 51 47 - 51Spin Speed R.P.M. (High Speed) 600 - 640 600 - 640Spin Speed R.P.M. (Low Speed) 390 - 420 390 - 420Oil Capacity (Ounces) 32 32MotorMotor HP @ 120V, 60Hz. (Min OP - 100V Internal Thermal 1/2 & 3/4 1/2 & 3/4Overload Protection, Capacitor Start (189 - 210 Mfd., 135 Volt)One Speed (RPM) 1725 1725Two Speed (RPM) 1150/1725 1150/1725AgitateAgitate Wattage - Full Load (High Speed) Max. 750 950Agitate Wattage - Full Load (Low Speed) Max. 450 475SpinFull Spin Wattage - No Load (High Speed) 300 - 660 300 - 660Full Spin Wattage - No Load (Low Speed) 250 - 575 250 - 575Spin Wattage - No Load (High Speed) Max. After 10 Sec. 800 800Spin Wattage - No Load (High Speed) Max. After 10 Sec. 700 700Full Spin Wattage - Full Load (High Speed) 300 - 660 300 - 660Full Spin Wattage - Full Load (Low Speed) 250 - 575 250 - 575Spin Wattage - Full Load (High Speed) Max. After 10 Sec. 900 900Spin Wattage - Full Load (High Speed) Max. After 10 Sec. 700 700Tub Capacity / Water UsageCapacity (Cu. Ft.) 3.0 2.7Water Level (Inches) Measured from tub bottomLarge 13.5 - 15.2 10.8 - 13.0Small 5.5 - 7.8 4.3 - 6.6Water SupplyPressure (P.S.I.) Minimum/Maximum 30/120 30/120Water Flow Rate (G.P.M.) 3 - 14.6 3 - 14.6Drain PumpoutG.P.M. @ 36” (Min.) 12 12G.P.M. @ 96” (Min.) 7 7Agitator ClearanceAgitator Bottom to Tub .050 - .300 .050 - .300Component resistance - Ohms +/- 10% @ 77°FMotor4 Pole Main Winding (High Speed) 2.4 2.46 Pole Main Winding (Low Speed) If 2 Speed Motor 1.5 1.5Fill ValveHot Water Solenoid 880 880Cold Water Solenoid 880 880Timer Motor 2322 2322Pump Motor - Ohms +/- 7% @ 68°F 12 129
Page 1 and 2: (/(&752/8;Ã+20(Ã352'8&76Ã1257+Ã
Page 3 and 4: SAFE SERVICING PRACTICES 2QUICK REF
Page 5 and 6: Short unrestricted vents 51Electric
Page 7: Removing the control thermostat 101
Page 11 and 12: Connecting Drive Motor for Bench Ch
Page 13 and 14: SAMPLE GAS DRYER SECTION WIRING DIA
Page 15 and 16: SAMPLE WASHER TIMER CYCLE CHARTCAM0
Page 17 and 18: The cycle signal will sound briefly
Page 19 and 20: • Prewash - When soaking is not n
Page 21: hydrogen gas. Hydrogen gas is flamm
Page 24 and 25: 5. If desired, add liquid bleach to
Page 26 and 27: • Do not combine stain removal pr
Page 28 and 29: Common Washing ProblemsMany washing
Page 31 and 32: 4. Close the dryer door and set dry
Page 33 and 34: To reduce risk of fire or serious i
Page 35 and 36: Avoid Service ChecklistBefore calli
Page 37 and 38: OCCURRENCEDRYERDryer does not start
Page 39 and 40: SECTION C INSTALLATION INSTRUCTIONS
Page 41 and 42: :$51,1* Do not allow combustible ma
Page 43 and 44: 0 IN.(0 CM )0 IN.(0 CM )1 IN.(2.54
Page 45 and 46: ELECTRICAL INSTALLATIONALL ELECTRIC
Page 47 and 48: &$87,21DO NOT CROSS THREAD OROVERTI
Page 49 and 50: SECTION D - DRYER SECTION OPERA-TIO
Page 51 and 52: ing times, hotter dryer surfaces an
Page 53 and 54: the control thermostat are cycled b
Page 55 and 56: switch, so the switch can be releas
Page 57 and 58: SECTION E - WASHER SECTION OPERA-TI
Page 59 and 60:
Softener Dispenser:The softener dis
Page 61 and 62:
magnetic field pulls the armature u
Page 63 and 64:
flushing the lint out the drain. Be
Page 65 and 66:
ELECTRICAL OPERATIONIn the washer s
Page 67 and 68:
Timer Motor CircuitPower is not sup
Page 69 and 70:
Terminal M7 supplies power to the s
Page 71 and 72:
Terminal M7 supplies power to the s
Page 73 and 74:
SECTION F - TROUBLESHOOTING FLOW CH
Page 75 and 76:
Gas Dryer Completely Inoperative.No
Page 77 and 78:
Electric Dryers Timer Advances in A
Page 79 and 80:
Gas Dryers Blower Motor Runs but Dr
Page 81 and 82:
Washer SectionNOTE: Always check th
Page 83 and 84:
Washer Does Not Drain.Note: Always
Page 85 and 86:
Drive Motor Does Not Turn.Note: Alw
Page 87 and 88:
Slow Water Fill.Note: Always check
Page 89 and 90:
Washer will Not Fill in AnySetting
Page 91 and 92:
Water Temperature is too Hot or too
Page 93 and 94:
Removing the access panel:1. The ac
Page 95 and 96:
Removing the fabric selector switch
Page 97 and 98:
Removing the dryer door heat shield
Page 99 and 100:
Replacing the front duct:1. Disconn
Page 101 and 102:
Removing the control thermostat and
Page 103 and 104:
2. Disconnect the manual shut off,
Page 105 and 106:
Removing the high limit thermostat:
Page 107 and 108:
2. The blower wheel can be removed
Page 109 and 110:
3. Remove the three screw in the fr
Page 111 and 112:
2. Place a screwdriver between tran
Page 113 and 114:
Removing the water inlet nozzle:2.
Page 115 and 116:
3. Disconnect the wires from the ca
Page 117 and 118:
3. Remove the bolt from the front l
Page 119 and 120:
3. Using a 1/2” socket remove the
Page 121 and 122:
Removing the washer cabinet:1. Disc
Page 123 and 124:
NOTES123
show all

SERVICE MANUAL - Appliance Blog

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?