A R B O R Wood Stove - Avalon

More documents

Recommendations

Info

34 Maintaining Your ApplianceDoor Parts89134 5 67210ID # Description Qty Part # ID # Description Qty Part #1 Door, Left 1 2 Door, Right 13 Door Gasket 1 4 Gasket Cement 15 Glass Gasket 1 6 Glass 27 Glass Clip w Screws, Gasket 4 8 Door Hinge w Pins 49 Left Door Handle w Hardware 1 10 Right Door Handle w Hardware 1Replacing the GlassThe glass must not contact the door retainer or glass clips directly. The glass gasket and glass clipgaskets insulate the glass to prevent cracking. Do not over-tighten the glass clips.Replacing the Door GasketThe door gasket inserts into the outer groove of the door. <strong>Stove</strong> gasket cement holds it in place. Beforeinstalling, remove any residual cement. Lay the gasket in place (start at the lower left corner) and cut offany excess gasket (do not stretch the gasket. The cement fully cures with heat from the stove. You mayneed to open and close the door repeatedly to get the gasket to seat fully.Replacing the Loading Lid GasketThe loading lid gasket inserts into the groove below the loading lid. <strong>Stove</strong> gasket cement holds it inplace. Before installing, remove any residual cement. Lay the gasket in place (start at the back leftcorner) and cut off any excess gasket (do not stretch the gasket. The cement fully cures with heat fromthe stove. You may need to open and close the lid repeatedly to get the gasket to seat fully.Replacing the Door HandleSee the illustration above for a component list (see pg. 31 for details on adjusting the door).© Travis Industries 100-01190_000 4070808
Maintaining Your Appliance 35Firebox Parts7Apply penetrating oil (WD40) to the boltsprior to removal to prevent stripping.13275689This nut is located onthe exterior of the stovebeneath the rear heatshield.41ID # Description Qty Part # ID # Description Qty Part #1 Side Brick 2 250-00139 2 Combustion Brick w 2 Gaskets 1 250-001413 Inter-Ram Gasket 1 250-00294 4 Combustion Brick Gasket 1 250-001455 Back Brick 1 250-00140 6 Firebox Back w 4 Nuts & Bolts 1 250-007047 Brick Retainers with Bolts 1 250-00144 8 Combustor Pack with Gaskets 1 250-002479 Push Plugs (pack of 4) 2 92-1360 3Brick Removal & ReplacementDo not pry brick - they chip and crack easily. Remove the clips holding the side brick in place.Remove the side brick. Remove the clip holding the back brick in place. Lift the back brick up andremove. Remove the gasket on top of the combustion brick. Remove the combustion brick.Combustor Removal & ReplacementRemove the bricks first. Remove the four (4) screws holding the firebox back in place. Remove thefirebox back. Slide the combustor forward, taking care not to damage this component.© Travis Industries 100-01190_000 4070808
Page 1 and 2: \A r b o rWood StoveOwner's Manual
Page 3 and 4: Table of Contents 3General Informat
Page 5 and 6: Safety Precautions 5MobileHomeWhen
Page 7 and 8: Stove Installation (for qualified i
Page 15 and 16: Mobile Home RequirementsStove Insta
Page 19 and 20: Operating Your Appliance 19Safety N
Page 21 and 22: Bypass OperationOperating Your Appl
Page 23 and 24: Adjusting the Burn RateOperating Yo
Page 25 and 26: Operating Your Appliance 25Blower O
Page 27 and 28: Burn Procedure Pictorial OverviewOp
Page 29 and 30: TroubleshootingProblemSmoke Enters
Page 31 and 32: Maintaining Your Appliance 31Monthl
Page 33: Yearly Maintenance - ContinuedAdjus
Page 37 and 38: Limited 5 Year Warranty 37CONDITION
Page 39 and 40: 39 Optional EquipmentRear Blower In

A R B O R Wood Stove - Avalon

Create successful ePaper yourself

Delete template?

Save as template?