NOx Emissions from Cement Mfg - US Environmental Protection ...

More documents

Recommendations

Info

6-6
TABLE 6-2. CAPITAL COST COMPONENTS FOR EMISSION CONTROL DEVICE COST EVALUATION 2 Capital cost elements Direct costs (DC) Purchased equipment costs (PEC): C Control device and auxiliary equipment C Instrumentation C Sales taxes (3 percent of PEC) C Freight (5 percent of PEC) Direct installation costs (DIC): C Foundations and supports C Handling and erection C Electrical C Piping C Insulation for ductwork C Painting Total direct cost (DC) = PEC + DIC Indirect costs (IC) Indirect installation costs (IIC): C Engineering C Construction and field expenses C Contractor fees C Startup C Performance test C Model study Contingencies (C): C Equipment redesign and modifications C Cost escalations C Delays in startup Total indirect cost (IC) = IIC + C TOTAL CAPITAL COST (TCC) = DC + IC 6-7
Page 1 and 2:
EPA-453/R-94-004 ALTERNATIVE CONTRO
Page 3 and 4:
ALTERNATIVE CONTROL TECHNOLOGY DOCU
Page 5 and 6:
Chapter Page 4.1 MECHANISMS OF NO F
Page 7 and 8:
TABLE OF CONTENTS (con.) Chapter Pa
Page 9 and 10:
LIST OF TABLES Number Page 2-1 UNCO
Page 11 and 12:
CHAPTER 1 INTRODUCTION Congress, in
Page 13 and 14:
CHAPTER 2 SUMMARY This chapter pres
Page 15 and 16:
2.2 NO EMISSION CONTROL TECHNOLOGIE
Page 17 and 18:
TABLE 2-2. ACHIEVABLE NO REDUCTIONS
Page 19 and 20:
TABLE 2-4. CAPITAL AND ANNUAL COSTS
Page 21 and 22:
TABLE 2-5. COST EFFECTIVENESS OF NO
Page 23 and 24:
eductions ranged from 470 tons/year
Page 25 and 26:
CHAPTER 3 INDUSTRY DESCRIPTION 3.1
Page 27 and 28:
Type II. Moderate-heat-of-hardening
Page 29 and 30:
3 a TABLE 3-2. UNITED STATES CEMENT
Page 31 and 32:
Figure 3-1. U.S. Portland cement pl
Page 33 and 34:
Table 3-3. (con.) Rank Clinker 3 (1
Page 35 and 36:
5 cement processes: wet process and
Page 37 and 38:
Figure 3-3. New technology in dry-p
Page 39 and 40:
substantial levels of silica and al
Page 41 and 42:
are achieved by clinker coolers of
Page 43 and 44:
126,000 to 963,000 tons/year with a
Page 45:
such as crushing and grinding opera
Page 48 and 49:
4.1.1 Thermal NO Formation x Therma
Page 50 and 51:
temperatures are on the order of 16
Page 52 and 53:
4-6
Page 54 and 55:
expected to produce more fuel NO th
Page 56 and 57:
introduce a large proportion of com
Page 58 and 59:
will also mean a somewhat lower sec
Page 60 and 61:
ILC systems: In these systems, the
Page 62 and 63:
which indicates an average and the
Page 64 and 65:
4-18
Page 66 and 67:
Uncontrolled NO x emissions Plant c
Page 68 and 69:
from 2 to 9 lb/ton of clinker, and
Page 70 and 71: Capacity Heat in NO x emissions Met
Page 72 and 73: TABLE 4-3. (con.) Capacity Heat in
Page 78 and 79: in estimating uncontrolled and cont
Page 80 and 81: 13. Letter from Sheridan, S.E., to
Page 82 and 83: 44. Chemecology Corporation Source.
Page 84 and 85: 73. Letter and attachments from Smi
Page 86 and 87: NO control approaches applicable to
Page 88 and 89: 5.1.2.2 Kiln Fuel Changing the prim
Page 90 and 91: oxygen content of the primary air m
Page 92 and 93: tend to recirculate hot combustion
Page 94 and 95: e about 15 to 38 percent depending
Page 96 and 97: combustion system shown in Figure 5
Page 98 and 99: 5-14
Page 100 and 101: Figure 5-3. Schematic of hazardous
Page 102 and 103: 5-18
Page 104 and 105: higher than typical cement kiln flu
Page 106 and 107: window is in the middle of a kiln.
Page 108 and 109: Figure 5-4. Application of the sele
Page 110 and 111: in Section 5.1.2 is usually difficu
Page 112 and 113: 5.4 REFERENCES 1. Helmuth, R.A., F.
Page 114 and 115: 25. Letter from Wax, J., Institute
Page 116 and 117: TABLE 6-1. CEMENT KILN MODEL PLANTS
Page 118 and 119: 6-4
Page 122 and 123: The total capital cost is the sum o
Page 124 and 125: TABLE 6-3. ANNUALIZED COST ELEMENTS
Page 126 and 127: 6-12
Page 128 and 129: 6.1.3.7 Administrative Charges. The
Page 130 and 131: At this time only three installatio
Page 132 and 133: 6-18
Page 134 and 135: The annualized costs for low NOx bu
Page 136 and 137: No additional costs for utilities o
Page 138 and 139: 20 percent PEC cost for contingenci
Page 140 and 141: TABLE 6-7. ANNUALIZED COSTS FOR RET
Page 142 and 143: 6-28
Page 144 and 145: PEC for model plant 300,000 ' Heat
Page 146 and 147: TABLE 6-9. ANNUALIZED COSTS FOR MID
Page 148 and 149: 6-34
Page 150 and 151: TABLE 6-10. CAPITAL COSTS FOR A URE
Page 152 and 153: TABLE 6-11. ANNUAL OPERATING COSTS
Page 154 and 155: 6-40
Page 156 and 157: TABLE 6-12. CAPITAL COSTS FOR AN AM
Page 158 and 159: TABLE 6-13. ANNUAL OPERATING COSTS
Page 160 and 161: 6-46
Page 162 and 163: costs range from $9.9 million for t
Page 164 and 165: The estimated annualized costs for
Page 166 and 167: 6.3 COST EFFECTIVENESS OF NOx CONTR
Page 168 and 169: emoved. Cost effectiveness were det
Page 170 and 171:
TABLE 6-17. COST EFFECTIVENESS OF R
Page 172 and 173:
6-58
Page 174 and 175:
TABLE 6-18. COST EFFECTIVENESS OF M
Page 176 and 177:
TABLE 6-19. COST EFFECTIVENESS OF U
Page 178 and 179:
6.3.4 Selective Catalytic Reduction
Page 180 and 181:
6-66
Page 182 and 183:
TABLE 6-21. COST EFFECTIVENESS OF S
Page 184 and 185:
6-70
Page 186 and 187:
11. Letter and attachments from Nov
Page 188 and 189:
Tables 7-1 7-2
Page 190 and 191:
TABLE 7-2. REDUCTION IN NO x EMISSI
Page 192 and 193:
model plants described in Section 6
Page 194 and 195:
temperature and excess air may be u
Page 196 and 197:
NOxemissions will form. The heater
Page 198:
equirement for the flue gas reheati
show all

NOx Emissions from Cement Mfg - US Environmental Protection ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?