RPL: RAH, Size 077, Vintage C, RoofPak Draw Thru / Blow Thru Air ...

More documents

Recommendations

Info

Section N- Main Control Box Control Panel- Units with MicroTech II Controls (C12= LD, LS, BD, BS, ED, ES, SD, SS)— 1/01 until 3/05 Components, Continued Sch. Part Part Qty. Sym. Description Relays, Continued Number R30 Relay- Cooling Face & Bypass until 11/02 026213000 1 Relay- Cooling Face & Bypass 11/02 & later 032508101 1 R46,47 Relay- Supply Fan 072789226 1 1 R48,49 Relay- Exhaust Fan Inverter 072789226 1 1 R67 Relay, Control- units with inverters (C14= 1-9) 073305401 1 Relay, Control- units without inverters (C14= Y) 026213000 1 R68 Relay- Return Fan w/ Inverter or Exhaust Fan 073305401 1 Relay- Return Fan without inverter 026213000 1 R69 Relay- Inverters w/ bypass (C14= 1, 2, 3, 4, 5) Main MicroTech Controller and Associated Boards 032508101 1 MCB Main Controller- Must be programmed (unit GO# required) 060006101 1 Com Card- Bacnet (C12= B*) 060006202 1 Com Card- Bacnet with Ethernet (C12= E*) 060006201 1 Com Card- LonMark with Space Control (C12= LS) 060006203 1 Com Card- LonMark with Discharge Control (C12= LD) 060006204 1 Standoff- Com Card 048166706 4 Kit- Connector Repair 300036605 1 Power Supply- 5 VDC 111049610 1 Serial Port Ribbon Cable 111047201 1 Battery 049754501 1 EHB1 Electric Heat Board (C4= E) 112026101 5 1 Communication Module 060006202 1 GCB1 Condenser Board 112026101 5 1 Communication Module 060006202 1 Keypad Keypad Assy (Code 19= R or Y) 060006301 1 Board- Remote Keypad Interface (Code 19= R) 112021601 1 Cable- Keypad Transducers and Pressure Controls 111044601 1 SPS1 Static Pressure Transducer- Duct (C13= 1, 2, 3) 049545007 4 1 SPS2 Static Pressure Transducer- Duct (C13= 2) 049545007 4 1 Static Pressure Transducer- Building (C13= 3, 4) 049545006 1 DHL Duct Hi-Limit Pressure Control 065493801 1 Pressure Fitting- DHL Power Supply 049763002 1 Power Supply- Design Flow Units 111049610 1 Terminal Block for Power Supply Sensors 065499809 1 ZNT1 Sensor- Zone Temperature w/ Tenant Override 2 111048101 1 Sensor- Zone Termp. w/ Tenant Override & Remote Setpoint Adjustment 3, 2 111048102 1 DAT Sensor- Discharge Air Temperature 2 060004705 1 ENT Sensor- Entering Air Temperature 2 060004705 1 OAT Sensor- Outside Air Temperature 2 060004705 1 RAT Sensor- Return Air Temperature 2 060004705 1 1 Relay Assembly. Consists of: Relay- p/n 060017101; Socket Only- p/n 060016901; Clip Only- p/n 060017001. 2 Not Shown on diagram. 3 SCC Units only- Code 12= BS, LS, ES, SS. 4 Prior to 8/02 the duct sensor was p/n 049545005. 049545007 is a direct replacement on MicroTech II units. 5 The board mounts with standoffs p/n 048166707 (qty. 7). The Communication Module mounts with standoffs p/n 048166707 (qty. 4) RoofPak Singlezone; RAH 077 “C” Rev. Q 07/12 RPL 700008300 / Page 170
Section N- Main Control Box Control Panel- Units without MicroTech Controls (C12= YC, YM, YY)— Until 3/05* Diagram * Code 08= P. Between 10/04 and 3/05 either this control panel or the current control panel (Code 08= D) could be installed. Check the GO or visually inspect the unit to verify which panel is installed. Deadfront Door (shown open) F3 R69 R70 R67 R68 R 24 T B 7 T B 8 R20 T2 TD 19 R63 TD9 RoofPak Singlezone; RAH 077 “C” Rev. Q 07/12 RPL 700008300 / Page 171 T B 6 N B 1 TB2 DHL S1 HS1 F1 REC1 GFR1*GFR2* S4 S5 * GFR1 & GFR2 are detailed with the GFS1, GFS2 in the power panel section. T B 5 T B 10 N B 2
Page 1 and 2:
Replacement Parts List No. 70000830
Page 3 and 4:
Contents Continued Section F- Suppl
Page 5 and 6:
Parts List Revision History Rev. Da
Page 7 and 8:
R = RoofPak Unit Configuration AH =
Page 9 and 10:
General Options Unit Model Codes th
Page 11 and 12:
Code 16= Smoke Detectors 1= Supply
Page 13 and 14:
Code 31= Supply Air Fan 33A()= 33
Page 15 and 16:
Electrical Legend Schematic Sym. De
Page 17 and 18:
Electrical Legend Continued Schemat
Page 19 and 20:
Section A- Outdoor/Return Air Secti
Page 21 and 22:
29 23 26 Section A- Outdoor/Return
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
6 6A Inverter- 2 Fan Units (Code 24
Page 33 and 34:
165 128 152 167 136 Mixing Box Asse
Page 35 and 36:
115 114 110 128 116 Section A- Outd
Page 37 and 38:
90 93 89 92 188 189 190 123 156 155
Page 39 and 40:
11 Section A- Outdoor/Return Air Se
Page 41 and 42:
Bottom Return Shown C19= BY or BE E
Page 43 and 44:
Section B- Draw-Thru Filter/Blank S
Page 45 and 46:
Section B- Draw-Thru Filter/Blank S
Page 47 and 48:
Section D- Draw-Thru Combination Co
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
21 Section D- Draw-Thru Combination
Page 59 and 60:
Section E- Draw-Thru Heat Section H
Page 61 and 62:
Section F- Supply Air Section Forwa
Page 63 and 64:
19 27 Detail A 6 26 14 VAV detail o
Page 65 and 66:
65 Section F- Supply Air Section Ai
Page 67 and 68:
Section F- Supply Air Section Air F
Page 69 and 70:
90 89 161 or 61 63 or 163 190 92 91
Page 71 and 72:
90 89 190 92 91 188 189 123 156 Rub
Page 73 and 74:
90 89 190 92 91 188 189 123 156 Rub
Page 75 and 76:
90 89 190 92 91 188 189 123 156 Rub
Page 77 and 78:
90 89 190 92 91 188 189 123 156 Rub
Page 79 and 80:
90 89 190 92 91 188 189 123 156 Rub
Page 81 and 82:
90 89 190 92 91 188 189 123 156 Rub
Page 83 and 84:
90 89 190 92 91 188 189 123 156 Rub
Page 85 and 86:
Section F- Supply Air Section Suppl
Page 87 and 88:
Section F- Supply Air Section Inver
Page 89 and 90:
40 50 Section F- Supply Air Section
Page 91 and 92:
40 50 Section F- Supply Air Section
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Code 15= A Model 550 (8/04 & Later)
Page 103 and 104:
Page 105 and 106:
15 20 Until 1/00 67 98 99 Section F
Page 107 and 108:
Section F- Supply Air Section Secti
Page 109 and 110:
Section G- Blow-Thru Heat Section O
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
DS3 or PB3 FB33 FB32FB36FB31FB35 M3
Page 119 and 120: Section G- Blow-Thru Heat Section O
Page 133 and 134: 25 24 Detail Section G- Blow-Thru H
Page 137 and 138: 26 25 Section G- Blow-Thru Heat Sec
Page 139 and 140: 26 25 FSG Detail Section G- Blow-Th
Page 141 and 142: 234 234 205 Section G- Blow-Thru He
Page 143 and 144: 226 Section G- Blow-Thru Heat Secti
Page 145 and 146: 253 500 - 2000 MBH Furnaces UL Appr
Page 147 and 148: 500 - 650 MBH Furnaces UL (C07= EU,
Page 149 and 150: 275 283 500 - 790MBH 800,1000 MBH C
Page 157 and 158: Section H- Blow-Thru Heat Blank Acc
Page 159 and 160: Primary Codes that pertain: 39 Addi
Page 161 and 162: Section K- Discharge Plenum Section
Page 163 and 164: Section L- Out-of-Airstream Blank A
Page 165 and 166: Keypad Section N- Main Control Box
Page 167 and 168: Section N- Main Control Box Control
Page 169: Section N- Main Control Box Control
Page 173 and 174: Section N- Main Control Box Power P
Page 175 and 176: Power Panel- Power Blocks, Disconne
Page 195 and 196: Section N- Main Control Box MicroTe
Page 211 and 212: Short Circuit 3C Alarm Aux. Contact
Page 217 and 218: See Control Panel Section N- Main C
Page 221 and 222:
Section N- Main Control Box Power P
Page 223 and 224:
Front Mtd. Contact 3E Link 3B MMP10
Page 225 and 226:
Page 227 and 228:
Page 229:
2 Control Box McQuay Supplied Line
show all

RPL: RAH, Size 077, Vintage C, RoofPak Draw Thru / Blow Thru Air ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?