RPL: RAH, Size 077, Vintage C, RoofPak Draw Thru / Blow Thru Air ...

More documents

Recommendations

Info

Section N- Main Control Box Power Panel 1/07 to present* Components Power Panel- MMP, Contactors, DS1 Disconnect Switches Sch. Part Part Voltage Sym. Description Number 208V 230V 460V 575V Manual Motor Protectors MMP10 MMP- Supply Fan Motor See 1 Page After Next MMP20 MMP- Return Fan Motor See 1 Page After Next Contactors M10 Contactor- Supply Fan Motor See 1 Page After Next M20 Contactor- Return Fan Motor See 1 Page After Next Disconnect Switch DS1 Disconnect Switch- Main Code 11= A2, B2, C2, D2 Electric Heat (C04= E) units Switch- 100A 1 349935125 1 1 1 1 Handle Kit 349935521 1 1 1 1 Shaft 349962204 1 1 1 1 Ground Lug 349938001 1 1 1 1 Switch- 150A 1 349935126 1 1 1 1 Handle Kit 349935532 1 1 1 1 Shaft 349962205 1 1 1 1 Ground Lug 349938001 1 1 1 1 Switch- 250A 1 349935226 1 1 1 1 Handle Kit 349935532 1 1 1 1 Shaft 349962205 1 1 1 1 Ground Lug 349938001 1 1 1 1 Switch- 400A 1 349935325 1 1 1 1 Handle Kit 349935621 1 1 1 1 Shaft 349962206 1 1 1 1 Ground Lug 349938002 1 1 1 1 Switch- 600A 1, 2, 3, 4 193438205 1 1 1 1 Handle 349961102 1 1 1 1 Operating Mechanism 193455001 1 1 1 1 Shaft 349961301 1 1 1 1 Shaft- Mod 349962242 1 1 1 1 Ground Lug 349938002 1 1 1 1 Switch- 800A 1, 4 193438201 1 1 1 1 Handle 349961102 1 1 1 1 Operating Mechanism 193455001 1 1 1 1 Shaft 349961301 1 1 1 1 Shaft- Mod 349962242 1 1 1 1 Ground Lug 349938003 1 1 1 1 Switch- 1000A 1, 4 193438206 1 1 1 1 Handle 349961102 1 1 1 1 Operating Mechanism 193455001 1 1 1 1 Shaft 349961301 1 1 1 1 Shaft- Mod 349962242 1 1 1 1 Ground Lug 349938003 1 1 1 1 1 Any of the listed disconnects may be used, depending on unit options. Check installed part to verify, or contact Daikin McQuay Parts with unit serial and/or GO number to insure correct replacement is selected. 2 The 600A switch listed is used on units with one disconnect or two disconnects EH/balance of unit (Code 11= A2 or B2). 3 If unit has two disconnects where the second disconnect controls the fans (Code 11= C2) or 3 disconnects (Code 11= D2) then use switch p/n 193438002, handle kit p/n 193437901, shaft p/n 349962233, and ground lug p/n 349938002. 4 Note that the original disconnect is obsolete. Due to dimensional differences minor field modifications may be required for proper installation. * Code 08= D. If unit was built between 10/06 and 12/06 contact Daikin McQuay Parts. RoofPak Singlezone; RAH 077 “C” Rev. Q 07/12 RPL 700008300 / Page 220
Section N- Main Control Box Power Panel 1/07 to present* Components * Code 08= D. If unit was built between 10/06 and 12/06 contact Daikin McQuay Parts. Power Panel- DS1, DS2 Disconnect Switches Sch. Part Part Voltage Sym. Description Number 208V 230V 460V 575V Disconnect Switch, Continued DS1 Disconnect Switch- Main Code 11= A2, B2, C2, D2 Gas, Steam, HW or No Heat (C04= A, S, W, Y) units Switch- 100A 1, 2 349935121 1 1 1 1 Handle Kit 349935521 1 1 1 1 Shaft 349962204 1 1 1 1 Ground Lug 349938001 1 1 1 1 Switch- 150A 1, 3 349935122 1 1 1 1 Handle Kit (with operating mechanism) 349935532 1 1 1 1 Shaft 349962205 1 1 1 1 Ground Lug 349938001 1 1 1 1 Switch- 250A 1, 4 349935222 1 1 1 1 Handle Kit (with operating mechanism) 349935532 1 1 1 1 Shaft 349962205 1 1 1 1 Ground Lug 349938001 1 1 1 1 Switch- 400A 1, 5 349935321 1 1 1 1 Handle Kit (with operating mechanism) 349935621 1 1 1 1 Shaft 349962206 1 1 1 1 Ground Lug 349938002 1 1 1 1 DS2 Disconnect Switch- SAF/RAF C11= C2 or D2 Switch- 100A 1, 2 349935121 1 1 1 1 Handle Kit (with operating mechanism) 349935521 1 1 1 1 Shaft 349962204 1 1 1 1 Ground Lug 349938001 1 1 1 1 Switch- 150A 1, 3 349935122 1 1 1 1 Handle Kit (with operating mechanism) 349935532 1 1 1 1 Shaft 349962205 1 1 1 1 Ground Lug 349938001 1 1 1 1 Switch- 250A 1, 4 349935222 1 1 1 1 Handle Kit (with operating mechanism) 349935532 1 1 1 1 Shaft 349962205 1 1 1 1 Ground Lug 349938001 1 1 1 1 Switch- 400A 1, 5 349935321 1 1 1 1 Handle Kit (with operating mechanism) 349935621 1 1 1 1 Shaft 349962206 1 1 1 1 Ground Lug 349938002 1 1 1 1 1 Any of the listed disconnects may be used, depending on unit options. Check installed part to verify, or contact Daikin McQuay Parts with unit serial and/or GO number to insure correct replacement is selected. 2 Also uses a Load Lug p/n 349956101 with cover p/n 349957003. 2 Also uses a Load Lug p/n 349956202 with cover p/n 349957001. 2 Also uses a Load Lug p/n 349956301 with cover p/n 349957002. 2 Also uses a 3 Load Lugs p/n 349956401 with cover p/n 349957004. RoofPak Singlezone; RAH 077 “C” Rev. Q 07/12 RPL 700008300 / Page 221
Page 1 and 2:
Replacement Parts List No. 70000830
Page 3 and 4:
Contents Continued Section F- Suppl
Page 5 and 6:
Parts List Revision History Rev. Da
Page 7 and 8:
R = RoofPak Unit Configuration AH =
Page 9 and 10:
General Options Unit Model Codes th
Page 11 and 12:
Code 16= Smoke Detectors 1= Supply
Page 13 and 14:
Code 31= Supply Air Fan 33A()= 33
Page 15 and 16:
Electrical Legend Schematic Sym. De
Page 17 and 18:
Electrical Legend Continued Schemat
Page 19 and 20:
Section A- Outdoor/Return Air Secti
Page 21 and 22:
29 23 26 Section A- Outdoor/Return
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
6 6A Inverter- 2 Fan Units (Code 24
Page 33 and 34:
165 128 152 167 136 Mixing Box Asse
Page 35 and 36:
115 114 110 128 116 Section A- Outd
Page 37 and 38:
90 93 89 92 188 189 190 123 156 155
Page 39 and 40:
11 Section A- Outdoor/Return Air Se
Page 41 and 42:
Bottom Return Shown C19= BY or BE E
Page 43 and 44:
Section B- Draw-Thru Filter/Blank S
Page 45 and 46:
Section B- Draw-Thru Filter/Blank S
Page 47 and 48:
Section D- Draw-Thru Combination Co
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
21 Section D- Draw-Thru Combination
Page 59 and 60:
Section E- Draw-Thru Heat Section H
Page 61 and 62:
Section F- Supply Air Section Forwa
Page 63 and 64:
19 27 Detail A 6 26 14 VAV detail o
Page 65 and 66:
65 Section F- Supply Air Section Ai
Page 67 and 68:
Section F- Supply Air Section Air F
Page 69 and 70:
90 89 161 or 61 63 or 163 190 92 91
Page 71 and 72:
90 89 190 92 91 188 189 123 156 Rub
Page 73 and 74:
90 89 190 92 91 188 189 123 156 Rub
Page 75 and 76:
90 89 190 92 91 188 189 123 156 Rub
Page 77 and 78:
90 89 190 92 91 188 189 123 156 Rub
Page 79 and 80:
90 89 190 92 91 188 189 123 156 Rub
Page 81 and 82:
90 89 190 92 91 188 189 123 156 Rub
Page 83 and 84:
90 89 190 92 91 188 189 123 156 Rub
Page 85 and 86:
Section F- Supply Air Section Suppl
Page 87 and 88:
Section F- Supply Air Section Inver
Page 89 and 90:
40 50 Section F- Supply Air Section
Page 91 and 92:
40 50 Section F- Supply Air Section
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Code 15= A Model 550 (8/04 & Later)
Page 103 and 104:
Page 105 and 106:
15 20 Until 1/00 67 98 99 Section F
Page 107 and 108:
Section F- Supply Air Section Secti
Page 109 and 110:
Section G- Blow-Thru Heat Section O
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
DS3 or PB3 FB33 FB32FB36FB31FB35 M3
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
25 24 Detail Section G- Blow-Thru H
Page 135 and 136:
Page 137 and 138:
26 25 Section G- Blow-Thru Heat Sec
Page 139 and 140:
26 25 FSG Detail Section G- Blow-Th
Page 141 and 142:
234 234 205 Section G- Blow-Thru He
Page 143 and 144:
226 Section G- Blow-Thru Heat Secti
Page 145 and 146:
253 500 - 2000 MBH Furnaces UL Appr
Page 147 and 148:
500 - 650 MBH Furnaces UL (C07= EU,
Page 149 and 150:
275 283 500 - 790MBH 800,1000 MBH C
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Section H- Blow-Thru Heat Blank Acc
Page 159 and 160:
Primary Codes that pertain: 39 Addi
Page 161 and 162:
Section K- Discharge Plenum Section
Page 163 and 164:
Section L- Out-of-Airstream Blank A
Page 165 and 166:
Keypad Section N- Main Control Box
Page 167 and 168:
Section N- Main Control Box Control
Page 169 and 170: Section N- Main Control Box Control
Page 173 and 174: Section N- Main Control Box Power P
Page 175 and 176: Power Panel- Power Blocks, Disconne
Page 195 and 196: Section N- Main Control Box MicroTe
Page 211 and 212: Short Circuit 3C Alarm Aux. Contact
Page 217 and 218: See Control Panel Section N- Main C
Page 219: Section N- Main Control Box Power P
Page 223 and 224: Front Mtd. Contact 3E Link 3B MMP10
Page 229: 2 Control Box McQuay Supplied Line
show all

RPL: RAH, Size 077, Vintage C, RoofPak Draw Thru / Blow Thru Air ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?