RPL: RAH, Size 077, Vintage C, RoofPak Draw Thru / Blow Thru Air ...

More documents

Recommendations

Info

Section N- Main Control Box MicroTech II or No Controls Control Panel— 3/05 and later* Units with No Controller (Code 12= YM or YC) Diagram * Code 08= D. Between 10/04 & 3/05 either this control panel or the original MicroTech II control panel (Code 08= P) could be installed. Check the GO or visually inspect the unit to verify which panel is installed. If built between 10/06 and 12/06 contact Daikin McQuay Parts. Switches Detail HS1 S1 S4 S7 T2 R 20 R R 2425 R R R 28 30 45 TB1 See Power Panel RoofPak Singlezone; RAH 077 “C” Rev. Q 07/12 RPL 700008300 / Page 196 T4 R 61 R 66 R 63 R 67 R 68 R 69 R 70 TD9 TD 19 DHL
Section N- Main Control Box MicroTech II or No Controls Control Panel— 3/05 and later* Components * Code 08= D. Between 10/04 & 3/05 either this control panel or the original MicroTech II control panel (Code 08= P) could be installed. Check the GO or visually inspect the unit to verify which panel is installed. If built between 10/06 and 12/06 contact Daikin McQuay Parts. Sch. Part Part Sym. Description Number Qty. Main Controller MCB Main Controller- Must be programmed (unit GO# required) 060006101 1 Com Card- Bacnet (C12= B*) 060006202 1 Com Card- Bacnet with Ethernet (C12= E*) 060006201 1 Com Card- LonMark Space Control (C12= LS) 060006203 1 Com Card- LonMark Discharge Control (C12= LD) 060006204 1 Standoff- Com Card 048166706 4 Kit- Connector Repair 300036605 1 Power Supply- 5 VDC 111049610 Serial Port Ribbon Cable 111047201 1 Battery 049754501 1 Grounding Bar 349936901 1 Keypad Keypad Keypad 060006301 1 Remote Keypad Interface Board 112021601 1 Cable- Interface 349938501 1 Condenser Board GCB1 Expansion Board- Condenser 112026101 1 Standoff- Expansion Board 048166705 7 Com. Card- Bacnet 060006202 1 Standoff- Com. Card 048166707 4 RES Resistor- GCB1 060003901 1 Electric Heat Board EHB1 Expansion Board- Electric Heat 112026101 1 Standoff- Expansion Board 048166705 7 Com. Card- Bacnet 060006202 1 Standoff- Com. Card 048166707 4 Switches- Control HS1 Switch- Electric Heat Shutdown (C04=E) 001355000 1 S1 Switch- System On/Off Gas Heat Units C04= A 018446400 1 Elec.,Steam,HW or No Heat C04=E,S,W,Y 001355000 1 S4 Switch- Inverter Bypass On/Off 028798400 1 S7 Switch- Local On/Auto/Off to Controller 349931201 1 Serial Cables Serial Serial Cable 111047201 1 Duct Hi Limit and Duct Static Pressure Sensors DHL Duct Hi Limit Switch 065493801 1 SPS1 Pressure Transducer- Duct Sensor Code 13= 1, 2, 3 049545007 1 SPS2 Pressure Transducer- Duct Sensor Code 13= 2 049545007 1 Pressure Transducer- Space Sensor Code 13= 3, 4 049545006 1 Time Delays TD9 Time Delay- SA Fan PW (Special) 1 Sec. 028210101 1 TD19 Time Delay- RA Fan PW (Special) 1 Sec. 028210101 1 RoofPak Singlezone; RAH 077 “C” Rev. Q 07/12 RPL 700008300 / Page 197
Page 1 and 2:
Replacement Parts List No. 70000830
Page 3 and 4:
Contents Continued Section F- Suppl
Page 5 and 6:
Parts List Revision History Rev. Da
Page 7 and 8:
R = RoofPak Unit Configuration AH =
Page 9 and 10:
General Options Unit Model Codes th
Page 11 and 12:
Code 16= Smoke Detectors 1= Supply
Page 13 and 14:
Code 31= Supply Air Fan 33A()= 33
Page 15 and 16:
Electrical Legend Schematic Sym. De
Page 17 and 18:
Electrical Legend Continued Schemat
Page 19 and 20:
Section A- Outdoor/Return Air Secti
Page 21 and 22:
29 23 26 Section A- Outdoor/Return
Page 23 and 24:
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
Page 31 and 32:
6 6A Inverter- 2 Fan Units (Code 24
Page 33 and 34:
165 128 152 167 136 Mixing Box Asse
Page 35 and 36:
115 114 110 128 116 Section A- Outd
Page 37 and 38:
90 93 89 92 188 189 190 123 156 155
Page 39 and 40:
11 Section A- Outdoor/Return Air Se
Page 41 and 42:
Bottom Return Shown C19= BY or BE E
Page 43 and 44:
Section B- Draw-Thru Filter/Blank S
Page 45 and 46:
Section B- Draw-Thru Filter/Blank S
Page 47 and 48:
Section D- Draw-Thru Combination Co
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
21 Section D- Draw-Thru Combination
Page 59 and 60:
Section E- Draw-Thru Heat Section H
Page 61 and 62:
Section F- Supply Air Section Forwa
Page 63 and 64:
19 27 Detail A 6 26 14 VAV detail o
Page 65 and 66:
65 Section F- Supply Air Section Ai
Page 67 and 68:
Section F- Supply Air Section Air F
Page 69 and 70:
90 89 161 or 61 63 or 163 190 92 91
Page 71 and 72:
90 89 190 92 91 188 189 123 156 Rub
Page 73 and 74:
90 89 190 92 91 188 189 123 156 Rub
Page 75 and 76:
90 89 190 92 91 188 189 123 156 Rub
Page 77 and 78:
90 89 190 92 91 188 189 123 156 Rub
Page 79 and 80:
90 89 190 92 91 188 189 123 156 Rub
Page 81 and 82:
90 89 190 92 91 188 189 123 156 Rub
Page 83 and 84:
90 89 190 92 91 188 189 123 156 Rub
Page 85 and 86:
Section F- Supply Air Section Suppl
Page 87 and 88:
Section F- Supply Air Section Inver
Page 89 and 90:
40 50 Section F- Supply Air Section
Page 91 and 92:
40 50 Section F- Supply Air Section
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Code 15= A Model 550 (8/04 & Later)
Page 103 and 104:
Page 105 and 106:
15 20 Until 1/00 67 98 99 Section F
Page 107 and 108:
Section F- Supply Air Section Secti
Page 109 and 110:
Section G- Blow-Thru Heat Section O
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
DS3 or PB3 FB33 FB32FB36FB31FB35 M3
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
25 24 Detail Section G- Blow-Thru H
Page 135 and 136:
Page 137 and 138:
26 25 Section G- Blow-Thru Heat Sec
Page 139 and 140:
26 25 FSG Detail Section G- Blow-Th
Page 141 and 142:
234 234 205 Section G- Blow-Thru He
Page 143 and 144:
226 Section G- Blow-Thru Heat Secti
Page 145 and 146: 253 500 - 2000 MBH Furnaces UL Appr
Page 147 and 148: 500 - 650 MBH Furnaces UL (C07= EU,
Page 149 and 150: 275 283 500 - 790MBH 800,1000 MBH C
Page 151 and 152: Section G- Blow-Thru Heat Section O
Page 157 and 158: Section H- Blow-Thru Heat Blank Acc
Page 159 and 160: Primary Codes that pertain: 39 Addi
Page 161 and 162: Section K- Discharge Plenum Section
Page 163 and 164: Section L- Out-of-Airstream Blank A
Page 165 and 166: Keypad Section N- Main Control Box
Page 167 and 168: Section N- Main Control Box Control
Page 173 and 174: Section N- Main Control Box Power P
Page 175 and 176: Power Panel- Power Blocks, Disconne
Page 195: Section N- Main Control Box MicroTe
Page 199 and 200: Section N- Main Control Box MicroTe
Page 211 and 212: Short Circuit 3C Alarm Aux. Contact
Page 217 and 218: See Control Panel Section N- Main C
Page 223 and 224: Front Mtd. Contact 3E Link 3B MMP10
Page 229: 2 Control Box McQuay Supplied Line
show all

RPL: RAH, Size 077, Vintage C, RoofPak Draw Thru / Blow Thru Air ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?