U.S. DEPARTMENT OF TRANSPORTATION - SaferCar.gov

More documents

Recommendations

Info

SINCAP MDB - A1 APPENDIX A ES-2re Calibration Procedure In addition to the following document, 49 CFR 572 Subpart U may be referenced.
U.S. DEPARTMENT OF TRANSPORTATION TP-P572-U-00 Feb 2011 NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION LABORATORY TEST PROCEDURE FOR Part 572, SUBPART U PERFORMANCE CALIBRATION REQUIREMENTS ENFORCEMENT Office of Vehicle Safety Compliance Mail Code: NVS-220 1200 New Jersey Ave. SE Washington, DC 20590
Page 1 and 2:
Rev. 09/19/2012 SEPTEMBER 2012 U.S.
Page 3 and 4:
SINCAP MDB LABORATORY TEST PROCEDUR
Page 5 and 6:
SINCAP MDB LABORATORY TEST PROCEDUR
Page 7 and 8:
SINCAP MDB - 2 1. PURPOSE AND APPLI
Page 9 and 10:
SINCAP MDB - 4 2.3. TEST VEHICLE AS
Page 11 and 12:
SINCAP MDB - 6 schedule in cases of
Page 13 and 14:
SINCAP MDB - 8 (10) The position of
Page 15 and 16:
SINCAP MDB - 10 Figure 2 - Typical
Page 17 and 18:
SINCAP MDB - 12 D. A written calibr
Page 19 and 20: SINCAP MDB - 14 before the MDB cont
Page 21 and 22: SINCAP MDB - 16 shows not only curt
Page 23 and 24: SINCAP MDB - 18 (2) Measure the dis
Page 25 and 26: SINCAP MDB - 20 D. BARRIER PHOTOGRA
Page 27 and 28: SINCAP MDB - 22 NOTE: The test labo
Page 29 and 30: SINCAP MDB - 24 9.8 STILL PHOTOGRAP
Page 31 and 32: SINCAP MDB - 26 No. 050 - Post-Test
Page 33 and 34: SINCAP MDB - 28 NOTE: The numbering
Page 35 and 36: SINCAP MDB - 30 (1) NHTSA Number (s
Page 37 and 38: SINCAP MDB - 32 H. CALCULATION OF V
Page 39 and 40: SINCAP MDB - 34 NOTE: The “As Tes
Page 41 and 42: SINCAP MDB - 36 Figure 9 - Moving D
Page 43 and 44: SINCAP MDB - 38 (1) With the seat
Page 45 and 46: SINCAP MDB - 40 (6) If the seat and
Page 47 and 48: SINCAP MDB - 42 seat controls the f
Page 49 and 50: SINCAP MDB - 44 combined cable bund
Page 51 and 52: SINCAP MDB - 46 NR NB Nose to Rim -
Page 53 and 54: SINCAP MDB - 48 A B C D E F G H I J
Page 55 and 56: SINCAP MDB - 50 C. MOVING DEFORMABL
Page 57 and 58: SINCAP MDB - 52 A. MDB Centerline t
Page 59 and 60: SINCAP MDB - 54 12.9 REMOVAL OF TES
Page 61 and 62: SINCAP MDB - 56 F. TEST REPORT No t
Page 63 and 64: SINCAP MDB - 58 M. The Contractor m
Page 65 and 66: SINCAP MDB - 60 13.4 NOTIFICATION O
Page 67 and 68: SINCAP MDB - 62 E. DRAFT TEST REPOR
Page 69: SINCAP MDB - 64 H. DELIVERABLE SCHE
Page 73 and 74: List of Figures TP-P572-U-00 Figure
Page 75 and 76: TP-P572-U-00 1. PURPOSE AND APPLICA
Page 77 and 78: TP-P572-U-00 8. CALIBRATION AND TES
Page 79 and 80: TP-P572-U-00 10. PRETEST REQUIREMEN
Page 81 and 82: TP-P572-U-00 10. PRETEST REQUIREMEN
Page 83 and 84: TP-P572-U-00 14. CHECK SHEETS CHECK
Page 85 and 86: TP-P572-U-00 CHECK SHEET NO. U1 (Co
Page 87 and 88: TP-P572-U-00 CHECK SHEET NO. U2 HEA
Page 93 and 94: TP-P572-U-00 __4 __5 CHECK SHEET NO
Page 97 and 98: TP-P572-U-00 CHECK SHEET NO. U4 SHO
Page 99 and 100: TP-P572-U-00 CHECK SHEET NO. U5 RIB
Page 105 and 106: TP-P572-U-00 CHECK SHEET NO. U7 ABD
Page 113 and 114: TP-P572-U-00
Page 115 and 116: TP-P572-V-00 Feb 2011 U.S. DEPARTME
Page 117 and 118: TP-P572-V-00 List of Figures Figure
Page 119 and 120: TP-P572-V-00 List of Tables Table V
Page 121 and 122:
TP-P572-V-00 3. SECURITY….Continu
Page 123 and 124:
TP-P572-V-00 9. PHOTOGRAPHIC DOCUME
Page 125 and 126:
TP-P572-V-00 10. PRETEST REQUIREMEN
Page 127 and 128:
TP-P572-V-00 14. CHECK SHEETS CHECK
Page 129 and 130:
TP-P572-V-00 CHECK SHEET NO. V1 (Co
Page 131 and 132:
TP-P572-V-00 CHECK SHEET NO. V2 HEA
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
TP-P572-V-00 CHECK SHEET NO.V3 (Con
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
TP-P572-V-00 CHECK SHEET NO. V5 THO
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
TP-P572-V-00 PELVIS ACETABULUM IMPA
Page 183 and 184:
Page 185 and 186:
TP-P572-V-00 CHECK SHEET NO. V10 PE
Page 187 and 188:
TP-P572-V-00 CHECK SHEET NO. V10 (C
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
ATTACHMENT OF THORACIC AND ABDOMINA
Page 195 and 196:
P572-V-00
Page 197 and 198:
P572-V-00
Page 199 and 200:
SINCAP MDB - C2 ES-2re 50th Percent
Page 201 and 202:
SINCAP MDB - C4 SID-IIs 5th Percent
Page 203 and 204:
SINCAP MDB - C6 close to 20.0 degre
Page 205 and 206:
SINCAP MDB - D1 APPENDIX D ALUMINIU
Page 207 and 208:
SINCAP MDB - D3 FIGURE 1 2.3 Measur
Page 209 and 210:
SINCAP MDB - D5 2.6 Crush Strength
Page 211 and 212:
APPENDIX E. DELIVERABLE GUIDELINES
Page 213 and 214:
2 1. FINAL TEST REPORT Instructions
Page 215 and 216:
4 Block No. 1--REPORT NUMBER SINCAP
Page 217 and 218:
6 Block No. 17--KEY WORDS New Car A
Page 219 and 220:
8 Measurement Description Passenger
Page 221 and 222:
10 037 View of Disengaged Parking B
Page 223 and 224:
12 1.7 APPENDIX B - VEHICLE AND DUM
Page 225 and 226:
14 1.8 APPENDIX C - DUMMY PERFORMAN
Page 227 and 228:
16 Lower Spine Acceleration (G’s)
Page 229 and 230:
18 TABLE 4 - MDB Instrumentation MD
Page 231 and 232:
20 DATA SHEET NO. 1 (CONTINUED) GEN
Page 233 and 234:
22 DATA SHEET NO. 1 (CONTINUED) GEN
Page 235 and 236:
24 DATA SHEET NO. 2 (CONTINUED) SEA
Page 237 and 238:
26 DATA SHEET NO. 2 (CONTINUED) SEA
Page 239 and 240:
28 DATA SHEET NO. 4 DUMMY LATERAL C
Page 241 and 242:
30 DATA SHEET NO. 6 TEST VEHICLE AC
Page 243 and 244:
32 DATA SHEET NO. 8 POST-TEST OBSER
Page 245 and 246:
34 DATA SHEET NO. 9 MDB SUMMARY OF
Page 247 and 248:
36 DATA SHEET NO. 11 TEST VEHICLE E
Page 249 and 250:
38 DATA SHEET NO. 11 (CONTINUED) TE
Page 251 and 252:
40 DATA SHEET NO. 13 FMVSS NO. 301
Page 253 and 254:
42 3. FORMS Forms, like Data Sheets
Page 255 and 256:
44 1.1 Driver’s Seat 1.1A Seat Fo
Page 257 and 258:
1.2D Provide any other instructions
Page 259 and 260:
With the seat in the test seat trac
Page 261 and 262:
50 5. STEERING COLUMN AND WHEEL ADJ
Page 263 and 264:
52 9. DEACTIVATION OF SIDE AIRBAGS
Page 265 and 266:
___________________________________
Page 267:
56 Rev. 09/19/2012
Page 270 and 271:
FORM NO. 2 (CONTINUED) REPORT OF VE
Page 272 and 273:
FORM NO. 4 MONTHLY VEHICLE STATUS R
Page 274 and 275:
SINCAP MDB - F1 APPENDIX F Determin
Page 276 and 277:
SINCAP MDB - F3 (11) Again apply a
Page 278 and 279:
PROCEDURE FOR CHECKING AND RECORDIN
Page 280 and 281:
Figure 1 - Response of X Axis Accel
Page 282 and 283:
The channel outputs for the x-axis
Page 284 and 285:
Polarity Check Data Sheet For Y - A
show all

U.S. DEPARTMENT OF TRANSPORTATION - SaferCar.gov

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?