Carrier Compressors Service Guide

More documents

Recommendations

Info

LEGENDLRA - Locked Rotor AmpsMCC - Maxmium Continuous CurrentRLA - Rated Load AmpsNOTES:1. RLA (rated load amps) value shown for new high efficiency models is MCC ÷ 1.56 = RLA. Use thisrecommended (and minimum) RLA value to determine nameplate stamping. Minimum contactor sizing and wire sizing.2. Compressor operating amps at any specific conditions can only be determined from a performance curve.3. RLA values for 06D compressor protected by a calibrated circuit breaker will depend on must-trip value of circuit breaker.4. Ohm values shown for resistance are approximate and shown for reference only. Motors from different vendors and motors of different efficienciescan differ up to 15% from data shown.105OPERATING RANGESALLOWABLENOMINALVOLTAGE MAXIMUM MINIMU M187414518342180254529661460230208/230460575400 (50 Hz)200 (50 Hz)
1064.8 – 06CC (50 to 99 Cfm) 3 Phase Electrical SpecificationsDATAMOTOROMPRESSORC ADATBREAKERCIRCUITCOMPRESSORMODELVOLTMAXkWHP1NOTEEES 2NOTEEES RMOTOWINDINGRESISTANCE(Ohms)3NOTESEE.H.M ..TM ALR4NOTESEEMaximumTripMustAmpsLRA-XLLRA-PW(FirstWinding)RecommendedBreakerCircuitNo.PartRecommendedRLA06CC550F201550J201550E201460575208/230/4602.02 51322768/321429828385591702.81.80.44/0.22HH83XB414XB438XB455/XB4142723593227681458624523194906CC665F201665J201665E201460575208/230/4605.32 025038100/50173120345/173104722072.21.30.32/0.16HH83XB437XA461XB376/XB43743337350388517612433336276106CC675F201675J201675E201460575208/230/4605.32 025038100/50173120345/173104722072.21.30.32/0.16HH83XB437XA461XB378/XB43743337750388917612436536276406CC899F201899J201899E201460575208/230/4609.13 035858141/73253176506/2531521063041.30.880.22/0.11HH83XB432XA430XC406/XB432635012273581412401684645241101
Page 1 and 2:
SERVICEGUIDE06D/06E/06CCCOMPRESSORS
Page 3 and 4:
3.14 Oil Safety Switch ............
Page 5 and 6:
06E COMPRESSORS06ER 3 99 3 0 A - (R
Page 7 and 8:
1.2 — Nameplate SignificanceMODEL
Page 9 and 10:
1.3 — Compressor Serial Number Si
Page 11 and 12:
1.5 — Service Billing and CreditR
Page 13 and 14:
BEFORE START-UP1. Verify that the c
Page 15 and 16:
compressor unit configurations. Thi
Page 17 and 18:
COMPRESSOR START-UP1. After circuit
Page 19 and 20:
Fig. 1A -- Typical 06D, E Operating
Page 21 and 22:
2.3 — Troubleshooting Procedures!
Page 23 and 24:
.Troubleshooting Guide - 06D,06E an
Page 25 and 26:
.OBSERVATIONPOSSIBLECAUS EREMED Y6
Page 27 and 28:
26BSERVATIONO ECAUSOSSIBLEP YREMEDp
Page 29 and 30:
28BSERVATIONO ECAUSOSSIBLEP YREMEDl
Page 31 and 32:
30BSERVATIONO ECAUSOSSIBLEP YREMEDt
Page 33 and 34:
2.4 — Service ProceduresThe servi
Page 35 and 36:
Fig. 2 -- Disassembly of Valve Plat
Page 37 and 38:
REASSEMBLY1. If reassembling existi
Page 39 and 40:
7. Certain high compression ratio a
Page 41 and 42:
Fig. 7 -- Removing Pump End Bearing
Page 43 and 44:
MOTOR BURNOUT CLEAN-UP PROCEDUREWhe
Page 45 and 46:
2.5 -- Connection Points, - 06D, 06
Page 47 and 48:
NOTE: Bolt sizes and thread pitch:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56: 2.6 -- Cross-Sectional View, 06D Se
Page 57 and 58: 2.8 -- Exploded View - 6-Cylinder 0
Page 59 and 60: 2.9 -- Exploded View - 6-Cylinder 0
Page 61 and 62: 2.10 - Torque Guide - All 06D and 1
Page 63 and 64: -------†††††††††
Page 65 and 66: ------3.2 - 06E Series Compressors
Page 67 and 68: 3.3 - 06CC Series Compressors - Phy
Page 69 and 70: 3.4 — 06D, E High Efficiency (H.E
Page 71 and 72: FOR HCFC BLENDS:Carlyle’s enginee
Page 73 and 74: 3.7 — Refrigerants and Oils for 0
Page 75 and 76: 3.12 — High Flow Oil Pump (Bearin
Page 77 and 78: Use of an oil safety switch is reco
Page 79 and 80: elow 0°F (-18°C) and all R404A/50
Page 81 and 82: LOADED OPERATIONUNLOADED OPERATIONF
Page 83 and 84: 3.20 — Compressor Mounting DataMo
Page 85 and 86: 3.27 — Gaskets - Cylinder Head an
Page 87 and 88: 3.29 — Valve Plate Packages, Serv
Page 89 and 90: 3.31 — Electrical AccessoriesBOX
Page 91 and 92: 90* Indicates Vacuum.NOTE: 1 BAR =
Page 93 and 94: .4.0 — ELECTRICAL DATA4.1 — 06D
Page 95 and 96: 944.2 — 06DM, DA 3 Phase Electric
Page 97 and 98: 4.3 — 06DR, DM Single Phase Elect
Page 99 and 100: SEENOTE4RecommendedRLA64.323.933.96
Page 101 and 102: SEENOTE4RecommendedRLA64.323.933.96
Page 103 and 104: SEENOTE4RecommendedRLA74.327.13574.
Page 105: 1044.7 — 06CC (16 to 37 Cfm) 3 Ph
Page 109 and 110: 4.9 — 06D Compressor Overloads*(s
Page 111 and 112: 06E COMPRESSORS(ACROSS-THE-LINE [XL
Page 113 and 114: 4.11 — Voltage and Current Unbala
Page 115 and 116: 06D, 06E Compressor Service Workshe
Page 117 and 118: Service Guide IndexPage06CC (16 to
Page 119 and 120: Current Unbalance .................
Page 121 and 122: Parallel Compressor Applications, O
Page 123 and 124: Troubleshooting — Low On Capacity
show all

Carrier Compressors Service Guide

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?