Carrier Compressors Service Guide

More documents

Recommendations

Info

4.10 — Electrical Hook-UpConsult wiring diagram located inside compressorterminal box cover and reference diagrams shown belowfor wiring hook-up connection locations. See 3.31, pg 88for Terminal Box Packages.L1T1L2T2Compressor Terminal Box1R/14OL-2Start37S/32RS06DSinglePhaseN/Cinternal ‘statinside motor 8C/241OL-1Common 322RunCapacitor5StartRelayStartCapacitor106D Single Phase WiringControl WiringPower WiringSINGLE PHASE INTERNAL THERMOSTAT06DThreePhase* 3rd overload required on some compressors. See 4.9 06D compressor overloads.Three Phase Across-the-Line StartInternal Thermostat109
06E COMPRESSORS(ACROSS-THE-LINE [XL] START)See Fig.17, page 111, for detailed view ofterminal post arrangement.110
Page 1 and 2:
SERVICEGUIDE06D/06E/06CCCOMPRESSORS
Page 3 and 4:
3.14 Oil Safety Switch ............
Page 5 and 6:
06E COMPRESSORS06ER 3 99 3 0 A - (R
Page 7 and 8:
1.2 — Nameplate SignificanceMODEL
Page 9 and 10:
1.3 — Compressor Serial Number Si
Page 11 and 12:
1.5 — Service Billing and CreditR
Page 13 and 14:
BEFORE START-UP1. Verify that the c
Page 15 and 16:
compressor unit configurations. Thi
Page 17 and 18:
COMPRESSOR START-UP1. After circuit
Page 19 and 20:
Fig. 1A -- Typical 06D, E Operating
Page 21 and 22:
2.3 — Troubleshooting Procedures!
Page 23 and 24:
.Troubleshooting Guide - 06D,06E an
Page 25 and 26:
.OBSERVATIONPOSSIBLECAUS EREMED Y6
Page 27 and 28:
26BSERVATIONO ECAUSOSSIBLEP YREMEDp
Page 29 and 30:
28BSERVATIONO ECAUSOSSIBLEP YREMEDl
Page 31 and 32:
30BSERVATIONO ECAUSOSSIBLEP YREMEDt
Page 33 and 34:
2.4 — Service ProceduresThe servi
Page 35 and 36:
Fig. 2 -- Disassembly of Valve Plat
Page 37 and 38:
REASSEMBLY1. If reassembling existi
Page 39 and 40:
7. Certain high compression ratio a
Page 41 and 42:
Fig. 7 -- Removing Pump End Bearing
Page 43 and 44:
MOTOR BURNOUT CLEAN-UP PROCEDUREWhe
Page 45 and 46:
2.5 -- Connection Points, - 06D, 06
Page 47 and 48:
NOTE: Bolt sizes and thread pitch:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
2.6 -- Cross-Sectional View, 06D Se
Page 57 and 58:
2.8 -- Exploded View - 6-Cylinder 0
Page 59 and 60: 2.9 -- Exploded View - 6-Cylinder 0
Page 61 and 62: 2.10 - Torque Guide - All 06D and 1
Page 63 and 64: -------†††††††††
Page 65 and 66: ------3.2 - 06E Series Compressors
Page 67 and 68: 3.3 - 06CC Series Compressors - Phy
Page 69 and 70: 3.4 — 06D, E High Efficiency (H.E
Page 71 and 72: FOR HCFC BLENDS:Carlyle’s enginee
Page 73 and 74: 3.7 — Refrigerants and Oils for 0
Page 75 and 76: 3.12 — High Flow Oil Pump (Bearin
Page 77 and 78: Use of an oil safety switch is reco
Page 79 and 80: elow 0°F (-18°C) and all R404A/50
Page 81 and 82: LOADED OPERATIONUNLOADED OPERATIONF
Page 83 and 84: 3.20 — Compressor Mounting DataMo
Page 85 and 86: 3.27 — Gaskets - Cylinder Head an
Page 87 and 88: 3.29 — Valve Plate Packages, Serv
Page 89 and 90: 3.31 — Electrical AccessoriesBOX
Page 91 and 92: 90* Indicates Vacuum.NOTE: 1 BAR =
Page 93 and 94: .4.0 — ELECTRICAL DATA4.1 — 06D
Page 95 and 96: 944.2 — 06DM, DA 3 Phase Electric
Page 97 and 98: 4.3 — 06DR, DM Single Phase Elect
Page 99 and 100: SEENOTE4RecommendedRLA64.323.933.96
Page 101 and 102: SEENOTE4RecommendedRLA64.323.933.96
Page 103 and 104: SEENOTE4RecommendedRLA74.327.13574.
Page 105 and 106: 1044.7 — 06CC (16 to 37 Cfm) 3 Ph
Page 107 and 108: 1064.8 - 06CC (50 to 99 Cfm) 3 Phas
Page 109: 4.9 — 06D Compressor Overloads*(s
Page 113 and 114: 4.11 — Voltage and Current Unbala
Page 115 and 116: 06D, 06E Compressor Service Workshe
Page 117 and 118: Service Guide IndexPage06CC (16 to
Page 119 and 120: Current Unbalance .................
Page 121 and 122: Parallel Compressor Applications, O
Page 123 and 124: Troubleshooting — Low On Capacity
show all

Carrier Compressors Service Guide

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?