Carrier Compressors Service Guide

More documents

Recommendations

Info

06DR7180DA3350*(8347A19-4)HN69GZ307(8347A23-40)HN69GZ03706DM3130CA3350*06DR3160CA3350*(8348A19-4)HN69GZ307(8347A23-40)HN69GZ037COMPRESSORVARIABLECOMPRESSORMODEL06DM8080CA3350*06DR1090CA3350* 06DR0130CA3350 *(T.I. No.)CommonOverload(8347A23-63)HN69GZ024(8347A23-31)HN69GZ025(8347A23-63)HN69GZ024(T.I.)StartOverload(8347A23-53)HN69GZ014(8347A23-42)HN69GZ032(8347A23-53)HN69GZ014*The last two digits of the compressor model number may vary. See page 3.ALLOWABLEOPERATING RANGENOMINALVOLTAGEMAXIMUMMINIMU M208/230-1-60254V187 V97
SEENOTE4RecommendedRLA64.323.933.964.3/33.974.327.13574.327.13574.3/3574.327.13574.3/35116.441.454.3116.4/54.34.4 — 06ER, EY 3 Phase Electrical SpecificationsC OMPRESSOR MOTOR DATACIRCUIT BREAKER DAT ACOMPRESSORMODEL*06ER(1/4)50000(1/4)50100(1/4)50600(1/4)5030006ER(1/4)66000(1/4)66100(1/4)66600(SeeNote5)06ER(1/4)65000(1/4)65100(1/4)65600(1/4)6530006ER(1/4)75000(1/4)75100(1/4)75600(1/4)7530006ER(0/3)99000(0/3)99100(0/3)99600(0/3)99300VOLT208/230575460208/230/460208/230575460208/230575460208/230/460208/230575460208/230/460208/230575460208/230/460MAXkWHP22.01 525.32 025.32 025.32 039.13 0SEENOTE 1 S EE NOTE 2RMaximumMust TripAmps90384690/4610845541084554108/541084554108/541686584168/84MaximumRLA72313672/3687364487364487/4487364487/441355268135/68LRA-XL28398142283/142345120173345120173345/173345120173345/173506176253506/253LRA-PW(firstwinding)1705985170/852077210420772104207/10420772104207/104304106152304/152MOTOWINDINGRESISTANCE(Ohms)0.442.81.80.44/0.220.322.21.30.322.21.30.32/0.160.322.21.30.32/0.160.221.30.880.22/0.11SEENOTE3RecommendedCircuit BreakerPart No.HH83XB626XA460XA463XB626/XA463HH83XB625XA461XA424HH83XB625XA461XA424XB625/XA424HH83XB625XA461XA424XB625/XA424HH83XC539XA430XA478XC539/XA478M .H. M.T. LR A78294078/4091334291334291/4291334291/421425065142/679033.54690/4610438491043849104/491043849104/491635876163/7625097150250/150350124175350124175350/175350124175350/175507168274507/274* The last two digits of the compressor model number may vary. See page 4. The fifth digit in ( ) of the compressor model numberrepresents models with or without oil. 0, 1, 2 signifies older models with oil; 3, 4, 5 signifies newer models without oil. See page 4.98
Page 1 and 2:
SERVICEGUIDE06D/06E/06CCCOMPRESSORS
Page 3 and 4:
3.14 Oil Safety Switch ............
Page 5 and 6:
06E COMPRESSORS06ER 3 99 3 0 A - (R
Page 7 and 8:
1.2 — Nameplate SignificanceMODEL
Page 9 and 10:
1.3 — Compressor Serial Number Si
Page 11 and 12:
1.5 — Service Billing and CreditR
Page 13 and 14:
BEFORE START-UP1. Verify that the c
Page 15 and 16:
compressor unit configurations. Thi
Page 17 and 18:
COMPRESSOR START-UP1. After circuit
Page 19 and 20:
Fig. 1A -- Typical 06D, E Operating
Page 21 and 22:
2.3 — Troubleshooting Procedures!
Page 23 and 24:
.Troubleshooting Guide - 06D,06E an
Page 25 and 26:
.OBSERVATIONPOSSIBLECAUS EREMED Y6
Page 27 and 28:
26BSERVATIONO ECAUSOSSIBLEP YREMEDp
Page 29 and 30:
28BSERVATIONO ECAUSOSSIBLEP YREMEDl
Page 31 and 32:
30BSERVATIONO ECAUSOSSIBLEP YREMEDt
Page 33 and 34:
2.4 — Service ProceduresThe servi
Page 35 and 36:
Fig. 2 -- Disassembly of Valve Plat
Page 37 and 38:
REASSEMBLY1. If reassembling existi
Page 39 and 40:
7. Certain high compression ratio a
Page 41 and 42:
Fig. 7 -- Removing Pump End Bearing
Page 43 and 44:
MOTOR BURNOUT CLEAN-UP PROCEDUREWhe
Page 45 and 46:
2.5 -- Connection Points, - 06D, 06
Page 47 and 48: NOTE: Bolt sizes and thread pitch:
Page 55 and 56: 2.6 -- Cross-Sectional View, 06D Se
Page 57 and 58: 2.8 -- Exploded View - 6-Cylinder 0
Page 59 and 60: 2.9 -- Exploded View - 6-Cylinder 0
Page 61 and 62: 2.10 - Torque Guide - All 06D and 1
Page 63 and 64: -------†††††††††
Page 65 and 66: ------3.2 - 06E Series Compressors
Page 67 and 68: 3.3 - 06CC Series Compressors - Phy
Page 69 and 70: 3.4 — 06D, E High Efficiency (H.E
Page 71 and 72: FOR HCFC BLENDS:Carlyle’s enginee
Page 73 and 74: 3.7 — Refrigerants and Oils for 0
Page 75 and 76: 3.12 — High Flow Oil Pump (Bearin
Page 77 and 78: Use of an oil safety switch is reco
Page 79 and 80: elow 0°F (-18°C) and all R404A/50
Page 81 and 82: LOADED OPERATIONUNLOADED OPERATIONF
Page 83 and 84: 3.20 — Compressor Mounting DataMo
Page 85 and 86: 3.27 — Gaskets - Cylinder Head an
Page 87 and 88: 3.29 — Valve Plate Packages, Serv
Page 89 and 90: 3.31 — Electrical AccessoriesBOX
Page 91 and 92: 90* Indicates Vacuum.NOTE: 1 BAR =
Page 93 and 94: .4.0 — ELECTRICAL DATA4.1 — 06D
Page 95 and 96: 944.2 — 06DM, DA 3 Phase Electric
Page 97: 4.3 — 06DR, DM Single Phase Elect
Page 101 and 102: SEENOTE4RecommendedRLA64.323.933.96
Page 103 and 104: SEENOTE4RecommendedRLA74.327.13574.
Page 105 and 106: 1044.7 — 06CC (16 to 37 Cfm) 3 Ph
Page 107 and 108: 1064.8 - 06CC (50 to 99 Cfm) 3 Phas
Page 109 and 110: 4.9 — 06D Compressor Overloads*(s
Page 111 and 112: 06E COMPRESSORS(ACROSS-THE-LINE [XL
Page 113 and 114: 4.11 — Voltage and Current Unbala
Page 115 and 116: 06D, 06E Compressor Service Workshe
Page 117 and 118: Service Guide IndexPage06CC (16 to
Page 119 and 120: Current Unbalance .................
Page 121 and 122: Parallel Compressor Applications, O
Page 123 and 124: Troubleshooting — Low On Capacity
show all

Carrier Compressors Service Guide

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?