Owner's Manual - Polaris

More documents

Recommendations

Info

SAFETYSafety Labels and Locations“No Passenger”WarningTirePressure/LoadWarning“No Passenger” WarningWARNINGNEVER ride as a passenger.Passengers can cause a loss of control, resulting in SEVERE INJURY orDEATH.7175378Tire Pressure/Load WarningWARNINGImproper tire pressure or overloading can cause loss of control.Loss of control can result in severe injury or death.• Cold tire pressure:Front: 7.0 psi (48.3 kPa)Rear: 5.0 psi (34.5 kPa)• Maximum weight capacity: 575 lbs. (261 kg)• Lug nut torque values:Steel rims 45 ft-lbs. (61 Nm)Aluminum rims 75 ft-lbs. (102 Nm)717544022
Safety Labels and LocationsSAFETYRackWarningHHHRackWarningHClutch CoverWarning(under seat)Hitch CapacityLabelClutch Cover WarningWARNING• Moving parts hazard under belt-clutch guard. To prevent serious injury, do notoperate vehicle with guard removed.• Do not modify engine or clutch. Doing so can cause part failure, possibleimbalance, and excessive engine RPM, which can result in serious injury ordeath.7175488Rack Warning, Front and RearWARNING• DO NOT TOW FROM RACK OR BUMPER. Vehicle damage or tipover mayresult causing severe injury or death. Tow only from tow hooks or hitch.• Max. Rack Loads: Front 120 lbs. (54 kg) Rear 240 lbs. (109 kg)7175448Hitch Capacity LabelTRAILER MAX WEIGHT:1500 LBS. (682 KG) ON LEVEL GROUND850 LBS. (386 KG) UP TO 15° GRADEHITCH MAX. VERTICAL WEIGHT: 150 LBS. (68 KG)717050923
Page 1: PMS 419Sportsman 550Sportsman 550 E
Page 6 and 7: POLARIS, THE WAY OUT and SPORTSMAN
Page 8 and 9: INTRODUCTIONThe following signal wo
Page 10 and 11: INTRODUCTIONVehicle Identification
Page 12 and 13: SAFETYSafe Riding GearAlways wear a
Page 14 and 15: SAFETYSafety WarningsWARNINGFailure
Page 16 and 17: SAFETYSafety WarningsCarrying a Pas
Page 18 and 19: SAFETYSafety WarningsDescending Hil
Page 20 and 21: SAFETYSafety WarningsOperating in U
Page 24 and 25: SAFETYSafety Labels and LocationsWa
Page 28 and 29: 2x4FEATURES AND CONTROLSSwitchesHea
Page 30 and 31: FEATURES AND CONTROLSThrottle Lever
Page 32 and 33: FEATURES AND CONTROLSMaster Cylinde
Page 34 and 35: FEATURES AND CONTROLSAuxiliary Foot
Page 36 and 37: 2x4FEATURES AND CONTROLSAll Wheel D
Page 38 and 39: FEATURES AND CONTROLSInstrument Clu
Page 56 and 57: FEATURES AND CONTROLSFront Rack/Com
Page 58 and 59: OPERATIONPre-Ride ChecklistFailure
Page 60 and 61: OPERATIONKnow Your Riding Area/Trea
Page 62 and 63: OPERATIONDriving Procedures1. Wear
Page 64 and 65: OPERATIONDriving on Slippery Surfac
Page 66 and 67: OPERATIONDriving on a Sidehill (Sid
Page 68 and 69: OPERATIONTurning Around on a Hill (
Page 70 and 71: OPERATIONDriving Over ObstaclesFoll
Page 72 and 73: OPERATIONHauling CargoWARNINGOverlo
Page 74 and 75: OPERATIONParking on an InclineAvoid
Page 76 and 77:
MAINTENANCEPeriodic Maintenance Cha
Page 78 and 79:
MAINTENANCEPeriodic Maintenance Cha
Page 80 and 81:
MAINTENANCELubrication GuideCheck a
Page 82 and 83:
MAINTENANCEEngine OilOil and Filter
Page 84 and 85:
MAINTENANCETransmission OilPOLARIS
Page 86 and 87:
MAINTENANCEActive Descent Control (
Page 88 and 89:
MAINTENANCERear Gearcase OilSee the
Page 90 and 91:
MAINTENANCEPower Steering UnitIf yo
Page 92 and 93:
MAINTENANCECooling SystemRadiator C
Page 94 and 95:
MAINTENANCEToe AlignmentUse the fol
Page 96 and 97:
MAINTENANCETiresWARNINGOperating yo
Page 98 and 99:
MAINTENANCETiresWheel Installation1
Page 100 and 101:
MAINTENANCEFuse ReplacementIf the e
Page 102 and 103:
MAINTENANCELightsHigh Beam Adjustme
Page 104 and 105:
MAINTENANCELightsHeadlight Housing
Page 106 and 107:
MAINTENANCESpark PlugsSpark Plug Re
Page 108 and 109:
MAINTENANCEVehicle ImmersionIf your
Page 110 and 111:
MAINTENANCEPVT SystemWARNINGFailure
Page 112 and 113:
MAINTENANCEPVT SystemWhen To Use Lo
Page 114 and 115:
MAINTENANCEThrottle Body/Idle RPMId
Page 116 and 117:
MAINTENANCEBatteryWARNINGImproperly
Page 118 and 119:
MAINTENANCEBatteryBattery ChargingT
Page 120 and 121:
MAINTENANCECleaning and StorageWash
Page 122 and 123:
MAINTENANCECleaning and StorageStor
Page 124 and 125:
MAINTENANCETransporting the ATV1. S
Page 126 and 127:
TROUBLESHOOTINGEngine Doesn't Turn
Page 128 and 129:
TROUBLESHOOTINGEngine Stops or Lose
Page 130 and 131:
SPECIFICATIONSMaximum Weight Capaci
Page 132 and 133:
SPECIFICATIONSMaximum Weight Capaci
Page 134 and 135:
DECLARATION OF CONFORMITYPolaris In
Page 136 and 137:
WARRANTYWARRANTY COVERAGE AND EXCLU
Page 138 and 139:
WARRANTYHOW TO OBTAIN WARRANTY SERV
Page 140 and 141:
WARRANTYExported VehiclesHow to Get
Page 142 and 143:
WARRANTYU.S.A. EPA Emissions Limite
Page 144 and 145:
MAINTENANCE LOGDATEMILES (KM)OR HOU
Page 146 and 147:
INDEX0-94X4 Switch . . . . . . . .
Page 148:
INDEXPParking Brake . . . . . . . .
show all

Owner's Manual - Polaris

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?