Owner's Manual - Polaris

More documents

Recommendations

Info

OPERATIONKnow Your Riding Area/Tread LightlyFamiliarize yourself with all laws and regulations concerning the operationof this off-road vehicle in your area. Respect the environment inwhich you ride. Find out where the designated riding areas are by contactingyour POLARIS dealer, a local riding club or local officials.Help keep our trails open for recreational vehicle use. As an off-roadenthusiast, you represent the sport and can set a good example (or a poorexample) for others to follow. Tread lightly. Operate with respect for theterrain, avoid littering, and always stay on the designated trails.Trail EtiquetteAlways practice good etiquette when riding. Allow a safe distancebetween your vehicle and other vehicles operating in the same area.Communicate to oncoming operators by signaling the number of vehiclesin your group. When stopping, move your vehicle to the edge of thetrail as far as possible to allow others to pass safely.56
OPERATIONStarting the Engine1. Position the vehicle on a level surface outdoors or in a well-ventilatedarea.2. Place the transmission in PARK.3. Lock the parking brake.Tip: The starter interlock will prevent the engine from starting if the transmissionis in gear and the brake is not engaged.4. Sit on the vehicle and move the engine stop switch to RUN.5. Do not press the throttle while starting the engine.6. Turn the ignition key past the ON position to engage the starter.Activate the starter for a maximum of five seconds, releasing thekey when the engine starts.7. If the engine does not start, return the key to the OFF position andwait five seconds before attempting to start again. Activate thestarter for another five seconds if necessary. Repeat this procedureuntil the engine starts.NOTICE: Operating the vehicle immediately after starting could cause enginedamage. Allow the engine to warm up for several minutes beforeoperating the vehicle.Cold Weather OperationIf the ATV is used year-round, check the oil level frequently. A rising oillevel could indicate the accumulation of contaminates such as water orexcess fuel in the bottom of the crankcase. Water in the bottom of thecrankcase can lead to engine damage and must be drained. Water accumulationincreases as outside temperature decreases.57
Page 1:
PMS 419Sportsman 550Sportsman 550 E
Page 6 and 7:
POLARIS, THE WAY OUT and SPORTSMAN
Page 8 and 9:
INTRODUCTIONThe following signal wo
Page 10 and 11: INTRODUCTIONVehicle Identification
Page 12 and 13: SAFETYSafe Riding GearAlways wear a
Page 14 and 15: SAFETYSafety WarningsWARNINGFailure
Page 16 and 17: SAFETYSafety WarningsCarrying a Pas
Page 18 and 19: SAFETYSafety WarningsDescending Hil
Page 20 and 21: SAFETYSafety WarningsOperating in U
Page 24 and 25: SAFETYSafety Labels and LocationsWa
Page 26 and 27: SAFETYSafety Labels and Locations
Page 28 and 29: 2x4FEATURES AND CONTROLSSwitchesHea
Page 30 and 31: FEATURES AND CONTROLSThrottle Lever
Page 32 and 33: FEATURES AND CONTROLSMaster Cylinde
Page 34 and 35: FEATURES AND CONTROLSAuxiliary Foot
Page 36 and 37: 2x4FEATURES AND CONTROLSAll Wheel D
Page 38 and 39: FEATURES AND CONTROLSInstrument Clu
Page 56 and 57: FEATURES AND CONTROLSFront Rack/Com
Page 58 and 59: OPERATIONPre-Ride ChecklistFailure
Page 62 and 63: OPERATIONDriving Procedures1. Wear
Page 64 and 65: OPERATIONDriving on Slippery Surfac
Page 66 and 67: OPERATIONDriving on a Sidehill (Sid
Page 68 and 69: OPERATIONTurning Around on a Hill (
Page 70 and 71: OPERATIONDriving Over ObstaclesFoll
Page 72 and 73: OPERATIONHauling CargoWARNINGOverlo
Page 74 and 75: OPERATIONParking on an InclineAvoid
Page 76 and 77: MAINTENANCEPeriodic Maintenance Cha
Page 78 and 79: MAINTENANCEPeriodic Maintenance Cha
Page 80 and 81: MAINTENANCELubrication GuideCheck a
Page 82 and 83: MAINTENANCEEngine OilOil and Filter
Page 84 and 85: MAINTENANCETransmission OilPOLARIS
Page 86 and 87: MAINTENANCEActive Descent Control (
Page 88 and 89: MAINTENANCERear Gearcase OilSee the
Page 90 and 91: MAINTENANCEPower Steering UnitIf yo
Page 92 and 93: MAINTENANCECooling SystemRadiator C
Page 94 and 95: MAINTENANCEToe AlignmentUse the fol
Page 96 and 97: MAINTENANCETiresWARNINGOperating yo
Page 98 and 99: MAINTENANCETiresWheel Installation1
Page 100 and 101: MAINTENANCEFuse ReplacementIf the e
Page 102 and 103: MAINTENANCELightsHigh Beam Adjustme
Page 104 and 105: MAINTENANCELightsHeadlight Housing
Page 106 and 107: MAINTENANCESpark PlugsSpark Plug Re
Page 108 and 109: MAINTENANCEVehicle ImmersionIf your
Page 110 and 111:
MAINTENANCEPVT SystemWARNINGFailure
Page 112 and 113:
MAINTENANCEPVT SystemWhen To Use Lo
Page 114 and 115:
MAINTENANCEThrottle Body/Idle RPMId
Page 116 and 117:
MAINTENANCEBatteryWARNINGImproperly
Page 118 and 119:
MAINTENANCEBatteryBattery ChargingT
Page 120 and 121:
MAINTENANCECleaning and StorageWash
Page 122 and 123:
MAINTENANCECleaning and StorageStor
Page 124 and 125:
MAINTENANCETransporting the ATV1. S
Page 126 and 127:
TROUBLESHOOTINGEngine Doesn't Turn
Page 128 and 129:
TROUBLESHOOTINGEngine Stops or Lose
Page 130 and 131:
SPECIFICATIONSMaximum Weight Capaci
Page 132 and 133:
SPECIFICATIONSMaximum Weight Capaci
Page 134 and 135:
DECLARATION OF CONFORMITYPolaris In
Page 136 and 137:
WARRANTYWARRANTY COVERAGE AND EXCLU
Page 138 and 139:
WARRANTYHOW TO OBTAIN WARRANTY SERV
Page 140 and 141:
WARRANTYExported VehiclesHow to Get
Page 142 and 143:
WARRANTYU.S.A. EPA Emissions Limite
Page 144 and 145:
MAINTENANCE LOGDATEMILES (KM)OR HOU
Page 146 and 147:
INDEX0-94X4 Switch . . . . . . . .
Page 148:
INDEXPParking Brake . . . . . . . .
show all

Owner's Manual - Polaris

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?