Owner's Manual - Polaris

More documents

Recommendations

Info

MAINTENANCEPeriodic Maintenance ChartCareful periodic maintenance will help keep your vehicle in safe, reliablecondition. Inspect, clean, lubricate, adjust and replace parts as necessary.When inspection reveals the need for replacement parts, usegenuine POLARIS parts available from your POLARIS dealer. Recordmaintenance and service in the Maintenance Log beginning on page139.Service and adjustments are important for proper vehicle operation. Ifyou're not familiar with safe service and adjustment procedures, have aqualified dealer perform these operations.Maintenance intervals in the following chart are based upon averageriding conditions and an average vehicle speed of approximately 10miles per hour. Vehicles subjected to severe use must be inspected andserviced more frequently.Severe Use Definition• Frequent immersion in mud, water or sand• Racing or race-style high RPM use• Prolonged low speed, heavy load operation• Extended idle• Short trip cold weather operationPay special attention to the oil level. A rise in oil level during coldweather can indicate contaminants collecting in the oil sump or crankcase.Change oil immediately if the oil level begins to rise. Monitor theoil level, and if it continues to rise, discontinue use and determine thecause or see your dealer.72
Periodic Maintenance ChartWARNINGMAINTENANCEImproperly performing the procedures marked with a • could result incomponent failure and cause an accident, which may result in serious injury ordeath. Always have an authorized POLARIS dealer perform these services.Maintenance Chart Key Perform these operations more often for vehicles subjected to severeuse.E Emission-related service (Failure to conduct this maintenance willnot void the emissions warranty but may affect emissions.)• Have an authorized POLARIS dealer perform these services.Perform all services at whichever maintenance interval is reached first.ItemMaintenance Interval(whichever comes first)Hours Calendar Miles(Km)Steering - Pre-Ride -Front suspension - Pre-Ride -Rear suspension - Pre-Ride -Tires - Pre-Ride -Brake fluid level - Pre-Ride -Brake lever travel - Pre-Ride -Brake system - Pre-Ride -Wheels/fasteners - Pre-Ride -Frame fasteners - Pre-Ride -Engine oil level - Pre-Ride -RemarksSee Pre-Ride Checklist onpage 54. Air filter, pre-filterE- Daily - Inspect; clean often; replaceas neededCoolant - Daily - Check level daily, changecoolant every 2 years ADC fluid - Daily - Check level daily, add asneeded Power steering unit - Daily - Inspect daily; clean often(if equipped)Headlamp/taillight - Daily - Check operation73
Page 1:
PMS 419Sportsman 550Sportsman 550 E
Page 6 and 7:
POLARIS, THE WAY OUT and SPORTSMAN
Page 8 and 9:
INTRODUCTIONThe following signal wo
Page 10 and 11:
INTRODUCTIONVehicle Identification
Page 12 and 13:
SAFETYSafe Riding GearAlways wear a
Page 14 and 15:
SAFETYSafety WarningsWARNINGFailure
Page 16 and 17:
SAFETYSafety WarningsCarrying a Pas
Page 18 and 19:
SAFETYSafety WarningsDescending Hil
Page 20 and 21:
SAFETYSafety WarningsOperating in U
Page 24 and 25:
SAFETYSafety Labels and LocationsWa
Page 26 and 27: SAFETYSafety Labels and Locations
Page 28 and 29: 2x4FEATURES AND CONTROLSSwitchesHea
Page 30 and 31: FEATURES AND CONTROLSThrottle Lever
Page 32 and 33: FEATURES AND CONTROLSMaster Cylinde
Page 34 and 35: FEATURES AND CONTROLSAuxiliary Foot
Page 36 and 37: 2x4FEATURES AND CONTROLSAll Wheel D
Page 38 and 39: FEATURES AND CONTROLSInstrument Clu
Page 56 and 57: FEATURES AND CONTROLSFront Rack/Com
Page 58 and 59: OPERATIONPre-Ride ChecklistFailure
Page 60 and 61: OPERATIONKnow Your Riding Area/Trea
Page 62 and 63: OPERATIONDriving Procedures1. Wear
Page 64 and 65: OPERATIONDriving on Slippery Surfac
Page 66 and 67: OPERATIONDriving on a Sidehill (Sid
Page 68 and 69: OPERATIONTurning Around on a Hill (
Page 70 and 71: OPERATIONDriving Over ObstaclesFoll
Page 72 and 73: OPERATIONHauling CargoWARNINGOverlo
Page 74 and 75: OPERATIONParking on an InclineAvoid
Page 78 and 79: MAINTENANCEPeriodic Maintenance Cha
Page 80 and 81: MAINTENANCELubrication GuideCheck a
Page 82 and 83: MAINTENANCEEngine OilOil and Filter
Page 84 and 85: MAINTENANCETransmission OilPOLARIS
Page 86 and 87: MAINTENANCEActive Descent Control (
Page 88 and 89: MAINTENANCERear Gearcase OilSee the
Page 90 and 91: MAINTENANCEPower Steering UnitIf yo
Page 92 and 93: MAINTENANCECooling SystemRadiator C
Page 94 and 95: MAINTENANCEToe AlignmentUse the fol
Page 96 and 97: MAINTENANCETiresWARNINGOperating yo
Page 98 and 99: MAINTENANCETiresWheel Installation1
Page 100 and 101: MAINTENANCEFuse ReplacementIf the e
Page 102 and 103: MAINTENANCELightsHigh Beam Adjustme
Page 104 and 105: MAINTENANCELightsHeadlight Housing
Page 106 and 107: MAINTENANCESpark PlugsSpark Plug Re
Page 108 and 109: MAINTENANCEVehicle ImmersionIf your
Page 110 and 111: MAINTENANCEPVT SystemWARNINGFailure
Page 112 and 113: MAINTENANCEPVT SystemWhen To Use Lo
Page 114 and 115: MAINTENANCEThrottle Body/Idle RPMId
Page 116 and 117: MAINTENANCEBatteryWARNINGImproperly
Page 118 and 119: MAINTENANCEBatteryBattery ChargingT
Page 120 and 121: MAINTENANCECleaning and StorageWash
Page 122 and 123: MAINTENANCECleaning and StorageStor
Page 124 and 125: MAINTENANCETransporting the ATV1. S
Page 126 and 127:
TROUBLESHOOTINGEngine Doesn't Turn
Page 128 and 129:
TROUBLESHOOTINGEngine Stops or Lose
Page 130 and 131:
SPECIFICATIONSMaximum Weight Capaci
Page 132 and 133:
SPECIFICATIONSMaximum Weight Capaci
Page 134 and 135:
DECLARATION OF CONFORMITYPolaris In
Page 136 and 137:
WARRANTYWARRANTY COVERAGE AND EXCLU
Page 138 and 139:
WARRANTYHOW TO OBTAIN WARRANTY SERV
Page 140 and 141:
WARRANTYExported VehiclesHow to Get
Page 142 and 143:
WARRANTYU.S.A. EPA Emissions Limite
Page 144 and 145:
MAINTENANCE LOGDATEMILES (KM)OR HOU
Page 146 and 147:
INDEX0-94X4 Switch . . . . . . . .
Page 148:
INDEXPParking Brake . . . . . . . .
show all

Owner's Manual - Polaris

Create successful ePaper yourself

Delete template?

Save as template?