CH-TRAMPAC - Waste Isolation Pilot Plant - U.S. Department of ...

More documents

Recommendations

Info

CH-TRAMPAC Document Rev. 2, May 2005Table 6.2-6 – WIPP Control Checklist for Controlled Shipments Shipment No. ________________________Packaging No.________________________To be completed by designated WIPP Operations personnel for each package designatedas a controlled shipment:CH-TRAMPACSection No.ActivityRecordedDateRecordedTimeCompletion ofActivity(Indicate bycheckmark [√])6.2.3.5Record date and time thatthe package arrives at WIPP6.2.3.6Vent package within 24hours of date and timerecorded above and recordvent date and timeI certify that the above data is accurate and compliant with the Unloading Timelimit of 24 hours, as specified in Section 6.2.3 of the CH-TRAMPAC.6.2.3.7__________________________________________________ / _________WIPP OPERATIONS PERSONNELDATENote: Controlled shipments (10 days) shall be made in accordance with the conditions specified in Appendix 3.6 ofthe CH-TRU Payload Appendices 1 and Section 6.2.3. This table may be reformatted for WIPP use provided that thesame information is recorded.6.2-28
CH-TRAMPAC Document Rev. 2, May 20056.2.4 Mixing of Shipping CategoriesAppendix 2.4 of the CH-TRU Payload Appendices 1 describes the logic for mixing shippingcategories for compliance with flammable (gas/VOC) concentration limits, including thedetermination of the FI.Mixing of shipping categories is allowed for direct loaded and overpacked payloadconfigurations by ensuring that each payload container or overpacked container does not containa flammable mixture of gases. Mixing of shipping categories is allowed only within authorizedpayload configurations comprised of a single payload container type as listed in Table 2.1-1 ofthe CH-TRAMPAC. (Note: Standard pipe overpacks may be assembled in a TRUPACT-II orHalfPACT payload with 55-gallon drums. Standard pipe overpacks in this payload assembly areconsidered 55-gallon drums and are subject to the requirements of Section 2.9.1 andSection 3.1.) Each payload container or overpacked container is assessed through the calculationof the FI for the container, which accounts for the properties of each of the other containers inthe assembly or overpacked configuration, which may include dunnage containers.A payload is qualified for shipment only if the FI of each payload container or overpackedcontainer is a non-negative number less than or equal to 50,000. If one or more containers fail(s)the FI requirement, the payload or overpacked configuration shall be reconfigured until allcontainers satisfy this requirement. Otherwise, containers not meeting the FI requirement shallbe placed in the test category or rejected from transport and subject to mitigation or repackaging.The FI determination can be performed either manually or by the use of a verified/validatedsoftware package.6.2-29
Page 5 and 6:
CH-TRAMPAC Document Rev. 2, May 200
Page 8 and 9:
Page 10 and 11:
Page 12 and 13:
Page 14 and 15:
Page 16 and 17:
Page 18 and 19:
Page 20 and 21:
Page 22 and 23:
Page 24 and 25:
Page 26:
Page 29 and 30:
Page 31 and 32:
Page 33 and 34:
Page 35 and 36:
Page 37 and 38:
Page 39 and 40:
Page 41 and 42:
Page 43 and 44:
Page 45 and 46:
Page 47 and 48:
Page 49 and 50:
Page 51 and 52:
Page 53 and 54:
Page 55 and 56:
Page 57 and 58:
Page 59 and 60:
Page 61 and 62:
Page 63 and 64:
Page 65 and 66:
Page 67 and 68:
Page 69 and 70:
Page 71 and 72:
Page 73 and 74:
Page 75 and 76:
Page 77 and 78:
Page 79 and 80:
Page 81 and 82:
Page 83 and 84:
Page 85 and 86:
Page 87 and 88:
Page 89 and 90:
Page 91 and 92:
Page 93 and 94:
Page 95 and 96:
Page 97 and 98:
Page 99 and 100:
Page 101 and 102:
Page 103 and 104:
Page 105 and 106:
Page 107 and 108:
Page 109 and 110:
Page 111 and 112:
Page 113 and 114:
Page 115 and 116:
Page 117 and 118:
Page 119 and 120:
Page 121 and 122:
Page 123 and 124:
Page 125 and 126:
Page 127 and 128:
Page 129 and 130:
Page 131 and 132:
Page 133 and 134:
Page 135 and 136:
Page 137 and 138:
Page 139 and 140:
Page 141 and 142:
Page 143 and 144:
Page 145 and 146:
Page 147 and 148:
Page 149 and 150:
Page 151 and 152:
Page 153 and 154:
Page 155 and 156:
Page 157 and 158:
Page 159 and 160:
Page 161 and 162:
Page 163 and 164:
Page 165 and 166:
Page 167 and 168:
Page 169 and 170:
Page 171 and 172:
Page 173 and 174:
Page 175 and 176:
Page 177 and 178:
Page 179 and 180:
Page 181 and 182:
Page 183 and 184:
Page 185 and 186:
Page 187 and 188:
Page 189 and 190:
Page 191 and 192:
Page 193 and 194:
Page 195 and 196:
Page 197 and 198:
Page 199 and 200:
Page 201 and 202:
Page 203 and 204:
Page 205 and 206:
Page 207 and 208:
Page 209 and 210:
Page 211 and 212:
Page 213 and 214:
Page 215 and 216:
Page 217 and 218: CH-TRAMPAC Document Rev. 2, May 200
Page 267: CH-TRAMPAC Document Rev. 2, May 200
show all

CH-TRAMPAC - Waste Isolation Pilot Plant - U.S. Department of ...

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?