TM 3-4240-334-20&P

More documents

Recommendations

Info

TM 3-4240-334-20&P TECHNICAL MANUAL No. 3-4240-334-20&P Headquarters Department of the Army Washington, DC, 15 May 1992 UNIT MAINTENANCE MANUAL INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST FOR MASK, CHEMICAL-BIOLOGICAL: AIRCRAFT M43A1 TYPE I TYPE II (4240-01-319-5365 SMALL) (4240-01-319-5367 SMALL) (4240-01-320-8949 MEDIUM) (4240-01-319-5368 MEDIUM) (4240-01-319-5364 LARGE) (4240-01-319-5369 LARGE) (4240-01-319-5366 EXTRA LARGE) (4240-01-319-5370 EXTRA LARGE) REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS You can help improve this manual. If you find any mistakes or know of away to improve the procedures, please let us know. Mail your letter, DA Form 2028 (Recommended Changes to Publications and Blank Forms), or DA Form 2028-2 located in the back of this manual directly to Commander, U.S. Army Armament, Munitions and Chemical Command, ATTN: SMCCR-MAT, Aberdeen Proving Ground, MD 21010-5423. A reply will be furnished to you. WARNING - This document contains export-controlled technical data whose export is restricted by the Army Export Control Act (Tile 22, U.S.C., Sec 2751 et seq) or Executive Order 12470. Violation of these export laws is subject to severe criminal penalties. DISTRIBUTlON STATEMENT C: Distribution authorized to U.S. Government agencies and their contractors to protect technical or operational information. This determination was made on 29 April 1987. Other requests for this document will be referred to: Commander, U.S. Army Armament, Munitions and Chemical Command, ATTN: SMCCR-MAT Aberdeen Proving Ground, MD 21010-5423. DESTRUCTION NOTICE - Destroy by any method that will prevent disclosure of contents or reconstruction of the document. TABLE OF CONTENTS Page CHAPTER 1 Section I Section II Section Ill INTRODUCTION . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 General Information . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-1 Equipment Description and Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-2 Principles of Operation . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1-3 i
TM 3-4240-334-20&P TABLE OF CONTENTS (CONT) Page CHAPTER 2 Section I Section II Section Ill Section IV Section V Section VI MAINTENANCE INSTRUCTIONS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1 Repair Parts, Special Tools (RPSTL), Test Measurement and Diagnostic Equipment (TMDE), and Support Equipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1 Service Upon Receipt ... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-1 Equipment/User Fitting Instructions .... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-7 Preventive Maintenance Checks and Services (PMCS) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-15 Troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-38 Maintenance Procedures . . . . . . . . . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-47 Section VII Section Vlll APPENDIX A Preparation for Storage or Shipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Mask Servicing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . REFERENCES . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-71 2-72 A-1 APPENDIX B Section I Section II Section Ill MAINTENANCE ALLOCATION CHART (MAC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . B-1 Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . B-1 Maintenance Allocation Chart for M43A1 Mask . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . B-4 Tool and Test Equipment Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . B-5 Page Illus/ Figure APPENDIX C Section I Section II UNIT MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-1 Introduction . . . . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-1 Repair Parts List . . . . . . . . . . . .. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-1 Group 00 Group 01 Mask, Chemical-Biological Aircraft . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-1-1 Mask Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-2-1 C-1 C-2 ii 0101 Facepiece Assembly . . . . . . . . . . . ... . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-3-1 010101 Inlet Valve Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-4-1 010102 Outlet Valve Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . C-5-1 C-3 C-4 C-5
Page 1 and 2: TM 3-4240-334-20&P UNIT MAINTENANCE
Page 3: TM 3-4240-334-20&P WARNING Wear a p
Page 7 and 8: TM 3-4240-334-20&P M43A1 MASK 1-0
Page 9 and 10: TM 3-4240-334-20&P 1.7. CORROSION P
Page 11 and 12: TM 3-4240-334-20&P CHAPTER 2 MAINTE
Page 13 and 14: TM 3-4240-334-20&P NOTE IPD staples
Page 15 and 16: TM 3-4240-334-20&P CHECKING UNPACKE
Page 17 and 18: TM 3-4240-334-20&P Section III. EQU
Page 19 and 20: TM 3-4240-334-20&P (d) Check that f
Page 21 and 22: TM 3-4240-334-20&P (l) Remove test
Page 23 and 24: TM 3-4240-334-20&P 2-8. MASK ASSEMB
Page 25 and 26: TM 3-4240-334-20&P Section IV. PREV
Page 27 and 28: TM 3-4240-334-20&P Item No. Interva
Page 37 and 38: TM 3-4240-334-20&P Item No. lnterva
Page 41 and 42: TM 3-4240-334-20&P Interval Item to
Page 47 and 48: TM 3-4240-334-20&P para 2-8 TM-3-42
Page 49 and 50: TM 3-4240-334-20&P Table 2-3. Troub
Page 51 and 52: TM 3-4240-334-20&P para 2-13 2-41
Page 53 and 54: TM 3-4240-334-20&P 2-43
Page 55 and 56:
TM 3-4240-334-20&P Table 2-6. Troub
Page 57 and 58:
TM 3-4240-334-20&P Section VI. MAIN
Page 59 and 60:
TM 3-4240-334-20&P NOTE Buffed area
Page 61 and 62:
TM 3-4240-334-20&P c. Internal Drin
Page 63 and 64:
TM 3-4240-334-20&P e. Voicemitter R
Page 65 and 66:
TM 3-4240-334-20&P g. Linear Microp
Page 67 and 68:
TM 3-4240-334-20&P h. Dynamic Micro
Page 69 and 70:
TM 3-4240-334-20&P l. SETSCREW ADJU
Page 71 and 72:
TM 3-4240-334-20&P k. Flat Washer R
Page 73 and 74:
TM 3-4240-334-20&P 2-14. BLOWER ASS
Page 75 and 76:
TM 3-4240-334-20&P c. Webbing Strap
Page 77 and 78:
TM 3-4240-334-20&P 2-15. AUXILIARY
Page 79 and 80:
TM 3-4240-334-20&P c. Canister Seal
Page 81 and 82:
TM 3-4240-334-20&P Section VII. PRE
Page 83 and 84:
TM 3-4240-334-20&P (5) Air dry for
Page 85 and 86:
TM 3-4240-334-20&P A-5. MISCELLANEO
Page 87 and 88:
TM 3-4240-334-20&P B-2. MAINTENANCE
Page 89 and 90:
TM 3-4240-334-20&P Section II. MAIN
Page 91 and 92:
TM 3-4240-334-20&P APPENDIX C UNIT
Page 93 and 94:
TM 3-4240-334-20&P AO-(Assembled by
Page 95 and 96:
TM 3-4240-334-20&P e. DESCRIPTION A
Page 97 and 98:
TM 3-4240-334-20&P C-6. HOW TO LOCA
Page 99 and 100:
SECTION II TM3-4240-334-20&P (1) (2
Page 101 and 102:
SECTION II TM3-4240-334-20&P (1) (2
Page 103 and 104:
SECTION II TM3-4240-334-20&P (1) (2
Page 105 and 106:
SECTION II TM3-4240-334-20&P (1) (2
Page 107 and 108:
SECTION II TM3-4240-334-20&P (1) (2
Page 109 and 110:
SECTION II TM3-4240-334-20&P (1) (2
Page 111 and 112:
SECTION II TM3-4240-334-20&P (1) (2
Page 113 and 114:
SECTION II TM3-4240-334-20&P (1) (2
Page 115 and 116:
SECTION II TM3-4240-334-20&P (1) (2
Page 117 and 118:
SECTION II TM3-4240-334-20&P (1) (2
Page 119 and 120:
SECTION II TM3-4240-334-20&P (1) (2
Page 121 and 122:
SECTION II TM3-4240-334-20&P (1) (2
Page 123 and 124:
SECTION IV TM3-4240-334-20&P CROSS-
Page 125 and 126:
SECTION IV TM3-4240-334-20&P CROSS-
Page 127 and 128:
TM 3-4240-334-20&P APPENDIX D EXPEN
Page 129 and 130:
TM3-4240-334-20&P SECTION II.EXPEND
Page 131 and 132:
TM 3-4240-334-20&P Subject F (CONT)
Page 133 and 134:
TM 3-4240-334-20&P Subject Page Uni
Page 138:
PIN: 069616-000
show all

TM 3-4240-334-20&P

Create successful ePaper yourself

Delete template?

Save as template?