Prestige SOLO 110.pdf - Bloom Lake Farms

More documents

Recommendations

Info

Check-Out ProceduresSECTION XIII- Check-Out ProceduresPerform the following check-out proceduresas outlined and check off items ascompleted. When procedures are completed,the installer should complete theinstallation record on page 53.Check-out Proceduresc Boiler system water chemistry checked andverified as outlined on page 37.ccccccccccNOTICEThe boiler air vent and any automatic airvents placed within the system are openone full turn.Air is purged from the heating zones andboiler system piping.If applicable confirm that the burner hasbeen properly configured for Propaneapplication, as outlined on page 29 (Ifapplicable).Thermostat circuit wiring checked and verifiedthat no voltage is present to the lowvoltage terminals as outlined on page 39.Operating Instructions on page 42 were followedduring start-up.Combustion levels and flame pattern verifiedas outlined on page 41.Measured the rate of input on Natural Gasas outlined on page 41.Checked the incoming gas pressure to thePRESTIGE to ensure a minimum pressureof 5”w.c during flow conditions to all gasappliances and a maximum pressure of13”w.c during non-flow conditions forNatural and Propane.Adjusted balancing valves and system limitcontrols to provide design temperatures tothe primary space heating system.In multiple zone applications, adjusted forcorrect flow of boiler water to each zone.ccccccChecked and verified room thermostat(s)function properly and the thermostat(s)heat anticipator (if used) was properly set.Observed several operating cycles forproper operation of the PRESTIGE Soloand the system.Set the room thermostat(s) to the desiredroom temperature.Reviewed all instructions shipped with thePRESTIGE Solo with the homeowner ormaintenance personnel.Completed the Installation Record on page57.Ensure all manuals and other documentationare returned to the Installation envelope andgiven to the owner for safekeeping.56
Installation RecordSECTION XIV - Installation RecordPRESTIGE Model Number:Serial Number:Date of Installation:Fuel: Natural Gas PropaneMeasured Rate of Input:Btu/hrCombustion Readings:CO2%O2%COppmThe following items were completed during installation:Installation instructions have been followed and completedCheck-out procedures have been followed and completedInformation regarding the unit and installation received and left with owner /maintenance personnel.Installer Information(Company) ____________________________________________________________________(Address) ____________________________________________________________________(Address) ____________________________________________________________________(Phone Number) _________________________________________________________________57
Page 2 and 3:
Table of ContentsPRODUCT AND SAFETY
Page 5 and 6:
Table of ContentsAccessing Boiler I
Page 7 and 8:
Product & Safety InformationDefinit
Page 9 and 10:
Pre-Installation ItemsSECTION I - P
Page 11 and 12: Combustion Air and VentingSECTION I
Page 13 and 14: Combustion Air and VentingMethods o
Page 15 and 16: Combustion Air and VentingOutdoor O
Page 17 and 18: Combustion Air and VentingCommonwea
Page 19 and 20: Unit Preparations4. Remove the brac
Page 21 and 22: Boiler PipingPressure Relief Valve(
Page 23 and 24: Boiler PipingConnect the expansion
Page 25 and 26: Boiler PipingSystem Piping - Zone V
Page 27 and 28: Boiler Piping453AdditionalZone Load
Page 29 and 30: Boiler Piping45AdditionalRadiant Zo
Page 31 and 32: Installing Vent/ Combustion Air & C
Page 33 and 34: Gas PipingSECTION VI - Gas PipingGa
Page 35 and 36: Gas PipingPROPANE GASPipe Sizing -
Page 37 and 38: Internal WiringSECTION VII - Intern
Page 39 and 40: External WiringSECTION VIII- Extern
Page 41 and 42: External Wiring4 Wire Zone ValveZon
Page 43 and 44: Start-Up PreparationSECTION IX - St
Page 45 and 46: Start-Up PreparationCheck For Gas L
Page 47 and 48: Start-Up ProceduresccWARNINGVenting
Page 49 and 50: Start-Up ProceduresSet Boiler CH Ta
Page 51 and 52: Start-Up ProceduresBoiler Control D
Page 53 and 54: Start-Up ProceduresSetting The Boil
Page 55 and 56: Start-Up ProceduresError (Hard Lock
Page 57 and 58: Outdoor Reset ControlSummer / Winte
Page 59 and 60: Outdoor Reset Control180Boiler Temp
Page 61: Factory Setting ParametersFactory S
Page 65 and 66: Maintenance ProceduresSECTION XVI -
Page 67 and 68: Maintenance ProceduresCheck Expansi
Page 69 and 70: Maintenance ProceduresCheck Flame S
Page 71 and 72: Replacement Parts7659253Fig. 26: PR
Page 73 and 74: Replacement PartsFig. 28: PRESTIGE
Page 75 and 76: Product Specifications15.43” [392
Page 77 and 78: Products SpecificationsBoilerModelF
Page 79: Additional Quality Water Heating Eq
show all

Prestige SOLO 110.pdf - Bloom Lake Farms

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?