C - Peterbilt Motors Company

More documents

Recommendations

Info

5 Maintenance Procedures Maintenance Procedures Oil Pan Drain Plug After draining the oil, discard the washer and replace with a new copper sealing washer, torque the bolt to 44 lb-ft (60 Nm). 5-20 Inspection of the Engine Oil Level NOTE: It takes approximately 15 minutes for all the oil to run into the sump when the engine is ‘warm.’ If the level is checked immediately after switching off the engine, the dipstick will show a low oil level. 1. Make sure that the vehicle frame rail is standing on a flat and level surface. 2. Make sure that the vehicle is horizontal, both lengthwise and crosswise. Check this carefully on a vehicle with air suspension. Note that the engine may be inclined up to 4° depending on the vehicle model and wheelbase. 3. Twist the dipstick handle to unlock it, then pull the dipstick out of the holder. 4. Wipe the dipstick clean with a lint-free cloth. 5. Place the dipstick back into the holder. 6. Pull the dipstick out again and check the oil level. The oil level should always be between the 2 marks on the dipstick. 7. Reinstall the dipstick and twist to lock it in place.
1. Engine Oil High Level 2. Engine Oil Low Level Topping Up the Engine Oil 1. Top up with oil, if necessary, via the filler opening. Use the correct grade in the correct quantity. 2. After topping up, wait 1 minute and check the oil level again. 3. Reinstall the oil fill cap and twist to lock it in place. NOTE: PACCAR recommends the use of high-quality SAE 15W40 (API CJ-4) heavy-duty engine oil. Maintenance Procedures 5-21 5
Page 3 and 4:
Contents Safety Emergency Controls
Page 5:
Introduction Safety Alerts . . . .
Page 8 and 9:
1 Introduction CAUTION CAUTION: The
Page 10 and 11: 1 Introduction Important Reference
Page 12 and 13: 1 Introduction • Always use block
Page 15: WHAT TO DO IF... You Need Roadside
Page 18 and 19: 2 WHAT TO DO IF... Engine Oil Press
Page 20 and 21: 2 WHAT TO DO IF... 2-6 • Check to
Page 23: Operating Instructions Engine Warni
Page 26 and 27: 3 Operating Instructions Stop Engin
Page 28 and 29: 3 Operating Instructions Engine Ope
Page 30 and 31: 3 Operating Instructions Compressio
Page 32 and 33: 3 Operating Instructions Engine Com
Page 35 and 36: Operating Instructions General Info
Page 37 and 38: Cold Weather Starting General Infor
Page 39: System EMI Susceptibility PACCAR pr
Page 42 and 43: 5 5-2 Replacing Engine Oil Filters
Page 44 and 45: 5 Maintenance Guidelines Maintenanc
Page 46 and 47: 5 Maintenance Guidelines 5-6 ° Hos
Page 48 and 49: 5 Maintenance Guidelines Every 200,
Page 50 and 51: 5 Maintenance Specifications Mainte
Page 52 and 53: 5 Maintenance Specifications Coolin
Page 54 and 55: 5 Maintenance Specifications 5-14 a
Page 56 and 57: 5 Maintenance Specifications Lubric
Page 58 and 59: 5 Maintenance Specifications Checki
Page 62 and 63: 5 Maintenance Procedures Replacing
Page 64 and 65: 5 Maintenance Procedures Centrifuga
Page 66 and 67: 5 Maintenance Procedures 5-26 ° re
Page 68 and 69: 5 Maintenance Procedures proximity.
Page 70 and 71: 5 Maintenance Procedures NOTE: A sm
Page 72 and 73: 5 Maintenance Procedures Removal an
Page 75: Engine Identification Warranty Engi
Page 78 and 79: 6 Engine Identification EPA Label T
Page 80 and 81: 6 Warranty • Flywheel Housing •
Page 82 and 83: 6 Warranty limited to: damage due t
Page 84 and 85: 6 Warranty Base Engine Warranty The
Page 86 and 87: 6 Warranty 6,250 hours from the dat
Page 88 and 89: 6 Warranty Replacement Parts PACCAR
Page 90 and 91: 6 Warranty Your Warranty Rights and
Page 92 and 93: 6 Warranty Emissions Components Sta
Page 94 and 95: 6 Warranty PACCAR Engine dealer and
Page 96 and 97: 6 Warranty LIABLE FOR INCIDENTAL OR
Page 98: 7 Index 750,000 mi / 22,000 hours 5
show all

C - Peterbilt Motors Company

Create successful ePaper yourself

Delete template?

Save as template?