C - Peterbilt Motors Company

More documents

Recommendations

Info

6 Warranty PACCAR Engine dealer and may elect to use parts other than new or genuine approved rebuilt parts and assemblies for such maintenance, replacement or repair; however, the cost of such service or parts and subsequent failures resulting from such service or parts will not be covered under this emission control system warranty, except for Emergency Repairs as described below. 6-20 PACCAR Responsibilities The warranty coverage begins when the engine is delivered to the first purchaser. Repairs and service will be performed by any authorized PACCAR Engine dealer using new or genuine approved rebuilt parts and assemblies. PACCAR will repair any of the emission control parts found by PACCAR to be defective without charge for parts or labor (including diagnosis which results in determination that there has been a failure of a warranted emission control part). Emergency Repairs In the case of an emergency where an authorized PACCAR Engine dealer is not available, repairs may be performed by any available repair location or by any individual using any replacement parts. A part not being available within 30 days or a repair not being complete within 30 days constitutes an emergency. PACCAR will reimburse the Owner for expenses (including diagnosis), not to exceed the manufacturers suggested retail price for all warranted parts replaced and labor charges based on the manufacturers recommended time allowance for the warranty repair and the geographically appropriate hourly labor rate. Replaced parts and paid invoices must be presented at an authorized PACCAR Engine dealer as a condition of reimbursement for emergency repairs not performed by an authorized PACCAR Engine dealer.
Warranty Limitations Your sole and exclusive remedy against PACCAR and the Selling Dealer arising from your purchase and use of this Engine is limited to the repair or replacement of “warrantable failures” at authorized United States and Canadian PACCAR Engine Dealers, or an authorized PACCAR Engine facility where applicable, subject to PACCAR’s time, mileage, and hour limitations of the engine emission warranty. The maximum time, mileage and hour limitations of the engine emission warranty begin running on the Date of Delivery to the First Purchaser. The accrued time, mileage, or hours is calculated when the engine is brought into an Authorized Dealer for correction of warrantable failures. PACCAR is not responsible for failures or damage resulting from what PACCAR determines to be abuse or neglect, including, but not limited to: damage due to accident; operation without adequate coolants or lubricants; overfueling; overspeeding; lack of maintenance of cooling, lubricating or intake systems; improper storage, starting, warm-up, run-in or shutdown practices; unauthorized modifications to the engine. PACCAR is also not responsible for failures caused by incorrect oil, fuel or diesel exhaust fluid or by water, dirt or other contaminants in the fuel, oil or diesel exhaust fluid. Failure of replacement parts used in repairs due to the above non-warrantable conditions is not warrantable. PACCAR is not responsible for failures resulting from improper repair or the use of parts which are not genuine approved parts. PACCAR is not responsible for the material and labor costs of emission control parts and assemblies replaced Warranty during Scheduled Maintenance of the engine as specified in PACCAR Operator’s Manuals. THIS WARRANTY, TOGETHER WITH THE EXPRESS COMMERCIAL WARRANTIES ARE THE SOLE WARRANTIES MADE BY PACCAR IN REGARD TO THESE ENGINES. THIS LIMITED EMISSIONS WARRANTY IS THE SOLE WARRANTY MADE BY PACCAR AND THE SELLING DEALER. EXCEPT FOR THE ABOVE LIMITED WARRANTY, PACCAR AND THE SELLING DEALER MAKE NO OTHER WARRANTIES, EXPRESS OR IMPLIED. PACCAR AND THE SELLING DEALER EXPRESSLY DISCLAIM ANY WARRANTY OF MERCHANTABILITY OR WARRANTY OF FITNESS FOR A PARTICULAR PURPOSE. PACCAR AND THE SELLING DEALER SHALL NOT BE 6-21 6
Page 3 and 4:
Contents Safety Emergency Controls
Page 5:
Introduction Safety Alerts . . . .
Page 8 and 9:
1 Introduction CAUTION CAUTION: The
Page 10 and 11:
1 Introduction Important Reference
Page 12 and 13:
1 Introduction • Always use block
Page 15:
WHAT TO DO IF... You Need Roadside
Page 18 and 19:
2 WHAT TO DO IF... Engine Oil Press
Page 20 and 21:
2 WHAT TO DO IF... 2-6 • Check to
Page 23:
Operating Instructions Engine Warni
Page 26 and 27:
3 Operating Instructions Stop Engin
Page 28 and 29:
3 Operating Instructions Engine Ope
Page 30 and 31:
3 Operating Instructions Compressio
Page 32 and 33:
3 Operating Instructions Engine Com
Page 35 and 36:
Operating Instructions General Info
Page 37 and 38:
Cold Weather Starting General Infor
Page 39:
System EMI Susceptibility PACCAR pr
Page 42 and 43:
5 5-2 Replacing Engine Oil Filters
Page 44 and 45: 5 Maintenance Guidelines Maintenanc
Page 46 and 47: 5 Maintenance Guidelines 5-6 ° Hos
Page 48 and 49: 5 Maintenance Guidelines Every 200,
Page 50 and 51: 5 Maintenance Specifications Mainte
Page 52 and 53: 5 Maintenance Specifications Coolin
Page 54 and 55: 5 Maintenance Specifications 5-14 a
Page 56 and 57: 5 Maintenance Specifications Lubric
Page 58 and 59: 5 Maintenance Specifications Checki
Page 60 and 61: 5 Maintenance Procedures Maintenanc
Page 62 and 63: 5 Maintenance Procedures Replacing
Page 64 and 65: 5 Maintenance Procedures Centrifuga
Page 66 and 67: 5 Maintenance Procedures 5-26 ° re
Page 68 and 69: 5 Maintenance Procedures proximity.
Page 70 and 71: 5 Maintenance Procedures NOTE: A sm
Page 72 and 73: 5 Maintenance Procedures Removal an
Page 75: Engine Identification Warranty Engi
Page 78 and 79: 6 Engine Identification EPA Label T
Page 80 and 81: 6 Warranty • Flywheel Housing •
Page 82 and 83: 6 Warranty limited to: damage due t
Page 84 and 85: 6 Warranty Base Engine Warranty The
Page 86 and 87: 6 Warranty 6,250 hours from the dat
Page 88 and 89: 6 Warranty Replacement Parts PACCAR
Page 90 and 91: 6 Warranty Your Warranty Rights and
Page 92 and 93: 6 Warranty Emissions Components Sta
Page 96 and 97: 6 Warranty LIABLE FOR INCIDENTAL OR
Page 98: 7 Index 750,000 mi / 22,000 hours 5
show all

C - Peterbilt Motors Company

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?