C - Peterbilt Motors Company

More documents

Recommendations

Info

6 Warranty Emissions Components Statement for MX Engine (2010) Emissions Engine Coverage This list of emission control parts may be covered by the Emission Control System Warranty under certain failure modes. Aftertreatment System • Electronic Control Unit • Diesel Oxidation Catalyst • Diesel Particulate Filter (DPF) • Selective Catalytic Reduction (SCR) Catalyst • DPF Air / Fuel Manifold Assembly • DPF Fuel Injector including air, fuel, and coolant lines • DPF Fuel Pressure Sensor • DPF Air Supply Pressure Sensor • Pressure protection valve and plumbing to DPF Fuel Injector 6-18 • DPF Temperature Sensors and Signal Conditioner • DPF Pressure Sensors • Pre-SCR Temperature • Post-SCR Temperature • NOx Sensor • Decomposition Pipe and Pipe Elbows • Exhaust piping from turbocharger to last aftertreatment device Diesel Emission Fluid (DEF) System • DEF Tank, Heater, and associated plumbing • DEF Pump Module and associated plumbing • DEF Dosing Module with Injection Nozzle and wiring harness • DEF Level/Temperature Sensor • DEF Lines and Heating elements • DEF Line Heater Control Relay • DEF Tank Heater Coolant Control Valve • DEF Dosing ECU Dash Lamp • DEF Lamp Crankcase Ventilation System • Crankcase Ventilation Separator and associated plumbing Intake System • Air Intake Pipe Mixer • Pressure/Temperature/Humidity Sensor before Turbocharger • Charge Air Cooler and associated plumbing • Turbocharger and associated plumbing Electronic Control System • Engine Control Module • Coolant Temperature Sensor
• Intake Manifold Pressure and Temperature Sensor • Turbocharger Speed Sensor • Exhaust Gas Recirculation (EGR) Temperature Sensor • EGR Differential Pressure Sensor and associated plumbing • Crankshaft Speed Sensor • NOx Sensor • Ambient Temperature Sensor • Lambda Sensor • Exhaust Manifold Pressure Sensor • Temperature after Turbocharger • Vehicle Speed Sensor • Engine Oil Temperature Sensor • Water Pump Speed Sensor • Fuel Temperature Sensor • Pressure Sensor after Exhaust Throttle Valve • Wiring harnesses connected at both ends to emission warranty components Exhaust Gas Recirculation System (EGR) • EGR Valve and associated plumbing • EGR Cooler and associated plumbing Engine • Exhaust Manifold • Exhaust Throttle Valve and plumbing Fueling System • Injectors • Fuel Pumps and associated engine plumbing Replacement Parts Warranty PACCAR recommends that any service parts used for maintenance, repair or replacement of emission control systems be new or genuine approved rebuilt parts and assemblies, and that the engine be serviced by an authorized PACCAR Engine dealer. Your vehicle contains air, fuel, and electrical components that may affect engine emission controls. The use of non-genuine engine or vehicle replacement parts that are not equivalent to the PACCAR engine or OEM vehicle manufacturer’s original part may impair the engine and vehicle emissions control system from working or functioning effectively, and may jeopardize your emissions warranty coverage. The owner may elect to have maintenance, replacement or repair of the emission control parts performed by a facility other than an authorized 6-19 6
Page 3 and 4:
Contents Safety Emergency Controls
Page 5:
Introduction Safety Alerts . . . .
Page 8 and 9:
1 Introduction CAUTION CAUTION: The
Page 10 and 11:
1 Introduction Important Reference
Page 12 and 13:
1 Introduction • Always use block
Page 15:
WHAT TO DO IF... You Need Roadside
Page 18 and 19:
2 WHAT TO DO IF... Engine Oil Press
Page 20 and 21:
2 WHAT TO DO IF... 2-6 • Check to
Page 23:
Operating Instructions Engine Warni
Page 26 and 27:
3 Operating Instructions Stop Engin
Page 28 and 29:
3 Operating Instructions Engine Ope
Page 30 and 31:
3 Operating Instructions Compressio
Page 32 and 33:
3 Operating Instructions Engine Com
Page 35 and 36:
Operating Instructions General Info
Page 37 and 38:
Cold Weather Starting General Infor
Page 39:
System EMI Susceptibility PACCAR pr
Page 42 and 43: 5 5-2 Replacing Engine Oil Filters
Page 44 and 45: 5 Maintenance Guidelines Maintenanc
Page 46 and 47: 5 Maintenance Guidelines 5-6 ° Hos
Page 48 and 49: 5 Maintenance Guidelines Every 200,
Page 50 and 51: 5 Maintenance Specifications Mainte
Page 52 and 53: 5 Maintenance Specifications Coolin
Page 54 and 55: 5 Maintenance Specifications 5-14 a
Page 56 and 57: 5 Maintenance Specifications Lubric
Page 58 and 59: 5 Maintenance Specifications Checki
Page 60 and 61: 5 Maintenance Procedures Maintenanc
Page 62 and 63: 5 Maintenance Procedures Replacing
Page 64 and 65: 5 Maintenance Procedures Centrifuga
Page 66 and 67: 5 Maintenance Procedures 5-26 ° re
Page 68 and 69: 5 Maintenance Procedures proximity.
Page 70 and 71: 5 Maintenance Procedures NOTE: A sm
Page 72 and 73: 5 Maintenance Procedures Removal an
Page 75: Engine Identification Warranty Engi
Page 78 and 79: 6 Engine Identification EPA Label T
Page 80 and 81: 6 Warranty • Flywheel Housing •
Page 82 and 83: 6 Warranty limited to: damage due t
Page 84 and 85: 6 Warranty Base Engine Warranty The
Page 86 and 87: 6 Warranty 6,250 hours from the dat
Page 88 and 89: 6 Warranty Replacement Parts PACCAR
Page 90 and 91: 6 Warranty Your Warranty Rights and
Page 94 and 95: 6 Warranty PACCAR Engine dealer and
Page 96 and 97: 6 Warranty LIABLE FOR INCIDENTAL OR
Page 98: 7 Index 750,000 mi / 22,000 hours 5
show all

C - Peterbilt Motors Company

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?