JW220-UM-251 - Graphtec

More documents

Recommendations

Info

7. DISASSEMBLY AND REASSEMBLY7.2.14 How to Replace an Ink Supply TubeHave ready a syringe attached to a needle, double-sided adhesive tape (5 x 240 mm) and a new tube(Required length: about 910 mm for each tube).How to detach the ink supply tube(1) Detach the left side cover (see Subsection 7.1.1).(2) Detach the left rear cover (see Subsection 7.1.5).(3) Detach the center rear cover (see Subsection 7.1.2).(4) Detach the right top cover (see Subsection 7.1.3).(5) Detach the right rear cover (see Subsection 7.1.5).(6) Release all the clamps holding the ink supply tubes.Clamp(7) Release the print head cover from the front, and then open the print head cover.Print head coverRelease the print head coverfrom here.JW220-UM-251-93707-34
7. DISASSEMBLY AND REASSEMBLY(8) Detach the ink supply tube from the print head.Tube(9) Pull out the sponge holding the pressure buffer at the rear of the printer.The sponge is attached by double-sided adhesive tape, so gently detach the sponge from thebracket.SpongeThe sponge is attached bydouble-sided adhesive tape onthe inside of this bracket.(10) Disconnect the tube from the T-type tube joint; at this time do not pull the tube that isconnected to the ink cartridge tank.T-type jointDisconnect the tube fromthe T-type tube joint in thedirection of the arrow asshown in the photograph.JW220-UM-251-93707-35
Page 1 and 2:
JW220-06SERVICE MANUALMANUAL NO. JW
Page 3 and 4: CONTENT1. INTRODUCTION ............
Page 5: 9. TROUBLESHOOTING ................
Page 12 and 13: 2. PART NAMES and FUNCTIONSRear Vie
Page 14: 3. STANDARD ACCESSOIES and OPTIONSJ
Page 22 and 23: 7. DISASSEMBLY AND REASSEMBLYHow to
Page 24 and 25: 7. DISASSEMBLY AND REASSEMBLY7.1.3
Page 26 and 27: 7. DISASSEMBLY AND REASSEMBLY(7) Re
Page 28: 7. DISASSEMBLY AND REASSEMBLY7.1.6
Page 31 and 32: 7.2.2 How to Replace the Main Board
Page 33 and 34: 7.2.4 How to Replace the Power Supp
Page 41 and 42: 7. DISASSEMBLY AND REASSEMBLY(5) De
Page 47 and 48: 7.2.13 How to Replace the Carriage
Page 49 and 50: 7. DISASSEMBLY AND REASSEMBLY(20) R
Page 53: 7. DISASSEMBLY AND REASSEMBLY(7) Re
Page 57 and 58: 7. DISASSEMBLY AND REASSEMBLY(6) Co
Page 59: 7. DISASSEMBLY AND REASSEMBLY(11) C
Page 62 and 63: 8. ELECTRICAL ADJUSTMENTS8.2 Upgrad
Page 64 and 65: 8. ELECTRICAL ADJUSTMENTS(5) Select
Page 66 and 67: 8. ELECTRICAL ADJUSTMENTS8.3.2 How
Page 68 and 69: 8. ELECTRICAL ADJUSTMENTS8.3.3 How
Page 71 and 72: 9. TROUBLESHOOTING9. TROUBLESHOOTIN
Page 73 and 74: 9. TROUBLESHOOTINGSymptom Verificat
Page 75 and 76: 9. TROUBLESHOOTINGSymptom Verificat
Page 77 and 78: 9.5 Ink Supply9. TROUBLESHOOTINGSym
Page 79 and 80: 9.7 How toDraw Ink from the Ink Car
Page 81: 9. TROUBLESHOOTING(9) Attach the pr
Page 84 and 85: 10. PARTS LISTSOuter Casing94820133
Page 86 and 87: 10. PARTS LISTSBottom Chassis171314
Page 88 and 89: 10. PARTS LISTSMain Frame51159144 1
Page 90 and 91: 10. PARTS LISTSY Drive219 171816156
Page 92 and 93: 10. PARTS LISTSCarriage813149161211
Page 94 and 95: 10. PARTS LISTSStand108511972341211
Page 96: 10. PARTS LISTS10.9 OtherStandard A
show all

JW220-UM-251 - Graphtec

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?