Liebert Challenger 3000 with iCOM

More documents

Recommendations

Info

Split System ModelsFigure 44 5-ton water/glycol-cooled condensing unit (con't.)Field-supplied unit disconnectswitch when factory unitdisconnect switch is not supliedElectric service;not by <strong>Liebert</strong>WATER/GLYCOLOptional factory-installeddisconnect switchField-supplied 24VNEC Class 1 wiringto fan/coil unitField-supplied 24VNEC Class 1 wiringto drycooler(glycol-cooled units only)Line voltage electricpower supply conduit voltageRemovableAccess PanelHeat rejection connection.Field-supplied 24V NEC Class 2 wiring.Wire connections from evaporator mod:1. 24V ground2. 24V supply3. High pressure alarm (optional)4. Hot gas bypass connection(only on units <strong>with</strong> hot gas bypass)Remote drycoolerconnection; field-supplied24V NEC Class 1 wiring(glycol-cooled units only)Connection terminalfor field-suppliedearth grounding wireLow-voltage electricpower supply conduitentranceField-supplied 24V NECClass 1 wiring betweenglycol condensing unitand drycoolerDPN000228_Rev0NOTES1. Refer to specification sheet for full load amp. and wire size amp. ratings.2. Control voltage wiring must be a minimum of 16 G A (1.6mm) for up to 75' (23m)or not to exceed 1 volt drop in control line.76
R407C Refrigerant8.0 R407C REFRIGERANTTable 33R407C pressure/temperature chart for operation and superheat (discharge/hot gas and suctiongas)Temperature Gauge Pressure Temperature Gauge Pressure Temperature Gauge Pressure°F °C Psig kPa °F °C Psig kPa °F °C Psig kPa0.0 -17.8 18.9 130 35.0 1.7 54.8 378 70.0 21.1 114.9 7921.0 -17.2 19.6 135 36.0 2.2 56.1 387 72.0 22.2 119.3 8222.0 -16.7 20.4 141 37.0 2.8 57.5 396 74.0 23.3 124 8533.0 -16.1 21.2 146 38.0 3.3 58.9 406 76.0 24.4 128 8854.0 -15.6 22.0 152 39.0 3.9 60.3 415 78.0 25.6 133 9175.0 -15.0 22.8 157 40.0 4.4 62.2 429 80.0 26.7 138 9506.0 -14.4 23.6 163 41.0 5.0 63.1 435 82.0 27.8 143 9847.0 -13.9 24.5 169 42.0 5.6 64.6 445 84.0 28.9 148 10198.0 -13.3 25.4 175 43.0 6.1 66.1 456 86.0 30.0 153 10549.0 -12.8 26.2 181 44.0 6.7 67.6 466 88.0 31.1 158 109110.0 -12.2 27.1 187 45.0 7.2 69.1 476 90.0 32.2 164 112811.0 -11.7 28.0 193 46.0 7.8 70.7 487 92.0 33.3 169 116712.0 -11.1 28.9 200 47.0 8.3 72.2 498 94.0 34.4 175 120613.0 -10.6 29.9 206 48.0 8.9 73.8 509 96.0 35.6 181 124614.0 -10.0 30.8 213 49.0 9.4 75.4 520 98.0 36.7 187 128715.0 -9.4 31.8 219 50.0 10.0 77.1 531 100.0 37.8 193 132916.0 -8.9 32.8 226 51.0 10.6 78.7 543 102.0 38.9 199 137217.0 -8.3 33.8 233 52.0 11.1 80.4 554 104.0 40.0 205 141618.0 -7.8 34.8 240 53.0 11.7 82.1 566 106.0 41.1 212 146119.0 -7.2 35.8 247 54.0 12.2 83.9 578 108.0 42.2 219 150720.0 -6.7 36.9 254 55.0 12.8 85.6 590 110.0 43.3 225 155321.0 -6.1 38.0 262 56.0 13.3 87.4 603 112.0 44.4 232 160122.0 -5.6 39.0 269 57.0 13.9 89.2 615 114.0 45.6 239 165023.0 -5.0 40.1 277 58.0 14.4 91.0 628 116.0 46.7 247 170124.0 -4.4 41.3 284 59.0 15.0 92.9 640 118.0 47.8 254 175225.0 -3.9 42.4 292 60.0 15.6 94.8 653 120.0 48.9 262 180426.0 -3.3 43.6 300 61.0 16.1 96.7 666 122.0 50.0 269 185827.0 -2.8 44.7 308 62.0 16.7 98.6 680 124.0 51.1 277 191228.0 -2.2 45.9 317 63.0 17.2 100.5 693 126.0 52.2 285 196829.0 -1.7 47.1 325 64.0 17.8 102.5 707 128.0 53.3 294 202530.0 -1.1 48.4 333 65.0 18.3 104.5 721 130.0 54.4 302 208331.0 -0.6 49.6 342 66.0 18.9 106.5 735 132.0 55.6 311 214332.0 0.0 50.9 351 67.0 19.4 108.6 749 134.0 56.7 320 220333.0 0.6 52.1 359 68.0 20.0 110.7 763 136.0 57.8 329 226534.0 1.1 53.5 369 69.0 20.6 112.8 778 138.0 58.9 338 2329- - - - - - - - 140.0 60.0 347 2393NOTEUse this table for superheat and for control adjustment (e.g., pressure switches). SeeTable 34 for subcooling.77
Page 1:
Precision CoolingFor Business-Criti
Page 5 and 6:
7.5 Centrifugal Air-Cooled Condensi
Page 7 and 8:
IMPORTANT SAFETY INSTRUCTIONSSAVE T
Page 9 and 10:
Introduction1.0 INTRODUCTION1.1 Sys
Page 11 and 12:
Installation (Applicable to all Mod
Page 13 and 14:
Page 15 and 16:
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Page 23 and 24:
Figure 11 Piping connections for ch
Page 25 and 26:
Page 27 and 28:
Page 29 and 30:
3.0 AIR-COOLED MODELS—SELF-CONTAI
Page 31 and 32: Air-Cooled Models—Self-Contained
Page 39 and 40: Figure 17 General arrangement—Air
Page 41 and 42: 4.0 WATER-COOLED MODELS—SELF-CONT
Page 43 and 44: Figure 20 General arrangement diagr
Page 45 and 46: Water-Cooled Models—Self-Containe
Page 47 and 48: Glycol/GLYCOOL-Cooled Models—Self
Page 49 and 50: NOTICEGlycol/GLYCOOL-Cooled Models
Page 51 and 52: 5.5.2 Glycol SolutionsGlycol/GLYCOO
Page 57 and 58: Figure 27 General arrangement—GLY
Page 59 and 60: 5.5.4 Motor Ball Valve—Digital Sc
Page 61 and 62: Chilled Water ModelsFigure 30 Chill
Page 63 and 64: 7.2.2 Low VoltageSplit System Model
Page 65 and 66: Split System ModelsTable 24 Line co
Page 67 and 68: Table 26Horizontal air discharge ca
Page 69 and 70: Table 28Split System ModelsCabinet
Page 71 and 72: Split System Models7.5 Centrifugal
Page 73 and 74: Figure 36 3-ton centrifugal air-coo
Page 75 and 76: Split System ModelsFigure 38 5-ton
Page 77 and 78: Split System ModelsFigure 40 Split
Page 79 and 80: 7.6.4 Glycol SystemsSplit System Mo
Page 81: Split System ModelsFigure 43 5-ton
Page 85 and 86: R407C RefrigerantNOTES79
Page 88: Ensuring The High AvailabilityOf Mi
show all

Liebert Challenger 3000 with iCOM

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?