Manual - Unvented Gas Log Heater or Vented Decorative Appliance

More documents

Recommendations

Info

CONTENTS BLDV7 Series Gas Fireplace Thank you and congratulations on your purchase of a Monessen Fireplace. PLEASE READ THE INSTALLATION AND OPERATION INSTRUCTIONS BEFORE USING THE APPLIANCE! IMPORTANT: Read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible fire hazard and will void the warranty. Important Safety Information...................................... 3 Code Approval.............................................................. 4 Product Specifications................................................ 5 High Elevations........................................................ 5 Gas Pressures......................................................... 5 Gas Specifications & Orifice Size............................ 5 Pre-Installation Information Fireplace Dimensions & Framing............................ 6 Before You Start...................................................... 7 Cold Climate Insulation............................................ 7 Fireplace Location................................................... 8 Clearances.................................................................... 9 Securing Fireplace to Floor or Framing................... 10 Vent Installation......................................................... 11 Installation Precautions......................................... 11 General Venting..................................................... 11 Termination Location............................................. 12 Assembling Vent Pipes.......................................... 13 How to Use the Vent Graph................................... 14 Vent Pipe Clearances to Combustibles................. 15 Vertical Sidewall Applications & Installation............................................................. 16 Below Grade Installation........................................ 18 Vertical Through-the-Roof Applications & Installation.......................................................... 19 Fireplace Installation................................................. 22 Check Gas Type.................................................... 22 Install Gas Piping to Fireplace/Burner System Location................................................................. 22 Check Gas Pressure (Millivolt) ................................ 24 Electrical Installation................................................. 24 Electrical Wiring..................................................... 24 Glass Removal........................................................... 25 Remote Wall Switch Installation............................... 26 Optional Fan/Blower Systems (Milli-Volt)................ 26 BLOTBLDV............................................................ 26 Operating Instructions (Milli-Volt)............................ 29 Lighting Pilot for the First Time.............................. 29 Lighting Pilot.......................................................... 30 Lighting Burner...................................................... 31 Checking Gas Pressure - (Signature Command System) .......................... 32 Electrical Wiring (SCS) ............................................. 32 Junction Box Wiring............................................... 33 Command Center Wall Installation........................ 33 Wall Switch Installation.......................................... 33 Signature Command Wiring Diagram.................... 34 Optional Fan/Blower System (SCS).......................... 35 BLOTSDVSC......................................................... 35 BLOTSDV.............................................................. 36 Operating Instructions (SCS).................................... 37 Operating Instructions........................................... 38 To Turn Off Gas To Appliance................................ 38 Signature Command System Operation.................. 39 Final Installation......................................................... 42 Hearth Brick Placement......................................... 42 Rockwool Placement............................................. 42 Log Placement....................................................... 42 Cleaning and Maintenance........................................ 44 Burner, Pilot and Control Compartment................. 44 Pilot Flame............................................................. 44 Burner Flame......................................................... 44 Vent System.......................................................... 45 Glass Door............................................................. 45 Logs....................................................................... 45 Rock Wool ............................................................ 45 Troubleshooting Standing Pilot Ignition............................................ 46 Signature Command System................................. 48 Replacement Parts..................................................... 49 Firebox Components............................................. 49 Standing Pilot Millivolt Control .............................. 50 Signature Command System................................. 52 Logs....................................................................... 54 Venting Components............................................. 55 Massachusetts Residents Only................................ 55 Warranty...................................................................... 59 Efficiencies................................................................. 60 74D3000
BLDV7 Series Gas Fireplace INSTALLER Please leave these instructions with the appliance. OWNER IMPORTANT SAFETY INFORMATION Please retain these instructions for future reference. WARNING • Read this owner’s manual carefully and completely before trying to assemble, operate, or service this fireplace. • Any change to this fireplace or its controls can be dangerous. • Improper installation or use of this fireplace can cause serious injury or death from fire, burns, explosions, electrical shock and carbon monoxide poisoning. This fireplace is a vented product. This fireplace must be properly installed by a qualified service person. The glass door must be properly seated and sealed. If this unit is not properly installed by a qualified service person with glass door properly seated and sealed, combustion leakage can occur. CARBON MONOXIDE POISONING: Early signs of carbon monoxide poisoning are similar to the flu with headaches, dizziness and/or nausea. If you have these signs, the fireplace may not have been installed properly. Get fresh air at once! Have the fireplace inspected and serviced by a qualified service person. Some people are more affected by carbon monoxide than others. These include pregnant women, people with heart or lung disease or anemia, those under the influence of alcohol, and those at high altitudes. Propane/LP gas and natural gas are both odorless. An odor-making agent is added to each of these gases. The odor helps you detect a gas leak. However, the odor added to these gases can fade. Gas may be present even though no odor exists. Make certain you read and understand all warnings. Keep this manual for reference. It is your guide to safe and proper operation of this fireplace. 1. This appliance is only for use with the type of gas indicated on the rating plate. This appliance is not convertible for use with other gases unless a certified kit is used. 2. For propane/LP fireplace, do not place propane/LP supply tank(s) inside any structure. Locate propane/LP supply tank(s) outdoors. To prevent performance problems, do not use propane/LP fuel tank of less than 100 lbs. capacity. 3. If you smell gas • shut off gas supply. • do not try to light any appliance. • do not touch any electrical switch; do not use any phone in your building . • immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. 74D3000 4. Never install the fireplace • in a recreational vehicle • where curtains, furniture, clothing, or other flammable objects are less than 42" from the front, top, or sides of the fireplace • in high traffic areas • in windy or drafty areas 5. This fireplace reaches high temperatures. Keep children and adults away from hot surfaces to avoid burns or clothing ignition. Fireplace will remain hot for a time after shutdown. Allow surfaces to cool before touching. 6. Young children should be carefully supervised when they are in the same room as the appliance. Toddlers, young children and others may be susceptible to accidental contact burns. A physical barrier is recommended if there are at risk individuals in the house. To restrict access to a fireplace or stove, install an adjustable safety gate to keep toddlers, young children and other at risk individuals out of the room and away from hot surfaces. 7. Do not modify fireplace under any circumstances. Any parts removed for servicing must be replaced prior to operating fireplace. 8. Turn fireplace off and let cool before servicing, installing, or repairing. Only a qualified service person should install, service, or repair the fireplace. Have burner system inspected annually by a qualified service person. 9. You must keep control compartments, burners, and circulating air passages clean. More frequent cleaning may be needed due to excessive lint and dust. Turn off the gas valve and pilot light before cleaning fireplace. 10. Have venting system inspected annually by a qualified service person. If needed, have venting system cleaned or repaired. Refer to Cleaning and Maintenance, Page 44. 11. Keep the area around your fireplace clear of combustible materials, gasoline, and other flammable vapor and liquids. Do not run fireplace where these are used or stored. Do not place items such as clothing or decorations on or around fireplace.
Page 1: BLDV7 Series Direct Vent Gas Firepl
Page 5 and 6: BLDV7 Series Gas Fireplace product
Page 7 and 8: BLDV7 Series Gas Fireplace Before Y
Page 9 and 10: BLDV7 Series Gas Fireplace clearanc
Page 11 and 12: BLDV7 Series Gas Fireplace VENTING
Page 13 and 14: BLDV7 Series Gas Fireplace Terminat
Page 15 and 16: BLDV7 Series Gas Fireplace Vent ins
Page 17 and 18: BLDV7 Series Gas Fireplace vent ins
Page 19 and 20: BLDV7 Series Gas Fireplace 2. Remov
Page 21 and 22: BLDV7 Series Gas Fireplace vent ins
Page 23 and 24: BLDV7 Series Gas Fireplace fireplac
Page 25 and 26: BLDV7 Series Gas Fireplace glass re
Page 27 and 28: BLDV7 Series Gas Fireplace OPTIONAL
Page 29 and 30: BLDV7 Series Gas Fireplace OPERATIN
Page 33 and 34: BLDV7 Series Gas Fireplace SIGNATUR
Page 35 and 36: BLDV7 Series Gas Fireplace OPTIONAL
Page 39 and 40: BLDV7 Series Gas Fireplace FEATURES
Page 41 and 42: BLDV7 Series Gas Fireplace SIGNATUR
Page 43 and 44: BLDV7 Series Gas Fireplace final in
Page 45 and 46: BLDV7 Series Gas Fireplace cleaning
Page 47 and 48: BLDV7 Series Gas Fireplace troubles
Page 49 and 50: BLDV7 Series Gas Fireplace REPLACEM
Page 51 and 52: BLDV7 Series Gas Fireplace REPLACEM
Page 53 and 54:
BLDV7 Series Gas Fireplace REPLACEM
Page 55 and 56:
BLDV7 Series Gas Fireplace VENTING
Page 57 and 58:
BLDV7 Series Gas Fireplace VENTING
Page 59 and 60:
BLDV7 Series Limited Gas Fireplace
show all

Manual - Unvented Gas Log Heater or Vented Decorative Appliance

You also want an ePaper? Increase the reach of your titles

Delete template?

Save as template?