Sun Hydraulics Catalog - BIBUS SK, sro

More documents

Recommendations

Info

Pilot Control ValvesELECTRO-PROPORTIONAL, RELIEF VALVE, PILOT CAPACITYd2 1cb2OutletInlet 1LocatingShoulderPerformance CurvesaCapacityTypicalCartridgeModel CodeRBAPCartridge Dimensionsc***Cavity a b L X/M dInstallationTorque(Nm)1 L/min. RBAP – XAN T-8A 18,8 22,2 130,0 85,1 37,3 35 - 40***An additional 50,8 mm clearance is needed for coil installation and removal.300Constant CommandVarying FlowPressure vs. CommandFlow 0,37 L/min.300P = bar200100P = bar2001000.50 1.00 1.50Flow = L/min.2.000 20 40 60 80Command (%)■ Maximum operating pressure = 350 bar.■ Maximum valve leakage at reseat = 25 cc/min.■ Low leakage levels in the closed position. Reseat > 85% of set pressure.■ Hysteresis with dither
Pilot Control ValvesDIRECT ACTING, RELIEF VALVE, PILOT CAPACITYFull Adjustment 5 Turns+ -21cb2OutletaLocatingShoulderCapacityTypicalCartridgeModel CodeCavity a bCartridge DimensionscL C K OInstallationTorque(Nm)1 L/min. RBAC – LAN T-10A 39,7 22,2 51,0 55,0 58,0 58,0 45 - 502 L/min. RBAA – LAN T - 3A 47,8 28,6 54,0 56,0 61,0 61,0 60 - 7010 L/min. RBAE – LAN T-8A 19,1 22,2 60,5 62,7 67,6 67,6 35 - 40Inlet1Performance Curves■■■■■RBAC RBAA RBAEP = bar350300250200150100500 0,32 0,64 0,96 1,28 1,6Flow = L/min.P = barTypical Pressure Rise350300250200150100500 0,5 1,0 1,5 2,0 2,5Flow = L/min.0 2 4 6 8 10Flow = L/min.Maximum operating pressure = 350 bar.Typical response time 2 ms.Maximum valve leakage at reseat at 24 cSt = RBAC, RBAA, 0,3 cc/min.; RBAE: 1 cc/min.Back pressure on the tank port (port 2) is directly additive to the pressure settingat port 1 (inlet) at a 1:1 ratio to the valve setting.RBAE: This cartridge utilizes the Sun T-8A, 2 port cavity making it the ideal choice to use in conjunction with Sun’smain stage pilot or vent-to-operate cartridges. Separate pilot lines are eliminated and only one cavity needs to bemachined to accommodate both the control and primary function. Note: All 2-position, 2-way, pilot stage controlcartridges utilize the same cavity and are physically interchangeable. Functionality is the only consideration.P = bar400300200100OPTION ORDERING INFORMATIONR B A ✱ – ✱ ✱ ✱NominalCapacityControl** Adjustment Range Seal MaterialC 1 L/min. L Standard Screw A 1,7 - 210 bar N Buna-NAdjustmentStandard set at 70 barV VitonA 2 L/min. C*Tamper Resistant B 1,7 - 105 barFactory SetStandard set at 70 barE 10 L/min. K Handknob with C 1,7 - 420 barLock KnobStandard set at 70 barO Handknob withPanel MountD 1,7 - 55 barStandard set at 28 bar* Special setting required. E 1,7 - 28 barSpecify at time of order. Standard set at 14 barW 1,7 - 315 barStandard set at 70 barConsult the Sun website for** See page 178 our most recent and completefor informationinformation on the full Corrosionon Control OptionsResistant line of products.Visit www.sunhydraulics.com for current list pricing and complete technical information on all Sun products.Int’l Shortcut Catalogue #999-901-312 143
Page 1 and 2:
Over 35 New Products in this Catalo
Page 3 and 4:
ContentsModel Codes printed in Red
Page 5 and 6:
Relief Cartridge ValvesCartridge Ty
Page 7 and 8:
Relief ValvesDIRECT ACTING AND DIRE
Page 9 and 10:
Relief ValvesDIRECT ACTING, PILOT C
Page 11 and 12:
Relief ValvesPILOT OPERATED, BALANC
Page 13 and 14:
Page 15 and 16:
Relief Valves, Electro-Proportional
Page 17 and 18:
Page 19 and 20:
Page 21 and 22:
Relief ValvesBYPASS COMPENSATOR WIT
Page 23 and 24:
Page 25 and 26:
Sequence Cartridge ValvesCartridge
Page 27 and 28:
Sequence ValvesDIRECT ACTING WITH R
Page 29 and 30:
Sequence ValvesAIR CONTROLLED, PILO
Page 31 and 32:
Sequence Valves, Electro-Proportion
Page 33 and 34:
Reducing and Reducing/RelievingCart
Page 35 and 36:
Reducing ValvesPILOT OPERATED, AIR
Page 37 and 38:
Reducing/Relieving ValvesPILOT OPER
Page 39 and 40:
Reducing/Relieving ValvesDIRECT ACT
Page 41 and 42:
Reducing/Relieving ValvesPILOT OPER
Page 43 and 44:
Reducing/Relieving Valves, Electro-
Page 45 and 46:
Reducing/Relieving Valves, Electro-
Page 47 and 48:
Pilot-to-Open CheckCartridge Valves
Page 49 and 50:
Pilot-to-Open Check ValvesATMOSPHER
Page 51 and 52:
Counterbalance Cartridge ValvesCart
Page 53 and 54:
Series 2 Series 3 Series 4Pilot Rat
Page 55 and 56:
Counterbalance ValvesNON-VENTED, ST
Page 57 and 58:
Counterbalance ValvesNON-VENTED, SE
Page 59 and 60:
Counterbalance ValvesNON-VENTED, RE
Page 61 and 62:
Counterbalance ValvesVENTED, 280 BA
Page 63 and 64:
Load Control:Load Reactive Cartridg
Page 65 and 66:
Load Control: Load Reactive ValvesN
Page 67 and 68:
Load Control: Load Reactive ValvesV
Page 69 and 70:
Load Control:Balanced Cartridge Val
Page 71 and 72:
Load Control: BalancedVENTED, NON-R
Page 73 and 74:
Check Cartridge ValvesCartridge Typ
Page 75 and 76:
Check ValvesFREE FLOW, SIDE-TO-NOSE
Page 77 and 78:
Check ValvesFREE FLOW, SIDE-TO-NOSE
Page 79 and 80:
Flow Control Valves2Cartridge TypeP
Page 81 and 82:
Flow Control ValvesFULLY ADJUSTABLE
Page 83 and 84:
Flow Control ValvesFIXED ORIFICE, N
Page 85 and 86:
Flow Control ValvesFIXED ORIFICE, P
Page 87 and 88:
Flow Control ValvesFIXED ORIFICE, B
Page 89 and 90:
Flow Control ValvesVENTABLE, FIXED
Page 91 and 92: Flow Control Valves, Electro-Propor
Page 93 and 94: Flow Divider / CombinerCartridge Va
Page 95 and 96: Flow Divider / Combiner ValvesDIVID
Page 97 and 98: Flow Divider / Combiner ValvesDIVID
Page 99 and 100: Logic ElementsCartridge Type4421213
Page 101 and 102: Logic ElementsBALANCED POPPET, NORM
Page 109 and 110: Logic ElementsUNBALANCED POPPET, VE
Page 111 and 112: Logic ElementsUNBALANCED POPPET, PI
Page 113 and 114: Logic ElementsNORMALLY CLOSED, MODU
Page 115 and 116: Logic ElementsBI-DIRECTIONAL, MODUL
Page 117 and 118: Directional Cartridge Valves123Cart
Page 119 and 120: Directional Valves2-WAY AND 3-WAY,
Page 121 and 122: Directional Valves2-WAY AND 3-WAY D
Page 123 and 124: Directional Valves2-WAY AND 3-WAY,
Page 125 and 126: Directional Valves3-WAY, 2-POSITION
Page 127 and 128: Directional Valves2-WAY POPPET, WIT
Page 129 and 130: Directional Valves3-POSITION, 4-WAY
Page 131 and 132: Solenoid Operated Cartridge ValvesC
Page 133 and 134: Solenoid Operated Cartridge Valves2
Page 141: Pilot Control ValvesCartridge TypeP
Page 145 and 146: Pilot Control ValvesFLOW CONTROL, F
Page 147 and 148: Pilot Control Valves2-WAY, HYDRAULI
Page 149 and 150: Pilot Control Valves2-WAY, AIR OPER
Page 151 and 152: Pilot Control Valves3-WAY, 2-POSITI
Page 153 and 154: Pilot Control Valves3-WAY, 2-POSITI
Page 155 and 156: Shuttle ValvesCartridge TypePage121
Page 157 and 158: Shuttle ValvesBACK-TO-BACK CHECK/SH
Page 159 and 160: Shuttle ValvesBACK-TO-BACK CHECK/SH
Page 161 and 162: Shuttle ValvesHIGH SIDE, 3-POSITION
Page 163 and 164: Circuit SaversCartridge TypePage2Fi
Page 165 and 166: Circuit SaversAIR BLEED AND START-U
Page 167 and 168: Circuit SaversCHECK, PILOT-TO-CLOSE
Page 169 and 170: Circuit SaversACCUMULATOR SENSE, PU
Page 171 and 172: Hybrid Relief ValvesCartridge TypeP
Page 173 and 174: Hybrid ValvesDIRECT ACTING RELIEF,
Page 175 and 176: Hybrid ValvesPILOT OPERATED, BALANC
Page 177 and 178: General InformationPageCartridge Co
Page 179 and 180: Cartridge Control KitsService Kit N
Page 181 and 182: Cartridge Control KitsService KitNu
Page 183 and 184: Cavity PlugsIt is sometimes desirab
Page 185 and 186: Cavity PlugsPlugs for Six Port Cavi
Page 187: Sun Coil Options for Solenoids (Met
Page 191 and 192: Sun Coil 790-***** Part Numbering S
Page 193 and 194:
Sun Model Code SystemSun cartridges
Page 195 and 196:
Model Code IndexModel Code Cavity P
Page 197 and 198:
Model Code IndexModel Code Cavity P
Page 199 and 200:
WarrantyWARRANTY INFORMATION,PERFOR
Page 201:
MexicoCOUNTRYDISTRIBUTORComponentes
show all

Sun Hydraulics Catalog - BIBUS SK, sro

Create successful ePaper yourself

Delete template?

Save as template?